Since the declaration of COVID-19 as a global pandemic on March 11, 2020, this pandemic has been circulating for 17 months throughout the world, leading to more than 200 million infections and nearly 4.4 million deaths as of August 15, 2021. The pathogen of COVID-19 is a novel coronavirus named SARS-CoV-2, which shares ~79% genome sequence identity with SARS-CoV.1 At the early stage of the COVID-19 outbreak, SARS-CoV-2 caused great panic in the hardest-hit areas due to its high transmissibility and pathogenicity. To fight the COVID-19 crisis, drug repurposing was immediately pursued in order to find potential therapeutics. Until now, though some treatment options are available, there still lack effective antiviral agents. Vaccination is considered as the best way to control this global pandemic, but the emerging SARS-CoV-2 variants pose a great challenge to the protective efficacy of the existing vaccines. Hence, in the long run, finding an effective antiviral medication against the SARS-CoV-2 infection is a pressing need.
Great efforts have been put into the development of novel drugs against SARS-CoV-2 infection. Currently, remdesivir (RDV) (Fig. 1a), an intravenously administered nucleotide prodrug, is the only approved anti-SARS-CoV-2 drug. However, it displays limited therapeutic efficacy especially for severe COVID-19 cases.2 Nucleoside analogs are an important class of antivirals acting by interfering with the viral polymerases that are highly conserved in the active center. Besides RDV, two oral nucleoside analogs, molnupiravir (EIDD-2801)3 and AT-527,4 have entered phase II/III clinical studies. Herein, we reported the discovery of an oral anti-SARS-CoV-2 nucleoside candidate, VV116, which displays favorable drug-like properties, and is going to be evaluated in clinical study for treating COVID-19.
At the onset of the COVID-19 outbreak, we conducted a fast in vitro screening for anti-SARS-CoV-2 activity of various nucleoside/nucleotide analogs (listed in Supplementary information, Table S1) in Vero E6 cells. Most of these compounds are known antiviral agents that show inhibitory activities against one or several viruses. Among them, we discovered that only RDV and its parent nucleoside (GS-441524) could remarkably inhibit the replication of SARS-CoV-2 at 5.0 µM. Determination of their EC50 values indicated that GS-441524 with an EC50 of 0.59 µM was a stronger viral replication inhibitor than RDV in Vero E6 cells (Fig. 1b). RDV is a phosphoramidate prodrug of GS-441524, originally designed for enhancing the antiviral activity against hepatitis C virus.5 This kind of prodrug exhibits liver-targeting property, and may not be suitable for application in nucleoside-based antiviral therapy for COVID-19 since lungs are the most affected organs. Therefore, we chose GS-441524 as the parent structure for modifications to achieve improved druggability against SARS-CoV-2.6
A previous study showed that substituents at the 7-position (purine numbering) of the pyrrolotriazine base had a great influence on the antiviral activities of the pyrrolotriazine C-nucleosides.7 Hence, we modified GS-441524 by introducing different groups (halogen, hydroxyl or cyano) at this site. Among the six synthesized derivatives (A1–A6, Fig. 1a), only the fluoro-substituted nucleoside A1 showed moderate anti-SARS-CoV-2 activity with an EC50 of 3.3 µM (Supplementary information, Table S2), which was ~5-fold less potent than GS-441524. Structural modifications at the 1′- and 2′-positions of this nucleoside were also conducted. We found that removal of the 1′-CN of GS-441524 afforded a highly cytotoxic nucleoside A7, and conversion of the 6-amino group to hydroxyl group or methylation of the 2′-α-OH abolished the antiviral activity (A8 and A9). Two other derivatives (A10 and A11) derived from GS-441524 by removing the 1′-CN and replacing the 2′-α-OH with a α-fluoro or a 2′,2′-difluoro group did not exhibit anti-SARS-CoV-2 activity, either. From the above result, it seemed that the frequently-used structural modifications were not tolerated on this nucleoside, and subtle changes would lead to a significant decrease or loss of antiviral activity.
GS-441524 has an adenine-mimicking pyrrolotriazine base that is characterized by an electron-rich double bond and a 1,2,4-triazine ring. This unnatural base might be more vulnerable to enzymatic degradation through oxidation of the double bond or ring opening of the triazine moiety. Therefore, we attempted to modify GS-441524 by deuteration that may confer potential pharmacokinetic (PK) benefits. Due to the synthetic difficulties, we only obtained the 7-deuterated derivative X1 (Fig. 1a). This nucleoside displayed strong antiviral activity with an EC50 value of 0.39 ± 0.08 µM (Fig. 1b), and was found to have poor water solubility and liposolubility, which likely led to its low oral bioavailability in rats (F = 21.7%; Fig. 1c and Supplementary information, Table S3). To improve the oral bioavailability, several ester prodrugs of X1 were designed by introducing mono-, di- and tri-esters at the 2′-, 3′-, and 5′-positions of the ribose fragment. PK studies in rats showed that the 3′-isobutyrate prodrug X3 had a moderate bioavailability (F = 46.5%; Fig. 1c and Supplementary information, Table S3), which was about 2.1 times of that of X1, and 1.4 times of that of the 5′-isobutyrate prodrug X2 (F = 32.6%; Fig. 1c and Supplementary information, Table S3). However, the subsequent PK study in monkeys did not reveal a satisfying bioavailability (F = 18.4%; Supplementary information, Table S4) for X3. Therefore, this prodrug was not further evaluated. The 2′,3′-di-isobutyrate ester X4 (Fig. 1a) was obtained as a gummy substance, and then subjected to salt formation. The resulting two solids, the hydrochloride and the sulfate salts of X4, were highly hydroscopic, which was not favorable for pharmaceutical application. For the 3′,5′-di-isobutyrate ester X5 (Fig. 1a), it suffered from an inevitable impurity due to the 3′-isobutyryl group migration to the 2′-position. The tri-isobutyrate ester X6 (Fig. 1a) had a good oral bioavailability (F = ~50%) in rats (Fig. 1c and Supplementary information, Table S3), and was superior to X3 in terms of the plasma concentration and the plasma exposure of the parent nucleoside X1. Because X6 was difficult to be crystallized, an intensive salt screening of X6 was performed. Among all the solids obtained, the hydrobromide salt (VV116) was finally identified as the most qualified candidate. VV116 was not hygroscopic, and showed a good chemical stability over high temperature (60 °C), lights, or high humidity for weeks. This salt had a remarkably improved oral bioavailability (F = ~80%; Supplementary information, Table S6) in rats in the subsequent preclinical study.
Then, we evaluated the anti-SARS-CoV-2 efficacy of orally administered VV116 (25 mg/kg, 50 mg/kg or 100 mg/kg, BID) in hACE2-transduced mice8 with EIDD-2801 as the positive control (250 mg/kg or 500 mg/kg, BID) (Supplementary information, Fig. S4). VV116 presented a dose-dependent efficacy in reducing the viral RNA copies and infectious virus titers in the lungs (Fig. 1d). At day 2 post infection (p.i.) when viral loads peaked, there was a 0.5 log10, 0.70 log10, and 1.0 log10 reduction in the RNA copies for the three VV116 groups, respectively, and at day 5 p.i., more prominent efficacy was observed (1.1 log10, 1.3 log10 and 1.7 log10 decrease in the RNA copies, respectively). With respect to the infectious virus titers, treatment of VV116 at a low dose (25 mg/kg) resulted in a 2.0 log10 reduction at day 2 p.i., and a 3.0 log10 reduction at day 5 p.i. The medium dose (50 mg/kg) of VV116 exhibited a stronger activity, and decreased the virus titers below the detection limit at day 5 p.i. For the high dose (100 mg/kg) of VV116 and the two doses of EIDD-2801 (250 mg/kg or 500 mg/kg), the virus titers were reduced below the detection limit at both day 2 and day 5 p.i. Histopathology examination of lung tissues revealed that there was moderate interstitial pneumonia in vehicle-treated mice at day 2 p.i. characterized with thickened alveolar septa, infiltration of inflammatory cells and necrotic debris, while the area and degree of interstitial inflammatory lesions in 100 mg/kg VV116-treated mice were significantly improved (Supplementary information, Fig. S5 and Table S5).
Scalable synthesis of X1 was successfully achieved using deuterium gas as the deuterating agent, thus ensuring the supply of VV116 required for preclinical evaluation. VV116 functioned by targeting the viral RNA-dependent RNA polymerase through its nucleoside triphosphate form with an IC50 of 0.67 ± 0.24 μM (Supplementary information, Fig. S2). The preclinical safety evaluation showed that the maximal tolerated single doses of VV116 were at least 2.0 g/kg and 1.0 g/kg in rats and Beagle dogs, respectively. For the 14 days repeated dose toxicity studies, the no observed adverse effect levels (NOAELs) were 200 mg/kg and 30 mg/kg in rats and dogs, respectively (details shown in Supplementary information). VV116 and X1 exerted little effect on hERG current, and showed no mutagenicity according to the results of the Ames test and micronucleus test of bone marrow cells. PK results showed that VV116 had high oral bioavailability, reaching 80% and 90% in rats and dogs, respectively (Supplementary information, Tables S6–S11). The key metabolite X1 was widely distributed in rat tissues (Supplementary information, Fig. S3) of the intestine, lung, kidney, liver, heart, and brain, most of which are the preferred targets of SARS-CoV-2. This property of VV116 would confer potential advantages for the treatment of SARS-CoV-2 infection.
The above preclinical results prove VV116 as a safe and effective oral nucleoside drug candidate against SARS-CoV-2. The clinical studies of VV116 will be fast-tracked considering the tremendous threat caused by the rapid spread of SARS-CoV-2 variants.
Lu, R. et al. Lancet 395, 565–574 (2020).
Wang, Y. et al. Lancet 395, 1569–1578 (2020).
Cox, R. M., Wolf, J. D. & Plemper, R. K. Nat. Microbiol. 6, 11–18 (2021).
Good, S. S. et al. Antimicrob Agents Chemother 65, e02479–20 (2021).
Butler, T., Cho, A., Kim, C. U., Saunders, O. L. & Zhang, L. WO2009132135A1 (2009).
Wei, D. et al. Bioorg. Med. Chem. 46, 116364 (2021).
Draffan, A. G. et al. Bioorg. Med. Chem. Lett. 24, 4984–4988 (2014).
Sun, J. et al. Cell 182, 734–743.e5 (2020).
This work was partially supported by the 2020 ANSO Collaborative Research Project (ANSO-CR-SP-2020-03 to J.S.), the National Science & Technology Major Project “Key New Drug Creation and Manufacturing Program” of China (2018ZX09711002 to H.J.), the National Key R&D Program of China (2018YFA0507002 to H.E.X.), Shanghai Municipal Science and Technology Major Project (2019SHZDZX02 to H.E.X.), the Strategic Priority Research Program of Chinese Academy of Sciences (XDB37030103 to H.E.X.), the Youth Innovation Promotion Association of Chinese Academy of Sciences (2018367 to L.Z. and 2021278 to W.Y.), Shanghai Science and Technology Committee (21S11903100 to Y.X.), and the National Natural Science Foundation of China (31970165 to L.Z.). The authors thank Dongye Shen for his contribution to English editing and polishing of the manuscript.
Y.Xie, L.Z., G.X., H.J., H.E.X., G.T. and J.S. filed a patent application on antiviral nucleoside analogs.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons license, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons license and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Xie, Y., Yin, W., Zhang, Y. et al. Design and development of an oral remdesivir derivative VV116 against SARS-CoV-2. Cell Res 31, 1212–1214 (2021). https://doi.org/10.1038/s41422-021-00570-1
This article is cited by
Development and validation of a nomogram to predict failure of 14-day negative nucleic acid conversion in adults with non-severe COVID-19 during the Omicron surge: a retrospective multicenter study
Infectious Diseases of Poverty (2023)
Deuterium in drug discovery: progress, opportunities and challenges
Nature Reviews Drug Discovery (2023)
A new generation Mpro inhibitor with potent activity against SARS-CoV-2 Omicron variants
Signal Transduction and Targeted Therapy (2023)
Human Identical Sequences, hyaluronan, and hymecromone ─ the new mechanism and management of COVID-19
Molecular Biomedicine (2022)
Oral remdesivir derivative VV116 is a potent inhibitor of respiratory syncytial virus with efficacy in mouse model
Signal Transduction and Targeted Therapy (2022)