We show that defined lymphocytes can be rapidly purified by immunoaffinity chromatography starting directly from whole blood. The method relies on low-affinity Fab-fragments attached to a column-matrix combined with the reversible Strep-tag technology. Compared to established cell enrichment protocols, the Strep-tag affinity chromatography of cells is independent of erythrocyte lysis or centrifugation steps, allowing for simple cell-enrichment with good yields, high purities, and excellent functionality of purified cells.
The quick and non-altering processing of cell products is an essential procedure in clinical and basic research. In the last two decades, isolation of cells from blood has been carried out using high-affinity antibodies and magnetic bead technology1,2. Although good purities and reasonable yields can often be obtained, major disadvantages remain, like compromising biological interference of non-reversible selection reagents (high-affinity antibodies), the need for pre-enrichment, as well as the difficulty in purifying complex multiparametric cell populations by positive selection3. Cell isolation protocols based on negative selection circumvent these limitations but have the drawback of often being not as ‘specific’ and ‘pure’ as compared to positive enrichment4. Therefore, we intended to develop a positive cell isolation method, which would overcome the major obstacles of conventional isolation methods.
We previously described a method using reversible Fab multimers, which allowed the positive enrichment of cells and subsequent release of isolation reagents from the cell surface using D-Biotin3,5. This approach can preserve the original functionality of purified cells in vitro as well as upon in vivo transfer and engraftment5,6. While the cell isolation using reversible Fab multimers could overcome some problems otherwise caused by high-affinity antibodies, whole blood specimens still required removal of erythrocytes before the selection process. This can be achieved either by density gradient centrifugation or osmotic lysis of red blood cells. Density centrifugation unfortunately often goes along with a significant loss of lymphocytes, with a reported mean recovery rate around 65%7, and potentially alters cell competence due to hyperosmolarity of the used reagents8. Direct erythrocyte lysis affects lymphocyte viability, cell composition and thereby potentially functionality9. Furthermore, released erythrocyte components can interfere with assay systems10,11,12. In order to improve the isolation of cells from whole blood for therapeutic, diagnostic or research applications, it would be desirable to maximize the cell yield of enrichment by minimizing initial cell loss during PBMCs generation, as well as to prevent altering the results of the subsequent analyses by skewing of functional properties of cells by antibodies. First attempts in this field have already focused on immunoaffinity chromatography (IAC)-like procedures13,14,15, but did not lead to broader applicability in basic research or clinical studies despite the potential advantages. With this report, we describe the successful transfer of a well-established platform for protein purification (Strep-tag based affinity chromatography)16,17 to direct processing and isolation of cells from whole blood reducing the processing times to a minimum and still providing high yields and purities.
The Strep-tag based immunoaffinity chromatography we developed is based on an isolation matrix consisting of agarose beads, functionalized with Strep-Tactin on the bead surface (cell-grade agarose). This cell-grade agarose was filled in plastic mini-columns with frits similar to commonly used GE PD-10 desalting columns and subsequently coated with recombinant strep-tagged Fab-fragments targeting the desired cell-specific surface marker (Fig. 1A). Afterwards, a cell suspension, like whole blood, is pipetted directly onto the column and soaked into/through the column by gravity flow. At this step, marker-positive cells are held back in the column by binding to the Fab molecules on the bead surface, whereas other cells pass through. To elute remaining marker-negative cells, the column is washed with four column volumes wash buffer. (Fig. 1B). For elution of target cells, 1 mM Biotin Elution Buffer is added, which leads to rapid disruption of the Fab Strep-Tactin binding and thereby the release of cells from the matrix. Remaining monomeric Fab molecules on the target cell surface subsequently dissociate due to their low affinity and are washed away (Fig. 1C).
As a first proof-of-concept that the outlined procedure is indeed capable of realizing immunoaffinity chromatography of defined cell populations, we charged the column with anti-CD3 Fab to enrich CD3+ T cells from human whole blood samples. Immunoaffinity chromatography resulted in a ‘positive enrichment fraction’ of highly pure CD3+ T lymphocytes, whereas the ‘flow-through fraction’ was almost entirely liberated from this cell population, demonstrating a very high purification efficiency and yield (Fig. 1D). Very similar results could be obtained for multiple independent experiments and also for the enrichment of CD4-positive cells (monocytes (CD4low) and T cells (CD4high)) (Fig. 1E), showing the robustness and versatility of the method. With overall cell-processing times of usually considerably below one hour (the total processing time depends primarily on the sample volume; e.g. an enrichment of CD3-positive cells out of 10 ml whole blood/buffy coat takes 40 minutes), IAC allows enriching cells faster than currently available cell separation methods, thereby making no compromises on overall yield and purity of the enrichment process. To make sure that these encouraging results are not limited to T lymphocyte enrichment, we further broadened targeting reagents to enrich for CD19+ B cells, CD14+ cells (expressed on monocytes and granulocytes) or CD31+ human umbilical vein endothelial cells (HUVECs), directly from the digested vein solution. All populations were enriched with similarly high purities and yields (Fig. S1A,B,C). Next, we analyzed whether different sources of starting material (fresh whole blood, buffy coat, human cord blood, single cell suspensions from cell cultures, and splenocyte solutions from mice) could be processed with this new method. And indeed, from all tested cell specimens, we could enrich target populations with high yields and purities (Figs S1,S2,S3). Coating the affinity-matrix with streptag-ed epitope/MHC, I complexes5,18,19 even allow to enrich antigen-specific CD8+ cells with high purity and specificity (Fig. S3), demonstrating that the approach is not limited to antibody-derived Fab fragments as isolation reagents.
To scale up the number of processed cells, we used buffy coats as starting material. For larger cell numbers IAC decreases the relative processing times per target cell even more dramatically, thereby retaining the high purity and yield of the enrichment for CD3-positive T cells (Fig. 2A). We further show that enriched cells are neither harmed nor functionally impaired by IAC (Fig. 2B–H). Therefore, we first determined the viability of purified T cells. We found that for CD3, CD4 or CD8 targeted enrichment the overall survival was in all cases very high (<97%) (Fig. 2B), indicating that there is no detectable impact on cell viability. This is also true for other cell types; even the relatively harsh collagen-based tissue mobilization procedure of HUVECs can provide good survival of primary isolated cells (Fig. S1D).
In order to analyze whether the Fab-based IAC might influence the quality of separated cells, we further explored functional parameters. As the T cell-specific Fab fragment’s parental antibody clone (CD3 clone: OKT3) is known to activate T cells, we checked for the upregulation of CD69, as an early activation marker, and the induction of proliferation by CFSE as a later activation marker of T cells after isolation of CD3 positive T cells. As shown in Fig. 2C, we could not detect any signs of CD69 upregulation on CD3+ target cells, analyzed 1 h and 24 h after isolation; however, controls that were re-stimulated in vitro by addition of the OKT3 monoclonal antibody showed a strong CD69 upregulation after 24 h. Similarly, anti-CD8 isolation also did not show any signs of CD69 upregulation through the selection procedure. In addition, no changes in CFSE expression could be observed without further in vitro stimulation (Fig. 2D). Overall, these data demonstrate that separation via Fab-based immunoaffinity chromatography did not lead to any detectable changes in cell viability or cell activation.
In order to test whether cell immunoaffinity chromatography is comparable to current standard technologies, we performed Fab-based IAC in parallel to a conventional, commercially available, two-step isolation process (density gradient separation of the blood samples followed by enrichment with paramagnetic beads) on the same donor samples. Both isolation processes resulted in a final product with high target cell purity. However, the conventional enrichment was characterized by significantly lower target cell yields (Fig. 2E,F), which was mainly due to the cell loss during initial PBMC generation.
After demonstrating the general effectivness of Fab-based enrichment and the ‘unchanged’ phenotype of purified cell products, we wanted to test the procedure in settings with direct clinical relevance. Adoptive T cell therapy (ACT) has proven to be a potentially curative treatment for different diseases. Antigen-specific redirection of T cells by introduction of a new T cell receptor (TCR) or chimeric antigen receptor (CAR) has the potential to improve flexibility, applicability and therapeutic outcome of ACT20,21,22. The enrichment of defined lymphocyte subsets is becoming increasingly crucial for the generation of these engineered immune cells. To asses the applicability of IAC enrichment for ACT, we compared retroviral transduction-efficacy of CD3+ T cells enriched by IAC to conventional methods. Transgenic expression of CMV-specific TCRs or CAR (αCD19) resulted in very similar transduction efficacies for both enrichment procedures (Fig. 2G). Also when testing the engineered cell products functionally in target cell killing assays, no significant differences depending on the enrichment procedure could be detected (Fig. 2H). These data demonstrate that cell affinity chromatography is also fully compatible with current genetic engineering approaches.
Here we report for the first time a method combining immunoaffinity chromatography and the advantages of the reversible Streptag/biotin system for cell enrichment. Cellgrade Agarose and target antigen-specific Fab/MHC-streptag fusion-proteins act as an affinity matrix to bind the cell population of interest. After the addition of low concentrations of D-biotin, the binding to the matrix is rapidly reversed and cells can be eluted. Merging the advantages of reversible cell labeling with classical IAC results in a new cell isolation technology that combines simple handling with fast processing times and can be used for cell enrichment directly from whole blood, buffy coat- or apheresis-samples, circumventing the requirement of centrifugation-based density gradient PBMC generation. This novel approach should be attractive for basic research, diagnostic and therapeutic applications and can be transferred to completely automated cell selection platforms.
Immunoaffinity chromatography (IAC)
Cell-grade agarose (IBA GmbH; Göttingen, Germany) was filled into plastic columns and enclosed by an upper and lower frit (GE Healthcare) in PBS. After removal of air from the column matrix and frits by application of vacuum the columns were ready to use. The frits have been de-aired using 80% Ethanol before fitting them into the columns.
The columns were coated with recombinant strep-tagged Fab-fragments/MHC-I molecules targeting the desired cell-specific surface marker for 5 minutes. Afterwards, a single cell suspension is pipetted directly onto the column and soaked into/through the column by gravity flow. The column is washed with four column volumes wash buffer (PBS/0.5% BSA/1 mM EDTA, ph 7.4). 20 ml D-biotin elution buffer (PBS/0.5% BSA/1 mM EDTA/1 mM D-biotin; ph 7.4) is added, releasing the cells from the matrix.
Peripheral blood samples (whole blood sampels) were obtained from healthy adult donors of both sexes at the Institute of Medical Microbiology, Immunology and Hygiene (Technical University of Munich), and buffy-coats were obtained from autologous male or female blood donors (18–82 years old) at the Institute for Anesthesiology, German Heart Centre Munich (State of Bavaria and Technical University Munich). Cord Blood samples were obtained by the Klinik und Poliklinik für Frauenheilkunde, Technical University of Munich, Munich, Germany. The written informed consent was obtained from the donors, and usage of the blood samples was approved according to national law by the local Institutional Review Board (Ethikkommission der Medizinischen Fakultät der Technischen Universität München). To all blood specimens and single cell solutions, anti-coagulant was added during the initial processing steps. We used either Heparin (for whole blood and cord blood samples), acid-citrate-dextrose to buffy coat samples or EDTA (1 mM) to splenocyte single cell solutions.
Fab monomer generation
The monomeric Fab Fragments were produced as described previously3. In short, monomeric Fab fragments originating from monoclonal antibodies were generated by gene synthesis (Invitrogen) or by PCR-based cloning of the variable region from hybridomas. The parental clones used are aCD3:OKT323; aCD4:13B8.224; aCD8:OKT823; aCD14:2F9 (iba GmbH; Göttingen; Germany), aCD19:4G725 and aCD31:10F7 (Synaptic Systems, Göttingen, Germany). Following the cloning, Fab Monomers were periplasmatically expressed in E.coli and the recombinant protein harvested as described before26,27; subsequently, Fab-fragments were purified by Strep-tag/Strep-Tactin affinity chromatography via a Strep-Tactin Superflow column (IBA GmbH, Göttingen, Germany) and stored in PBS pH 7.517. After generation and verification, in some cases mutagenesis PCR was applied to introduce single amino acid substitutions within the non-hypervariable framework regions28 to reduce the affinity of monomeric Fabs.
For FACS analysis cells were stained for 20 minutes at 4 °C by the application of the respective antibodies: aCD4 PE (RM4-5), aCD8 PE-Cyanine7 (53-6.7), aCD3 APC (OKT3), aCD14 APC (61D3), aCD31 (WM-59) (all from eBioscience; Frankfurt am Main, Germany). For live dead discrimination propidium iodide (Molecular Probes, Eugene, Oregon) was used. MHC-I staining was performed for 45 minutes at 4 °C using Strept-Tactin APC backbone (IBA GmbH, Göttingen, Germany). Data were collected by flow cytometry on a CyAn ADP Lx (Beckman Coulter) and analyzed with FlowJo software (TreeStar). Absolute cell numbers were calculated using 123 count beads (Thermo Fisher Scientific, Waltham, USA).
xCelligence kill assay
2 × 104 CD19 presenting Human embryonic kidney cells (HEK293-CD19+) were seated into E-Plate 96 (ACEA, Biosciences Inc. San Diego. USA). After resting CAR-positive cells were added in a 1:1 ratio and incubated for 2 days while measuring. For analysis, only the first 26 h were analyzed, as afterwards unspecific cell death was observed.
CFSE dilution assay
Cells were isolated using CD3 IAC and stained with CFSE (Thermo Fisher Scientific, Waltham, USA) according to manufacturer’s protocol. Afterwards the cells were stimulated with CD3/CD28 Streptamers for T cell expansion (IBA GmbH, Göttingen Germany) according to manufacturer’s protocol for three days and proliferation was assessed using FACS analysis.
Conventional cell enrichment
PBMCs were generated using Biocoll Separating Solution (Dens 1.077 g/ml) (Biochrom GmbH, Berlin, Germany) according to manufacturer’s protocol. Cells were positively enriched using the LS columns and CD8 MicroBeads according to manufacturer’s protocol (Miltenyi Biotec, Bergisch Gladbach, Germany).
Miltenyi, S., Müller, W., Weichel, W. & Radbruch, A. High gradient magnetic cell separation with MACS. Cytometry 11, 231–8 (1990).
Grützkau, A. & Radbruch, A. Small but mighty: How the MACS1-technology based on nanosized superparamagnetic particles has helped to analyze the immune system within the last 20 years. Cytom. Part A 77, 643–647 (2010).
Stemberger, C. et al. Novel serial positive enrichment technology enables clinical multiparameter cell sorting. PLoS One 7, e35798 (2012).
Plouffe, B. D., Murthy, S. K. & Lewis, L. H. Fundamentals and application of magnetic particles in cell isolation and enrichment: a review. Rep. Prog. Phys. 78, 016601 (2015).
Knabel, M. et al. Reversible MHC multimer staining for functional isolation of T-cell populations and effective adoptive transfer. Nat. Med. 8, 631–637 (2002).
Mohr, F. et al. Minimally manipulated murine regulatory T cells purified by reversible Fab Multimers are potent suppressors for adoptive T-cell therapy. Eur. J. Immunol. 47, 2153–2162 (2017).
Schlenke, P. et al. Evaluation of a novel mononuclear cell isolation procedure for serological HLA typing. Clin. Diagn. Lab. Immunol. 5, 808–813 (1998).
Mallone, R. et al. Isolation and preservation of peripheral blood mononuclear cells for analysis of islet antigen-reactive T cell responses: position statement of the T-Cell Workshop Committee of the Immunology of Diabetes Society. Clin. Exp. Immunol. 163, 33–49 (2011).
Lin, S. J., Chao, H. C., Yan, D. C. & Huang, Y. J. Expression of adhesion molecules on T lymphocytes in young children and infants - A comparative study using whole blood lysis or density gradient separation. Clin. Lab. Haematol. 24, 353–359 (2002).
Darbonne, W. C. et al. Red blood cells are a sink for interleukin 8, a leukocyte chemotaxin. J. Clin. Invest. 88, 1362–1369 (1991).
Neote, K., Darbonne, W., Ogez, J., Horuk, R. & Schall, T. J. Identification of a promiscuous inflammatory peptide receptor on the surface of red blood cells. J. Biol. Chem. 268, 12247–12249 (1993).
Karsten, E., Breen, E. & Herbert, B. R. Red blood cells are dynamic reservoirs of cytokines. Sci. Rep. 8, 1–12 (2018).
Moser, A. & Hage, D. Immunoaffinity chromatography: an introduction to applications and recent developments. Bioanalysis 2, 769–790 (2010).
Kataoka, K., Sakurai, Y., Hanai, T., Maruyama, A. & Tsuruta, T. Immunoaffinity chromatography of lymphocyte subpopulations using tert-amine derived matrices with adsorbed antibodies. Biomaterials 9, 218–224 (1988).
Kumar, A. & Srivastava, A. Cell separation using cryogel-based affinity chromatography. Nat. Protoc. 5, 1737–47 (2010).
Schmidt, T. G. M. & Skerra, A. One-step affinity purification of bacterially produced proteins by means of the ‘Strep tag’ and immobilized recombinant core streptavidin. J. Chromatogr. A 676, 337–345 (1994).
Schmidt, T. G. M. & Skerra, A. The Strep-tag system for one-step purification and high-affinity detection or capturing of proteins. Nat. Protoc. 2, 1528–1535 (2007).
Nauerth, M. et al. TCR-ligand koff rate correlates with the protective capacity of antigen-specific CD8+ T cells for adoptive transfer. Sci. Transl. Med. 5, 192ra87 (2013).
Nauerth, M. et al. Flow cytometry-based TCR-ligand Koff-rate assay for fast avidity screening of even very small antigen-specific T cell populations ex vivo. Cytom. Part A, https://doi.org/10.1002/cyto.a.22933 (2016).
Morgan, R. A. et al. Cancer Regression in Patients After Transfer of Genetically Engineered Lymphocytes. Science (80-.). 314, 126–129 (2006).
Kochenderfer, J. N. et al. Eradication of B-lineage cells and regression of lymphoma in a patient treated with autologous T cells genetically engineered to recognize CD19. Blood 116, 4099–4102 (2010).
Kalos, M. et al. T Cells with Chimeric Antigen Receptors Have Potent Antitumor Effects and Can Establish Memory in Patients with Advanced Leukemia. Sci. Transl. Med. 3, 95ra73 (2011).
Hoffman, R. A., Kung, P. C., Hansen, W. P. & Goldstein, G. Simple and rapid measurement of human T lymphocytes and their subclasses in peripheral blood. Proc. Natl. Acad. Sci. USA 77, 4914–4917 (1980).
Bès, C. et al. The chimeric mouse-human anti-CD4 Fab 13B8.2 expressed in baculovirus inhibits both antigen presentation and HIV-1 promoter activation. Hum. Antibodies 10, 67–76 (2001).
Kügler, M. et al. Stabilization and humanization of a single-chain Fv antibody fragment specific for human lymphocyte antigen CD19 by designed point mutations and CDR-grafting onto a human framework. Protein Eng. Des. Sel. 22, 135–147 (2009).
Fiedler, M. & Skerra, A. Use of Thiophilic Adsorption Chromatography for the One- Step Purification of a Bacterially Produced Antibody F. Culture 427, 421–427 (1999).
Schlapschy, M. et al. Functional humanization of an anti-CD30 Fab fragment for the immunotherapy of Hodgkin’s lymphoma using an in vitro evolution approach. rotein Eng. Des. Sel. 17, 847–860 (2004).
Bès, C. et al. Mapping the paratope of anti-CD4 recombinant Fab 13B8.2 by combining parallel peptide synthesis and site-directed mutagenesis. J. Biol. Chem. 278, 14265–73 (2003).
Dössinger, G. et al. MHC Multimer-Guided and Cell Culture-Independent Isolation of Functional T Cell Receptors from Single Cells Facilitates TCR Identification for Immunotherapy. PLoS One 8 (2013).
Paszkiewicz, P. J. et al. Targeted antibody-mediated depletion of CD19 CAR-T cells permanently reverses B cell aplasia. J. Clin. Invest. 126, 1–11 (2016).
This work was supported by the TUM Institute for Advanced Study and the SFB 1054 (TP-B09).
H.S., F.L. and M.L.K. are members of IBA GmbH. S.P., C.S. and S.D. are members of Juno Therapeutics GmbH. D.H.B. invented the basic Streptamer technology, H.S. invented the immunoaffinity chromatography method (patent pending). None of the other authors declare any commercial or financial conflict of interest.
Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Electronic supplementary material
About this article
Cite this article
Mohr, F., Przibilla, S., Leonhardt, F. et al. Efficient immunoaffinity chromatography of lymphocytes directly from whole blood. Sci Rep 8, 16731 (2018). https://doi.org/10.1038/s41598-018-34589-z
- Immunoaffinity Chromatography (IAC)
- Cell Enrichment
- Column Volumes Wash Buffer
- Monomeric Fab
- German Heart Center Munich
Cytometry Part A (2020)
Acta Biomaterialia (2020)