Traditional Chinese liquor (Baijiu) solid state fermentation technology has lasted for several thousand years. The microbial communities that enrich in liquor starter are important for fermentation. However, the microbial communities are still under-characterized. In this study, 454 pyrosequencing technology was applied to comprehensively analyze the microbial diversity, function and dynamics of two most-consumed liquor starters (Jiang- and Nong-flavor) during production. In total, 315 and 83 bacterial genera and 72 and 47 fungal genera were identified in Jiang- and Nong-flavor liquor starter, respectively. The relatively high diversity was observed when the temperature increased to 70 and 62 °C for Jiang- and Nong-flavor liquor starter, respectively. Some thermophilic fungi have already been isolated. Microbial communities that might contribute to ethanol fermentation, saccharification and flavor development were identified and shown to be core communities in correlation-based network analysis. The predictively functional profile of bacterial communities showed significant difference in energy, carbohydrate and amino acid metabolism and the degradation of aromatic compounds between the two kinds of liquor starters. Here we report these liquor starters as a new functionally microbial resource, which can be used for discovering thermophilic and aerobic enzymes and for food and feed preservation.
Chinese liquor (Baijiu), approximately 40-60% alcohol by volume, is one of the world’s four most popular distilled spirits along with whisky, brandy and vodka. Chinese liquor production accounts for more than one-third of all spirits consumed in the world according to the International Wine and Spirit Research Group. The unique and traditional Chinese solid simultaneous saccharification and fermentation (SSF) technology have existed for more than 4000 years1,2. Even more intriguing, microbial communities associated with environmentally-enriched for Chinese liquor fermentation was significantly different from those of most western spirit productions3. Chinese liquor is classified primarily by its distinctive flavor and taste4. Nong-flavor (NF, also called thick flavor and strong flavor) liquor accounts for more than 70% of the Chinese liquor market4. Meanwhile, the consumption of Jiang-flavor (JF, also called sauce flavor) liquor has increased in recent years according to the China National Food Industry Association. These two most-consumed and popular liquors are highly valued in Chinese culinary culture4.
The liquor SSF process is mainly attributed to the interaction and metabolism of microbes in liquor starter (daqu), zaopei and pit mud5. Among them, liquor starter is important for saccharification, fermentation and flavor-generation and is the most essential component for the production of Chinese liquor6. The production process for both NF and JF liquor starters usually takes approximately four months (Fig. 1a). Briefly, ground wheat is mixed with water and shaped into blocks, which are spontaneously fermented in a fermentation room for approximately one month and then dried in a storage room for another three months to mature5. During the one month period of fermentation, the room temperatures increase to 50 and 55 °C after three days, and quickly reach the highest values of 62 and 70 °C after around six and seven days for NF and JF liquor starters, respectively. This high temperature continues for approximately 7–8 days. After the high-temperature stage, the room temperature will finally decrease to approximately 25 °C. Both the NF and JF starters use wheat as feedstock, and no microorganisms are intentionally inoculated, as all the microbes are enriched from the feedstock, water, air and working environment. The main difference between the production processes of these two liquor starters is the changes of room temperature, which is mainly generated by microbial metabolic heat and is controlled by the placement of the starter blocks, turning over the blocks and ventilation. As NF liquor starter is characterized by moderately high temperature (62 °C), the blocks are usually tiled, spread and covered with a layer of straw in the fermentation room. The blocks must be turned every day to maintain the moderately high temperature for 8 days. However, JF is a high-temperature liquor starter (70 °C), so the blocks are heaped up and covered in thick straw. The blocks are only turned two or three times during the high-temperature period. Therefore, the dynamics of the microbial composition during the liquor starter production process are mainly determined by the working environment and the changes of room temperature during the liquor starter production process.
The liquor SSF process is a highly skilled and mature technology, and the microbial community in liquor starter is highly stable with a long history7. Nonetheless, the microbial diversity, function and dynamics of liquor starter, which are related to the dynamic changes of room temperature during production, have remained under-characterized. Microbial communities have been analyzed by traditional and molecular methods, e.g., culture-dependent methods8,9,10 and culture-independent PCR-DGGE5,9,10,11,12,13. However, many issues exist with these methods, such as missing most of the unculturable strains, time-consuming procedures, high workload, changing microbial composition, high cost, and, most importantly, a limited understanding of the microbial communities under study. Advances in high-throughput sequencing technology, such as 454 pyrosequencing, can comprehensively analyze the composition, diversity and richness of the microbial community for many samples in a single run14. Based on pyrosequencing analysis, the Fen liquor starter (also called qing flavor (QF) and light flavor) production process was found to have abundant microbes in the families Lactobacillaceae, Bacillacae and Saccharomycetaceae15,16. It was also shown that Firmicutes and Actinobacteria were the dominant bacteria in mature QF starter17. The dominant prokaryotic communities, including Lactobacillus, Leuconostoc, Pseudomonas, Lactococcus and Thermoactinomyces, were also detected in another type of mature NF liquor starter18. However, the liquor starter making process is complex, and the dynamics and interactions of the microbial communities in the above reported QF and NF liquor starters are still undercharacterized.
Co-occurrence analysis is a useful method to pinpoint the correlations and core modules in microbial communities19,20,21, and this method has not yet been applied in liquor starters. Recently, the software ‘Phylogenetic Investigation of Communities by Reconstruction of Unobserved States (PICRUSt)’22 was developed to predict the functional profiles of bacterial communities by bridging 16S rRNA gene information with a reference genomic database and the Kyoto Encyclopedia of Genes and Genomes (KEGG) database. Currently, this method can only be applied to predict bacterial function, and the number of available fungal genomes is not sufficient to allow for such prediction. To date, PICRUSt has been successfully applied to reveal the functional profiles of bacterial communities in animals23,24, humans20,25, oceans26, crude oil sediments27 and soil28,29.
In this study, the bacterial and fungal communities of two widely consumed liquor starters, NF and JF, were investigated using 454 pyrosequencing technology. Some thermophilic microbes were also isolated. Attempting to understand the comparative diversity, function and dynamics of microbial communities in liquor starter can help to improve Chinese liquor fermentation technology from “traditional experience-based model” to a “modern science-directed model”.
Microbial diversity and richness in the liquor starters
Total bacterial 16S rRNA gene sequences (20765 and 51545) and fungal ITS sequences (54634 and 58912) were recovered from JF (J1, J2, J3 and J4) and NF (N1, N2, N3 and N4) liquor starter samples, respectively. The library samples were then clustered into bacterial and fungal Operational Taxonomic Units (OTUs) at 97% similarity (Table 1). After rarefied reads, the results showed that the most bacterial OTUs were found in the J3 and N2 samples (597 and 572 OTUs, respectively) and that the highest number of fungal OTUs in the J4 and N3 samples (587 and 258 OTUs, respectively) (Table 1). Across most of the samples, the OTU numbers of bacteria were much higher than those of fungi. The sequencing coverage for all the samples ranged up to 91% and was especially high for fungi at approximately 99%. A total of 315 bacterial and 72 fungal genera were found in the JF liquor starter. Meanwhile, 83 bacterial and 47 fungal genera were identified in the NF liquor starter. Samples N2 showed the highest values of Chao and Ace for 16S rRNA gene data, and N3 had the highest values of Chao and Ace for ITS data. Meanwhile, JF samples showed the highest values of Chao and Ace for 16S rRNA gene in sample J3 and the highest values of Chao and Ace for ITS in sample J4. The estimators of Shannon and Simpson also showed the similar results as the Chao and Ace indices discussed above.
Principal component analysis (PCA) was performed to comparatively analyze the relationships of the microbial communities in the JF and NF liquor starters. The bacterial community PCA scatterplot (Fig. 1b) revealed that the bacterial community in the JF liquor starter was distinct from that in the NF liquor starter. The bacterial community in the NF liquor starter was grouped to the right of the graph along PC1. However, the bacterial community in the JF liquor starter varied considerably. In contrast, the fungal community was similar in the JF and NF liquor starter samples during the early period (J1 and N1, J2 and N2) (Fig. 1b). However, the fungal community of liquor starter samples differed after the highest temperature period (J3, J4, N3 and N4).
Microbial community composition
Classification of the bacteria and fungi at the order level for all samples is shown in Fig. 2. Lactobacillales increased up to 92% and 61% during the first 3 days for both J2 and N2 samples, respectively. After the temperature reached its maximum, Lactobacillales decreased markedly. However, Bacillales increased quickly and their abundance reached 17% and 43% for samples J3 and N3, respectively. Meanwhile, a relatively high abundance of no-rank Actinobacteria (39%) was found in J3, while only few (0.2%) were found in N3. Surprisingly, some relatively low abundance bacterial communities (see supplementary Table 1) were only detected in JF liquor starter. When the room temperature decreased to approximately 25 °C, Bacillales increased, especially in the NF liquor starter, reaching up to 71% (N4). No-rank Actinobacteria in the JF liquor starter also increased markedly, reaching 78% (J4). For bacterial communities, it was further shown that there was no OTU in common among four JF liquor starter samples (Fig. S1A), and 36 OTUs were in common among four NF samples (Fig. S1B). Staphylococcus spp. and Chryseobacterium spp. were the most abundant genera in common across the 4 NF liquor starter samples (data not shown).
The total fungal diversity in both the JF and NF liquor starters was much lower than that in the bacterial communities (Fig. 2). After 3 days of incubation, Saccharomycetales were the dominant fungi, accounting for up to 96.3% and 99.7% in samples J2 and N2, respectively. During the highest temperature period, a large number of no-rank Eukaryota were detected in both liquor starters, comprising 55% and 41% of the relative abundance in samples J3 and N3, respectively. In sample J3, Eurotiales also increased up to 42% during this period. Interestingly, 48% of Saccharomycetales could tolerate 62 °C and exist in sample N3. After the highest temperature period, Eurotiales increased markedly and became the dominant fungal taxon with up to 85% and 96% of the observed fungi in samples J4 and N4, respectively. For fungi communities, there were 10 OTUs (Fig. S1C) in common across four JF liquor starters. And 3 OTUs (Fig. S1D) were in common across the NF starters. The NF liquor starter had Pichia kudriavzevii and uncultured Saccharomycetes in common, while the JF liquor starter had Pichia kudriavzevii, Thermomyces lanuginosus, Thermoascus crustaceus, Byssochlamys spectabilis, Rhizomucor pusillus, Emericella rugulosa, Eurotium spp. and uncultured compost fungi species in common.
Pivotal yeast, filamentous fungi and bacteria communities in liquor starter
In this study, five yeast genera, Candida, Hyphopichia, Pichia, Saccharomycopsis and Saccharomycetes were found in two liquor starters (Table 2). Saccharomycopsis fibuligera was detected in sample N1. However, Saccharomycetes were not found in the JF liquor starter, and a low abundance of no-rank/unclassified Saccharomycetes were present in the NF liquor starter. Pichia was the dominant genus and P. kudriavzevii was the most abundant species in samples J2 and N2. Recently, P. kudriavzevii and Candida spp. which can grow at temperatures up to 50 °C, have been isolated from NF liquor starter (N3). Surprisingly, Hyphopichia, which can tolerate higher temperature (62 °C), was relatively abundant (up to 40%) in the NF liquor starter (N3).
When comparing the important filamentous fungi in the JF and NF liquor starters (Fig. 3a), both had low relative abundance of the traditional genera Aspergillus, Penicillium, Rhizomucor and Rhizopus. Interestingly, both liquor starters had high relative abundances of Thermoascus and Thermomyces at the highest temperature point (J3 and N3), and these increased even further when the temperature dropped to 25 °C (J4 and N4) (Fig. 3a). In the present work, some thermophilic fungi, T. lanuginosus, T. crustaceus, R. pusillus, and R. microsporus were successfully isolated from N3 and J3 samples.
For bacterial communities, similar abundances were found between Acetobacter and Lactobacillus, both of which increased quickly when the two liquor starters had incubated for 3 days (J2 and N2) and decreased when the temperature increased to its highest point (J3 and N3) (Fig. 3b). On the other hand, different abundances were shown between Leuconostoc and Weissella communities in NF and JF liquor starters (Fig. 3b). Both liquor starters had a relatively abundant Bacillus community during the highest temperature point (Fig. 3b, J3 and N3). Meanwhile, highly abundant no-rank Actinobacteria were found in JF liquor starter (J3 and J4) (Fig. 2). In addition, relatively abundant Thermoactinomyces bacteria were detected in N3 and J4, with comparable values in J3 and few found in N4 samples (Fig. 3b).
Correlation Network analysis
A microbiome-wide network of microbial associations among 8 samples was performed to better understand the co-occurring relationship of the microbial community. In total, 339 and 239 pairs of nodes were significantly correlated in bacterial JF and NF samples, respectively (Table S2 and Table S3). Meanwhile, 69 and 68 pairs of nodes were strong correlated in fungal JF and NF samples, respectively (Table S2 and Table S3).
In the bacterial network, hundreds of edges were found within each sample: 671 in N1, 2544 in N2, 1969 in N3, 289 in N4, 961 in J1, 544 in J2, 22983 in J3, and 438 in J4 (Fig. 4 and Table S3). Few edges were found among samples, however, except for N1-N2, N2-J1 and N3-J3, with 59, 71 and 90 edges, respectively (Fig. 4 and Table S2). Those associations among samples mainly resulted from co-occurring taxa. A large proportion of co-occurring taxa were found to be related to the genera Weissella (J1, N2), Lactobacillus (N1, N2), Thermoactinomyces (N3) and Macrococcus (J3) (Fig. 4 and Table S3).
Meanwhile, in the fungal network, the edge numbers within each sample were 153 (N1), 182(N2), 54 (N3), 28 (N4), 396 (J1), 90(J2), 26 (J3), and 88 (J4) (Fig. 4 and Table S4), which were all lower than those in the bacterial network. However, many associations were found among samples. Some associations even showed comparable edge numbers to those within samples, such as the 59 found in N1-N3, 24 in N2-N4, and 35 in N2-J2. Interestingly, the genus Pichia played a pivotal role in associations related to N1, N2, N3 and J2, accounting for 52% of nodes in N1, 92% of nodes in N2, 23% of nodes in N3 and 81% of nodes in J2, and contributing to 100% of the edges in N2-J2, N2-J3, N2-J4, N2-N4 and J2-J4 and 78% of edges in J2-N4 (Fig. 4, Table S4, Table S5). Additionally, the Pichia species were largely affiliated with P. burtonii (N1), P. occidental (N1) and Candida inconspicua (J2, N2 and N3). In addition to Pichia, the genera Thermoascus, Paecilomyces, Thermomyces also played important roles in fungal correlation network, accounting for 75% of nodes in J3 and 50% of nodes in J4, 43% of nodes in J4, and 100% of nodes in N4. Moreover, together with the genus Pichia, Trichosporon (N1), Candida (N1), Galactomyces (N3) and Thermomyces (N3) made large contributions to association between N1 and N3.
Predictive functional profiles of bacterial communities
Functional capacity of the bacterial communities during liquor starters making process was predicted by PICRUSt. Meanwhile the compositions of KEGG pathways were also analyzed for the 8 samples (Fig. S2). The abundant KEGG pathways were also analyzed between every pair of samples to investigate the differently functional profiles of bacterial communities among the 8 samples (Fig. 5). Notably, carbon metabolism was the most abundant pathways in 8 samples, especially for the microbes in the J3 sample. In addition to carbon metabolism, related carbohydrate and energy metabolism activities, such as oxidative phosphorylation, starch and sucrose metabolism, fructose and mannose metabolism, galactose metabolism, propanoate metabolism, sulfur metabolism, pyruvate metabolism, butanoate metabolism and glycolysis/gluconeogenesis, were highly represented in the top 50 pathways (Fig. S2). Interestingly, most of those carbohydrate and energy metabolism activities were in the top 20 significantly differential pathways in two-sample groups (Fig. 5), and some of them showed clear differences between two liquor starters. On the one hand, some pathways showed obviously higher differential significances compared to JF samples, e.g., starch and sucrose metabolism in J1-J2, J2-J3, J3-J4, N1-N2, N1-J1 and N2-J2, oxidative phosphorylation in J2-J3, J3-J4 and N3-J3, and carbon metabolism in J1-J2, J2-J3, J3-J4, N3-J3 and N4-J4 (Fig. 5). On the other hand, some pathways also showed higher differential significances compared to NF samples, e.g., N2-N3, N3-N4, N2-J2, N3-J3 and N4-J4 in galactose metabolism, and N1-N2, N1-J1 and N3-J3 in fructose and mannose metabolism (Fig. 5).
In addition, amino acid metabolism, terpenoid and polyketide metabolism were also found in the top 20 significantly differential pathways (Fig. 5). Among these, cysteine and methionine metabolism, lysine degradation and terpenoid backbone biosynthesis were in the top 30 pathways for 8 samples (Fig. S2). Importantly, cysteine and methionine metabolism (J1-J2, J2-J3, J3-J4, N1-N2, N1-J2, N2-J2 and N3-J3) and terpenoid backbone biosynthesis (J1-J2, J2-J3, J3-J4, N1-N2, N1-J2, N2-J2 and N3-J3) presented relatively high differential significances compared to JF samples. Furthermore, the number of genes involved in the degradation of aromatic compounds was much higher in J3 and J4 samples (Fig. S2) and showed highly differential significances in J2-J3, J3-N3 and J4-N4 (Fig. 5).
Understanding the diversity, function and dynamics of liquor starter microbial communities is important for improving liquor quality and yield. Although the unique and traditional Chinese solid state SSF and liquor brewing technology has continued for over several thousand years, the structure of the NF and JF liquor starter microbial communities is still not well characterized5,8,9,10,11,12,13,15,17,18. This is the first study to comprehensively analyze the microbial composition of Chinese NF and JF liquor starters during the production process. A total of 315 and 83 bacterial genera and 72 and 47 fungal genera were detected in the JF and NF liquor starters, respectively, indicating that both liquor starters have complex and abundant bacterial and fungal communities. This study obtained a relatively larger number of microbes and higher coverage than studies of Fen liquor starter (QF) and Maotai liquor starter (JF) which used traditional and molecular methods; fewer than 30 species was detected in one starter5,8,9,10,11,12,13. Moreover, our study found a surprising result that bacterial and fungal communities had the highest diversity and richness at the higher temperature stage in NF liquor starter. And in JF liquor starter, the highest diversity and richness of bacterial communities were also detected at the highest temperature stage of J3, while the highest diversity and richness of fungal communities were shown at the mature stage of J4.
The metabolic products of bacteria are important to develop unique flavors for liquor4. In this study, Weissella, Lactobacillus and Thermoactinomyces were identified as the most abundant bacterial taxa and made large contributions in the bacterial correlation network, so they could constitute the core genera in bacterial communities for these two liquor starters. The genera Lactobacillus and Acetobacter, belongs to the group of acetic acid bacteria. Lactobacillus is mainly applied to ferment traditional food and beverages30, and Acetobacter is the main functional bacteria for producing vinegar31. The metabolic products (e.g., acetic acid, lactic acid) of Acetobacter and Lactobacillus can be further synthesized by esterase into esters, such as ethyl acetate, ethyl lactate, isoamyl lactate, hexyl acetate, 2-phenylethyl acetate, 3-methylbutyl acetate and benzenacetate, which make large contributions to the special flavor of NF and JF liquors32,33,34. It has been reported that Weissella and Leuconostoc are usually present in fermented food along with lactic acid bacteria and are active as a good dietary source of vitamins35. Therefore, the Lactobacillus, Acetobacter, Weissella and Leuconostoc identified in both liquor starters may be important for flavor contribution. This study was the first discovery that JF liquor starter had a relatively high abundance of thermophilic Actinobacteria, which are an important and functionally diverse group of microbes with potential for biodegradation, carbon cycling and nutrient transformation36,37. Meanwhile, the highly abundant no-rank Actinobacteria in JF liquor starter (J3 and J4) could produce volatile organic compounds; the secondary metabolic products of Actinomyces could also contribute to flavor development38. Thermoactinomyces can produce plenty of thermostable extracellular proteolytic enzymes, e.g., alkaline proteinase39, glutamyl endopeptidase40 and carboxypeptidase41. This study further found that Bacillales and no-rank Actinobacteria were the dominant communities when the temperature increased to the highest point. Bacillus is well known to play an important role in liquor flavor generation42,43. It has been reported that B. licheniformis in JF liquor starter can produce specific flavor compounds such as 2,3-butanediol, 3-hydroxy-2-butanone, 2-methylpropionic acid and 3-methylbutanoic acid44,45,46. Interestingly, among bacterial community with relatively low abundant in JF liquor starter, Burkholderiales has a great ability to degrade a vast array of aromatic compounds47, and Clostridiales is an expert at reducing a wide range of cinnamic acid derivatives to their corresponding 3-phenylpropionic acid derivatives48. Additionally, Fusobacteriales and Clostridiales work as versatile bacteria and have unique abilities to ferment amino acids49. Furthermore, Cytophagales was reported to have a high capacity of degrading cellulose50. Surprisingly, Lactobacillus, Leuconostoc, Lactococcus and Thermoactinomyces were also dominant in the mature status of another NF liquor starter18.
Moreover, the predicted functional profiles of bacterial communities have performed for both liquor starters. The liquor starter samples in this study showed that the Nearest Sequenced Taxon Index (NSTI) values (0.007 to 0.062) (Table S6) was lower than the reported similar sample (soil) (0.17) in Langille’s work22, suggesting sufficient accuracy for metagenome predictions by PICRUSt. The prediction result indicated that both liquor starter samples had the most active energy metabolism, especially, J3 had the highest number of genes involved in almost all of the pathways (Fig. S2). This result also showed that the microbial community in sample J3 possibly had the most metabolic activity, which might be consistent with its highest temperature (70 °C). Those genes involved in carbohydrate digestion metabolisms were also high in both liquor starters. The two liquor starters might have preferences in carbohydrate digestion, e.g., starch and sucrose for JF samples, galactose, fructose and mannose for NF samples. Amino acid, terpenoid and polyketide metabolisms possibly were also active with differential significances between the two liquor starters (e.g., cysteine and methionine metabolism and terpenoid backbone biosynthesis in JF samples). Therefore, intermediates from those pathways (e.g., butanoate, protanoate, terpenoids, polyketides, aliphatic amino acids and branched-chain amino acids) might act as precursors or stimulators of the aromatic compounds in Chinese NF and JF liquor33,34,45,51,52,53,54. Additionally, the relatively high differential significance of cysteine and methionine metabolism in JF samples might be consistent with reports that cysteine and its metabolisms play an important role in the formation of JF compounds46. Furthermore, the degradation of aromatic compounds showed high differential significances in JF samples, and more genes related to this pathway were found in J3 and J4 when compared to NF samples and other JF samples by PICRUSt prediction, which is not surprising that many aromatic compounds and their derivatives have been found in JF liquor32,45,54. To some extent, the difference of those pathways between two liquor starters might be consistent with their different flavors. This observation might suggest a confirmation for difference in the flavor-development of those bacteria mentioned above, e.g., Actinomyces and B. licheniformis in JF liquor starter. In addition, the capacity of aromatic compounds degradation by Burkholderiales in JF liquor starter might be consistent with the PICRUSt predicted result regarding the pathways of degradation of aromatic compounds. In sum, these bacteria in these liquor starters could be significant for developing their special and well-characterized flavor of this liquor.
Yeast constitutes the most important microbial community in the ethanol production process55. As described above, the genus Pichia was the most abundant yeast and made large contribution in fungal correlation network, thus it could be one of the core genera in fungal communities in these two liquor starter. In Fen liquor starter (QF), P. kudriavzevii has been found to be the most abundant species15,56, which is similar to our study. The surprising discovery is that Hyphopichia could tolerate 62 °C. Hyphopichia has a broad habitat and unique ecological niches such as starch, rumen contents, food, insects and insect frass57,58. However, little is known about the thermostability of Hyphopichia. In addition to their function in the ethanol production, yeasts may also play a pivotal role in liquor flavor generation59. P. anomala has been reported to increase acetate ester-hydrolyzing esterase activity when mixed with S. cerevisiae in liquor fermentation60, and regulate several important volatile compounds in Chinese liquor, such as ethyl lactate, octanoic acid, and ethyl tetradecanoate61. When co-fermented with S. cerevisiae, P. kluyveri increased varietal thiol concentrations in Sauvignon Blanc wine62. Therefore, the yeast communities that are found in the NF and JF liquor starters may contribute to both ethanol fermentation and favor generation.
Filamentous fungi are significant during the production process of liquor starters for their saccharification function by secreting a wide spectrum of carbohydrate degrading enzymes4. Aspergillus, Rhizomucor and Penicillium have been well studied for their good lignocellulose hydrolysis performance63,64,65,66. Traditionally, Rhizopus and Aspergillus have been widely involved in fermenting food and beverages, and considered as the standards in saccharification4,67,68. Here, both Rhizopus and Aspergillus did not show high abundance throughout the production process. However, Thermoascus and Thermomyces were the most abundant fungi. Therefore, the important thermophilic fungi that were isolated from the NF and JF liquor starters were completely different from the fungi which were found by traditional notion and experience during Chinese liquor fermentation. In this study, Thermoascus, Paecilomyces and Thermomyces were identified as abundant fungal taxa and played a pivotal role in the fungal correlation network, so they could be the core genera in fungal communities. T. aurantiacus 69,70, T. crustaceus 69, T. lanuginosus 71,72,73 and P. variotii 74,75 have all been reported to be promising sources of thermophilic enzymes for high-level carbohydrate degradation. Currently, the microbiome in the giant panda gut76, wood-feeding higher termites77,78,79 and cow rumen80 have been closely studied, as they specialize in the efficient degradation of biomass. All these studies have underscored the importance of microbial communities in ecology. However, most of the dominant microbiomes are bacteria that live in anaerobic, high water content or animal temperature conditions. It has been reported that filamentous fungi are the most potent biomass degraders, as they produce a high number and a broad variety of enzymes81. Most studies on cellulase production have focused on aerobic species because the anaerobes show limited growth and do not produce enzymes in high quantities82. Furthermore, thermophilic enzymes have received significant attention for biomass degradation in industrial processes83,84. In this study, some thermophilic fungi have been further isolated and identified, e.g., T. lanuginosus, T. crustaceus, R. pusillus and R. microspores. Besides these isolated thermophilic fungi, more functional fungi will be isolated in future work from the promising microbial resource of liquor starter. These isolated fungi will be used for further discovering novel thermophilic enzymes.
This study provides insight into the diversity, function and dynamics of liquor starter microbial communities and sets the stage for understanding liquor starter microbial composition, paving the way for further active microbial community studies by metatranscriptomics and metaproteomics technologies and functional microorganism isolation, which may finally optimize the liquor production process, increasing alcohol yield and developing flavor generation. This new microbial resource can also be used for other industrial applications, such as bioenergy production, thermophilic and aerobic enzymes discovery, and fermented products used in food or feed preservation.
Liquor starter sampling
NF liquor starter was sampled from a fermentation workshop of Yibin Hongloumeng Distillery Group Co., Ltd in Yibing, Sichuan, China in July 2013. JF liquor starter was sampled from a fermentation workshop of Kweichow Hanwang Group Co., Ltd. in Renhuai, Guizhou, China in July 2013. Both liquor starters were sampled at different time points. Samples were harvested from three locations in the fermentation room at each time point. Samples J1 and N1 were collected at the beginning of liquor starter production; J2 and N2 were collected after 3 days of liquor starter fermentation; J3 and N3 were collected after 8 and 9 days of liquor starter fermentation (the second day after the temperature reached to the highest point), respectively; J4 and N4 were collected from the mature liquor starter. The temperatures of J1, J2, J3, J4, N1, N2, N3 and N4 were 30, 55, 70, 25, 30, 50, 62 and 25 °C, respectively (Fig. 1a). The liquor starter samples were frozen in liquid nitrogen immediately when harvested in the fermentation workshop, and samples were transferred to 50 ml RNase free Corning CentriStar™ centrifuge tubes (CORNING, 430828) and kept in dry ice. After all samples were harvested, they were transferred to Chengdu Biology Institute, Chinese Academy of Sciences on that day and stored in a -80 °C freezer for further research.
Isolation of thermophilic fungi
A total of 10 g liquor starter samples (N3 or J3) was mixed with 90 ml sterile physiological saline (0.85% w/v sodium chloride) and homogenized for 30 min at 200 rpm at room temperature. Then, 0.2 ml of the diluted mixture (10−1, 10−2 and 10−3 dilution) was spread on both rose bengal chloramphenicol agar and dichlorane glycerol agar plates and incubated at 50 °C for 2–4 days. The genomic DNA of the isolates was extracted using the Biospin Fungus Genomics DNA Extraction Kit (BioFlux, Tokyo, Japan) according to the manufacturer. Approximately 10 ng of genomic DNA was used as the template for amplifying ITS sequences with I-5TM 2X High-Fidelity Master Mix (Mclab, CA, USA) and a universal fungal primer set ITS4 (5′ TCCTCCGCTTATTGATATGC 3′) and ITS5 (5′ GGAAGTAAAAGTCGTAACAAGG 3′)85. The amplification was performed as follows: 94 °C for 5 min; 30 cycles at 94 °C for 30 s, 55 °C for 30 s, 72 °C for 90 s; and a final extension at 72 °C for 10 min.The ITS sequences were purified and sent to TsingKe (Chengdu, China) for sequencing. All ITS sequences were deposited in GenBank under the accession numbers in Table 3.
Genomic DNA extraction and 454 pyrosequencing
Three liquor starter samples for each time point were mixed well and ground using liquid nitrogen and total genomic DNA was extracted from 1.0 g of liquor starter using the E.Z.N.A Soil DNA kit (D5625-02, Omega, USA). To amplify the 16S rRNA genes and ITS genes, a universal bacterial primer set 27 F (5′ AGAGTTTGATCCTGGCTCAG 3′) and 533 R (5′ TTACCGCGGCTGCTG GCAC 3′) and a universal fungal primer set ITS1 (5′ TCCGTAGGTGAACCT GCGG 3′) and ITS4 (5′ TCCTCCGCTTATTGATATGC 3′) were used. Approximately 10 ng of genomic DNA was used as the template in PCR mixtures (50 μl) with rTaq premix (TaKaRa) and 100 nM of each primer. The amplification in triplicate was performed as described above. The PCR products were checked using 2% agarose gel electrophoresis and harvested by using the AxyPrep DNA Gel Extraction Kit (Axygen, INC., AP-GX-250) and sent to Shanghai Majorbio Bio-Pharm Technology Co., Ltd. (Shanghai, China) for sequencing on the Roche GS FLX 454 pyrosequencing platform. Before sequencing, the PCR products were purified and checked according to the QuantiFluor-ST fluorescent quantitation System (Promega) using the PicoGreen dsDNA Quantitation Reagent. The PCR products were then pooled at equal concentrations based on a standard curve. Emulsion-based clonal amplification (EmPCR) products were obtained using Roche emPCRAmp-Lib_L Kit (Roche). The samples were further prepared according to the GS FLX + Sequencing Method Manual_XL + Kit and were submitted for 454 pyrosequencing (Roche 454 FLX+).
The raw sequences were trimmed of the adaptor, barcode, forward and reverse primer using SEQCLN (14-03-20) (http://sourceforge.net/projects/seqclean/)86. The resulting sequences were then quality-filtered by MOTHUR software package (v.1.33.0)87 to remove low quality sequences (shorter than 200 bp, with quality scores < 25, containing any ambiguous bases (N) or homopolymers longer than 6 nucleotides). The valid sequences were reduced to a subset of unique sequences in order to eliminate redundancy and reduce computation time. The reduced sequences were then clustered into OTUs at the 97% similarity level.
In detail, for bacterial OTU clustering, chimeric sequences in reduced sequences were identified and removed by UCHIME (4.2.40) (http://drive5.com/uchime)88. Uncorrected pairwise distances were calculated according to sequences’ base differences. Then, sequences having 97% similarity were clustered into OTUs using the furthest neighbor method in MOTHUR.
Meanwhile, for fungal OTU clustering, the reduced sequences were blasted against the reference Silva eukarya database (silva SSU111) (http://www.arb-silva.de/)89 to check the reference-based chimera by using the script identify_chimeric_seqs.py (QIIME 1.7.0, Usearch61) (http://qiime.org/scripts/identify_chimeric_seqs.html)90, and all chimeric tags were removed. Then sequences having 97% similarity were clustered into OTUs using the script pick_otus.py (QIIME 1.7.0, Usearch61) (http://qiime.org/scripts/pick_otus.html)90.
The Ribosome Database Project (RDP) Naive Bayesian classifier (11.2) (http://rdp.cme.msu.edu/)91 in MOTHUR was used to analyze bacterial and fungal clustered OTUs against reference SSUrRNA (small subunit ribosomal RNA) database in Silva (silva SSU111)89 for taxonomical classification. To fairly compare all samples at the same sequencing depth, the number of the sequences was normalized by randomly extracting 3460 reads for 16S rRNA gene data and 9622 reads for ITS sequence data from each sample using daisychopper.pl92 before alpha diversity indices analysis. Alpha diversity indices of Chao1, ACE, Shannon, Simpson and sample coverage (Good’s coverage) were calculated using QIIME 1.7.090. PCA was constructed using R package to quantify differences in community composition93. A Venn diagram was created with the online tool Venny (2.1) (http://bioinfogp.cnb.csic.es/tools/venny/). The sequencing data was deposited in the NCBI Sequence Read Archive database under the study accession number PRJNA283746.
Correlation Network Analysis
All microbial OTUs in liquor starter samples were used for network analysis. Spearman’s rank correlations between selected OTUs were calculated using R package93. A valid co-occurrence was selected as a strong correlation if the Spearman’s correlation coefficient (ρ) was >0.6 and >0.7 for fungi and bacteria, respectively94. Correlation networks were constructed with the open source platform Cytoscape (3.3.0)95.
Predictive functional profiles of bacterial communities involved in metabolic pathways
PICRUSt (1.0.0)22 and KEGG96 were applied to predict functional differences of bacterial communities in the liquor starter samples based on the raw 16S rRNA gene data. Briefly, the closed-reference OTU was chosen to blast against the Greengenes database (13.5)97, then the metagenomes of selected OTUs were predictively analyzed against the KEGG database. The prediction of PICRUSt was evaluated by the Nearest Sequenced Taxon Index (NSTI)22. Differentially abundant KEGG pathways were calculated using the program Metastats98 (using an FDR correction, p < = 0.05, Log2(FC)| > = 1), and pathways with significant difference were used for drawing bubble profile.
Xu, M. L., Yu, Y., Ramaswamy, H. S. & Zhu, S. M. Characterization of Chinese liquor aroma components during aging process and liquor age discrimination using gas chromatography combined with multivariable statistics. Sci Rep 7, 39671, https://doi.org/10.1038/srep39671 (2017).
Yao, F. et al. Chemical Analysis of the Chinese Liquor Luzhoulaojiao by Comprehensive Two-Dimensional Gas Chromatography/Time-of-Flight Mass Spectrometry. Sci Rep 5, 9553, https://doi.org/10.1038/srep09553 (2015).
Farías, M. E., Sosa, O.A., Mendoza, L.M. & Fernández, P.A.A. Microbial Interaction in Fermented Beverages 65 (Nova Science pub Inc, New York, 2011).
Xu, Y., Wang, D., Fan, W. L., Mu, X. Q. & Chen, J. in Biotechnology in China II: Chemicals, Energy and Environment (eds G. T. Tsao, Pingkai Ouyang, & Jian Chen) 189–233 (Springer Berlin Heidelberg, 2010).
Chen, B., Wu, Q. & Xu, Y. Filamentous fungal diversity and community structure associated with the solid state fermentation of Chinese Maotai-flavor liquor. Int J Food Microbiol 179, 80–84, https://doi.org/10.1016/j.ijfoodmicro.2014.03.011 (2014).
Zhang, C. et al. Characterization of volatile compounds from Daqu-a traditional Chinese liquor fermentation starter. Int J Food Sci Technol 46, 1591–1599, https://doi.org/10.1111/j.1365-2621.2011.02660.x (2011).
Zheng, X.-W. & Han, B.-Z. Baijiu(白酒), Chinese liquor: History, classification and manufacture. J Ethn Foods 3, 19–25, https://doi.org/10.1016/j.jef.2016.03.001 (2016).
Shi, J. H. et al. Analyses of microbial consortia in the starter of Fen Liquor. Lett Appl Microbiol 48, 478–485, https://doi.org/10.1111/j.1472-765X.2009.02554.x (2009).
Yan, Z. et al. Monitoring the Ecology of Bacillus During Daqu Incubation, a Fermentation Starter, Using Culture-Dependent and Culture-Independent Methods. J Microbiol Biotechnol 23, 614–622 (2013).
Zheng, X.-W. et al. Complex microbiota of a Chinese “Fen” liquor fermentation starter (Fen-Daqu), revealed by culture-dependent and culture-independent methods. Food Microbio 31, 293–300, https://doi.org/10.1016/j.fm.2012.03.008 (2012).
Liu, X., Guo, K. & Zhang, H. Determination of microbial diversity in Daqu, a fermentation starter culture of Maotai liquor, using nested PCR-denaturing gradient gel electrophoresis. World J Microbiol Biotechnol 28, 2375–2381, https://doi.org/10.1007/s11274-012-1045-y (2012).
Wang, H. Y. & Xu, Y. C. Effect of temperature on microbial composition of starter culture for Chinese light aroma style liquor fermentation. Lett Appl Microbiol 60, 85–91, https://doi.org/10.1111/lam.12344 (2015).
Zhang, L., Wu, C., Ding, X., Zheng, J. & Zhou, R. Characterisation of microbial communities in Chinese liquor fermentation starters Daqu using nested PCR-DGGE. World J Microbiol Biotechnol 30, 3055–3063, https://doi.org/10.1007/s11274-014-1732-y (2014).
Hamady, M., Walker, J. J., Harris, J. K., Gold, N. J. & Knight, R. Error-correcting barcoded primers allow hundreds of samples to be pyrosequenced in multiplex. Nat Methods 5, 235–237, https://doi.org/10.1038/nmeth.1184 (2008).
Li, X.-R. et al. Bacterial and fungal diversity in the starter production process of Fen liquor, a traditional Chinese liquor. J Microbiol Meth 51, 430–438, https://doi.org/10.1007/s12275-013-2640-9 (2013).
Li, X.-R. et al. Bacterial and fungal diversity in the traditional Chinese liquor fermentation process. Int J Food Microbiol 146, 31–37, https://doi.org/10.1016/j.ijfoodmicro.2011.01.030 (2011).
Zhang, X., Zhao, J. & Du, X. C. Barcoded pyrosequencing analysis of the bacterial community of Daqu for light-flavour Chinese liquor. Lett Appl Microbiol 58, 549–555, https://doi.org/10.1111/lam.12225 (2014).
Wang, X., Du, H. & Xu, Y. Source tracking of prokaryotic communities in fermented grain of Chinese strong-flavor liquor. Int J Food Microbiol 244, 27–35, https://doi.org/10.1016/j.ijfoodmicro.2016.12.018 (2017).
Faust, K. et al. Microbial Co-occurrence Relationships in the Human Microbiome. PLoS Comput Biol 8, e1002606, https://doi.org/10.1371/journal.pcbi.1002606 (2012).
Gevers, D. et al. The Treatment-Naive Microbiome in New-Onset Crohn’s Disease. Cell Host Microbe 15, 382–392, https://doi.org/10.1016/j.chom.2014.02.005 (2014).
Rui, J. et al. The core populations and co-occurrence patterns of prokaryotic communities in household biogas digesters. Biotechnol Biofuels 8, 158, https://doi.org/10.1186/s13068-015-0339-3 (2015).
Langille, M. G. I. et al. Predictive functional profiling of microbial communities using 16S rRNA marker gene sequences. Nat Biotechnol 31, 814–821, https://doi.org/10.1038/nbt.2676 (2013).
Corrigan, A., de Leeuw, M., Penaud-Frézet, S., Dimova, D. & Murphy, R. A. Phylogenetic and Functional Alterations in Bacterial Community Compositions in Broiler Ceca as a Result of Mannan Oligosaccharide Supplementation. Appl Environ Microbiol 81, 3460–3470, https://doi.org/10.1128/aem.04194-14 (2015).
Hu, J. et al. Gradual Changes of Gut Microbiota in Weaned Miniature Piglets. Front Microbiol 7, 1727, https://doi.org/10.3389/fmicb.2016.01727 (2016).
Kirst, M. E. et al. Dysbiosis and Alterations in Predicted Functions of the Subgingival Microbiome in Chronic Periodontitis. Appl Environ Microbiol 81, 783–793, https://doi.org/10.1128/aem.02712-14 (2015).
de Voogd, N. J., Cleary, D. F. R., Polónia, A. R. M., Gomes, N. C. M. & Olson, J. Bacterial community composition and predicted functional ecology of sponges, sediment and seawater from the thousand islands reef complex, West Java, Indonesia. FEMS Microbiology Ecology 91, fiv019–fiv019, https://doi.org/10.1093/femsec/fiv019 (2015).
Wang, H., Wang, B., Dong, W. & Hu, X. Co-acclimation of bacterial communities under stresses of hydrocarbons with different structures. Sci Rep 6, 34588, https://doi.org/10.1038/srep34588 (2016).
Jiang, L. et al. Exploring the Influence of Environmental Factors on Bacterial Communities within the Rhizosphere of the Cu-tolerant plant, Elsholtzia splendens. Sci Rep 6, 36302, https://doi.org/10.1038/srep36302 (2016).
Oh, S.-Y., Fong, J. J., Park, M. S. & Lim, Y. W. Distinctive Feature of Microbial Communities and Bacterial Functional Profiles in Tricholoma matsutake Dominant Soil. PLoS ONE 11, e0168573, https://doi.org/10.1371/journal.pone.0168573 (2016).
Liu, S.-n, Han, Y. & Zhou, Z.-j Lactic acid bacteria in traditional fermented Chinese foods. Food Res Int 44, 643–651, https://doi.org/10.1016/j.foodres.2010.12.034 (2011).
Wu, J. J., Ma, Y. K., Zhang, F. F. & Chen, F. S. Biodiversity of yeasts, lactic acid bacteria and acetic acid bacteria in the fermentation of “Shanxi aged vinegar”, a traditional Chinese vinegar. Food Microbiol 30, 289–297, https://doi.org/10.1016/j.fm.2011.08.010 (2012).
Xiao, Z. et al. Characterization of aroma compounds of Chinese famous liquors by gas chromatography-mass spectrometry and flash GC electronic-nose. J Chromatogr B 945-946, 92–100, https://doi.org/10.1016/j.jchromb.2013.11.032 (2014).
Zhu, S. et al. Characterization of flavor compounds in Chinese liquor Moutai by comprehensive two-dimensional gas chromatography/time-of-flight mass spectrometry. Anal Chim Acta 597, 340–348, https://doi.org/10.1016/j.aca.2007.07.007 (2007).
Fan, W. & Qian, M. C. Characterization of Aroma Compounds of Chinese “Wuliangye” and “jiannanchun” Liquors by Aroma Extract Dilution Analysis. J Agric Food Chem 54, 2695–2704, https://doi.org/10.1021/jf052635t (2006).
Nam, T. H., Ogihara, S. & Kobayashi, S. Interfacial, Mechanical and Thermal Properties of Coir Fiber-Reinforced Poly(Lactic Acid) Biodegradable Composites. Adv Compos Mater 21, 103–122 (2012).
Jenkins, S. N. et al. Actinobacterial community dynamics in long term managed grasslands. Antonie van Leeuwenhoek 95, 319–334, https://doi.org/10.1007/s10482-009-9317-8 (2009).
Schäfer, J., Jäckel, U. & Kämpfer, P. Analysis of Actinobacteria from mould-colonized water damaged building material. Syst Appl Microbiol 33, 260–268, https://doi.org/10.1016/j.syapm.2010.04.006 (2012).
Schöller, C. E. G., Gürtler, H., Pedersen, R., Molin, S. & Wilkins, K. Volatile Metabolites from Actinomycetes. J Agric Food Chem 50, 2615–2621 (2002).
Verma, A., Ansari, M. W., Anwar, M. S., Agrawal, R. & Agrawal, S. Alkaline protease from Thermoactinomyces sp. RS1 mitigates industrial pollution. Protoplasma 251, 711–718, https://doi.org/10.1007/s00709-013-0559-y (2014).
Liu, F. et al. Autocatalytic activation of a thermostable glutamyl endopeptidase capable of hydrolyzing proteins at high temperatures. Appl Microbiol Biotechnol. 100, 10429–10441, https://doi.org/10.1007/s00253-016-7697-z (2016).
Akparov, V. K. et al. Structural insights into the broad substrate specificity of carboxypeptidase T from Thermoactinomyces vulgaris. FEBS J 282, 1214–1224, https://doi.org/10.1111/febs.13210 (2015).
Hou, X. et al. Research Progress in Main Functional Microbes in Nong-flavor Liquor Pits. Liquor-Making Sci Technol (in Chinese) 2, 96–101 (2013).
Huang, Y. et al. Study on the Metabolites of Jiang-flavor-producing Bacillus. Liquor-Making Sci Technol (in Chinese) 1, 41–45 (2013).
Meng, X. et al. Improving flavor metabolism of Saccharomyces cerevisiae by mixed culture with Bacillus licheniformis for Chinese Maotai-flavor liquor making. J Ind Microbiol Biotechnol 42, 1601–1608, https://doi.org/10.1007/s10295-015-1647-0 (2015).
Zhang, R., Wu, Q. & Xu, Y. C. Aroma characteristics of Moutai-flavour liquor produced with Bacillus licheniformis by solid-state fermentation. Lett Appl Microbiol 57, 11–18, https://doi.org/10.1111/lam.12087 (2013).
Wu, Q. & Xu, Y. Transcriptome Profiling of Heat-Resistant Strain Bacillus licheniformis CGMCC3962 Producing Maotai Flavor. J Agric Food Chem 60, 2033–2038, https://doi.org/10.1021/jf204270h (2012).
Pérez-Pantoja, D. et al. Genomic analysis of the potential for aromatic compounds biodegradation in Burkholderiales. Environ Microbiol 14, 1091–1117, https://doi.org/10.1111/j.1462-2920.2011.02613.x (2012).
Chamkha, M., Garcia, J. L. & Labat, M. Metabolism of cinnamic acids by some Clostridiales and emendation of the descriptions of Clostridium aerotolerans, Clostridium celerecrescens and Clostridium xylanolyticum. Int J Syst Evol Microbiol 51, 2105–2111, https://doi.org/10.1099/00207713-51-6-2105 (2001).
Buckel, W. Unusual enzymes involved in five pathways of glutamate fermentation. Appl Microbiol Biotechnol 57, 263–273 (2001).
Li, X., Liu, J. & Gao, P. A simple method for the isolation of cellulolytic myxobacteria and cytophagales. J Microbiol Meth 25, 43–47 (1996).
Zhuang, M. Y. The Production Mechanism of the Fragrance in the Chinese Spirit & the Operation of the Spirit Brewing. Sichuan food ferment (in Chinese) 43, 1–6 (2007).
Wu, X.-H., Zheng, X.-W., Han, B.-Z., Vervoort, J. & Nout, M. J. R. Characterization of Chinese Liquor Starter, “Daqu” by Flavor Type with 1H NMR-Based Nontargeted Analysis. J. Agric. Food Chem. 57, 11354–11359, https://doi.org/10.1021/jf902881p (2009).
Lu, X., Wu, Q., Zhang, Y. & Xu, Y. Genomic and transcriptomic analyses of the Chinese Maotai-flavored liquor yeast MT1 revealed its unique multi-carbon co-utilization. BMC Genomics 16, 1064, https://doi.org/10.1186/s12864-015-2263-0 (2015).
Fan, W., Shen, H. & Xu, Y. Quantification of volatile compounds in Chinese soy sauce aroma type liquor by stir bar sorptive extraction and gas chromatography–mass spectrometry. J Sci Food Agric 91, 1187–1198, https://doi.org/10.1002/jsfa.4294 (2011).
Wu, Q., Chen, L. & Xu, Y. Yeast community associated with the solid state fermentation of traditional Chinese Maotai-flavor liquor. Int J Food Microbiol 166, 323–330, https://doi.org/10.1016/j.ijfoodmicro.2013.07.003 (2013).
Li, X. R. et al. Bacterial and fungal diversity in the starter production process of Fen liquor, a traditional Chinese liquor. J Microbiol 51, 430–438, https://doi.org/10.1007/s12275-013-2640-9 (2013).
Kurtzman, P. C. New species and a new combination in the Hyphopichia and Yarrowia yeast clades. Antonie van Leeuwenhoek 88, 121–130, https://doi.org/10.1007/s10482-005-2495-0 (2005).
Kurtzman, C. P. H. v. A. v. d. W. The Yeasts: A Taxonomic Study. 1 (eds. Kurtzman, C.P., Fell, J.W., Boekhout, T.), 435-438 (NY: Elsevier, New York, 2011).
Romano, P., Fiore, C., Paraggio, M., Caruso, M. & Capece, A. Function of yeast species and strains in wine flavour. Int J Food Microbiol. 86, 169–180, https://doi.org/10.1016/S0168-1605(03)00290-3 (2003).
Kurita, O. Increase of acetate ester-hydrolysing esterase activity in mixed cultures of Saccharomyces cerevisiae and Pichia anomala. J Appl Microbiol 104, 1051–1058, https://doi.org/10.1111/j.1365-2672.2007.03625.x (2008).
Kong, Y., Wu, Q., Zhang, Y. & Xu, Y. In Situ Analysis of Metabolic Characteristics Reveals the Key Yeast in the Spontaneous and Solid-State Fermentation Process of Chinese Light-Style Liquor. Appl Environ Microbiol 80, 3667–3676, https://doi.org/10.1128/aem.04219-13 (2014).
Anfang, N., Brajkovich, M. & Goddard, M. R. Co-fermentation with Pichia kluyveri increases varietal thiol concentrations in Sauvignon Blanc. Aust J Grape Wine Res 15, 1–8, https://doi.org/10.1111/j.1755-0238.2008.00031.x (2009).
Rodrigues, R. C. & Fernandez-Lafuente, R. Lipase from Rhizomucor miehei as an industrial biocatalyst in chemical process. J Mol Catal B: Enzym 64, 1–22, https://doi.org/10.1016/j.molcatb.2010.02.003 (2010).
Liu, G. et al. Genomic and Secretomic Analyses Reveal Unique Features of the Lignocellulolytic Enzyme System of Penicillium decumbens. PLoS ONE 8, e55185, https://doi.org/10.1371/journal.pone.0055185 (2013).
Krisch, J., Bencsik, O., Papp, T., Vágvölgyi, C. & Takó, M. Characterization of a β-glucosidase with transgalactosylation capacity from the zygomycete Rhizomucor miehei. Bioresour Technol 114, 555–560, https://doi.org/10.1016/j.biortech.2012.02.117 (2011).
de Souza, W. R. et al. Transcriptome analysis of Aspergillus niger grown on sugarcane bagasse. Biotechnol Biofuels 4, 40–40, https://doi.org/10.1186/1754-6834-4-40 (2011).
Blandino, A., Al-Aseeri, M. E., Pandiella, S. S., Cantero, D. & Webb, C. Cereal-based fermented foods and beverages. Food Res Int 36, 527–543 (2003).
Caplice, E. & Fitzgerald, G. F. Food fermentations: role of microorganisms in food production and preservation. Int J Food Microbiol. 50, 131–149, https://doi.org/10.1016/S0168-1605(99)00082-3 (1999).
Dashtban, M., Schraft, H. & Qin, W. Fungal Bioconversion of Lignocellulosic Residues; Opportunities & Perspectives. Int J Biol Sci 5, 578–595 (2009).
McClendon, S. D. et al. Thermoascus aurantiacus is a promising source of enzymes for biomass deconstruction under thermophilic conditions. Biotechnol Biofuels 5, 54–54, https://doi.org/10.1186/1754-6834-5-54 (2012).
Basaveswara Rao, V., Sastri, N. V. S. & Subba Rao, P. V. Purification and characterization of a thermostable glucoamylase from the thermophilic fungus Thermomyces lanuginosus. Biochem J 193, 379–387, https://doi.org/10.1042/bj1930379 (1981).
Nguyen, Q. D., Rezessy-Szabó, J. M., Claeyssens, M., Stals, I. & Hoschke, Á. Purification and characterisation of amylolytic enzymes from thermophilic fungus Thermomyces lanuginosus strain ATCC 34626. Enzyme Microb Tech 31, 345–352 (2002).
McHunu, N. P. et al. Xylanase Superproducer: Genome Sequence of a Compost-Loving Thermophilic Fungus, Thermomyces lanuginosus Strain SSBP. Genome Announc 1, e00388–00313, https://doi.org/10.1128/genomeA.00388-13 (2013).
Frandsen, R. J. N., Andersson, J. A., Kristensen, M. B. & Giese, H. Efficient four fragment cloning for the construction of vectors for targeted gene replacement in filamentous fungi. BMC Mol Biol 9, 70–70, https://doi.org/10.1186/1471-2199-9-70 (2008).
Herrera Bravo de Laguna, I., Toledo Marante, F. J. & Mioso, R. C. Enzymes and bioproducts produced by the ascomycete fungus Paecilomyces variotii. J Appl Microbiol 119, 1455–1466, https://doi.org/10.1111/jam.12934 (2015).
Zhu, L., Wu, Q., Dai, J., Zhang, S. & Wei, F. Evidence of cellulose metabolism by the giant panda gut microbiome. Proc Natl Acad Sci USA 108, 17714–17719, https://doi.org/10.1073/pnas.1017956108 (2011).
Warnecke, F. et al. Metagenomic and functional analysis of hindgut microbiota of a wood-feeding higher termite. Nature 450, 560–565, https://doi.org/10.1038/nature06269 (2007).
He, S. et al. Comparative Metagenomic and Metatranscriptomic Analysis of Hindgut Paunch Microbiota in Wood- and Dung-Feeding Higher Termites. PLoS ONE 8, e61126, https://doi.org/10.1371/journal.pone.0061126 (2013).
Warnecke, F. et al. Metagenomic and functional analysis of hindgut microbiota of a wood-feeding higher termite. Nature 450, 560–565 (2007).
Hess, M. et al. Metagenomic Discovery of Biomass-Degrading Genes and Genomes from Cow Rumen. Science 331, 463–467, https://doi.org/10.1126/science.1200387 (2011).
Lundell, T. K., Mäkelä, M. R. & Hildén, K. Lignin-modifying enzymes in filamentous basidiomycetes – ecological, functional and phylogenetic review. J Basic Microbiol 50, 5–20, https://doi.org/10.1002/jobm.200900338 (2010).
Verardi, A., De Bari, I., Ricca, E. & Calabrò, V. Hydrolysis of Lignocellulosic Biomass: Current Status of Processes and Technologies and Future Perspectives. in Bioethanol ed. Lima, M.A.P., 95–122 (Intech, Italy, 2012).
Li, D. C., Li, A. N. & Papageorgiou, C. A. Cellulases from Thermophilic Fungi: Recent Insights and Biotechnological Potential. Enzyme Res 2011, 1–9, https://doi.org/10.4061/2011/308730 (2011).
Busk, P. & Lange, L. Cellulolytic potential of thermophilic species from four fungal orders. AMB Express 3, 47 (2013).
Martin, K. J. & Rygiewicz, P. T. Fungal-specific PCR primers developed for analysis of the ITS region of environmental DNA extracts. BMC Microbiol 5, 28–28, https://doi.org/10.1186/1471-2180-5-28 (2005).
Prosdocimi, F., de Carvalho, D. C., de Almeida, R. N. & Beheregaray, L. B. The complete mitochondrial genome of two recently derived species of the fish genus Nannoperca (Perciformes, Percichthyidae). Mol Biol Rep 39, 2767–2772, https://doi.org/10.1007/s11033-011-1034-5 (2012).
Schloss, P. D. et al. Introducing mothur: Open-Source, Platform-Independent, Community-Supported Software for Describing and Comparing Microbial Communities. Appl Environ Microbiol 75, 7537–7541, https://doi.org/10.1128/aem.01541-09 (2009).
Edgar, R. C., Haas, B. J., Clemente, J. C., Quince, C. & Knight, R. UCHIME improves sensitivity and speed of chimera detection. Bioinformatics 27, 2194–2200 (2011).
Quast, C. et al. The SILVA ribosomal RNA gene database project: improved data processing and web-based tools. Nucleic acids res 41, D590–D596, https://doi.org/10.1093/nar/gks1219 (2012).
Caporaso, J. et al. QIIME allows analysis of high-throughput community sequencing data. Nat Meth 7, 335–336, https://doi.org/10.1038/nmeth.f.303 (2010).
Wang, Q., Garrity, G. M., Tiedje, J. M. & Cole, J. R. Naive Bayesian classifier for rapid assignment of rRNA sequences into the new bacterial taxonomy. Appl Environ Microbiol 73, 5261–5267, https://doi.org/10.1128/AEM.00062-07 (2007).
Gilbert, J. A. et al. The Taxonomic and Functional Diversity of Microbes at a Temperate Coastal Site: A ‘Multi-Omic’ Study of Seasonal and Diel Temporal Variation. PLoS ONE 5, e15545, https://doi.org/10.1371/journal.pone.0015545 (2010).
Ihaka, R. & Gentleman, R. R. A Language for Data Analysis and Graphics. J Comput Graph Stat 5, 299–314, https://doi.org/10.1080/10618600.1996.10474713 (1996).
Barberán, A., Bates, S. T., Casamayor, E. O. & Fierer, N. Using network analysis to explore co-occurrence patterns in soil microbial communities. ISME J 6, 343–351, https://doi.org/10.1038/ismej.2011.119 (2012).
Shannon, P. et al. Cytoscape: a software environment for integrated models of biomolecular interaction networks. Genome res 13, 2498–2504, https://doi.org/10.1101/gr.1239303 (2003).
Kanehisa, M., Furumichi, M., Tanabe, M., Sato, Y. & Morishima, K. KEGG: new perspectives on genomes, pathways, diseases and drugs. Nucleic Acids Res 45, D353–D361, https://doi.org/10.1093/nar/gkw1092 (2017).
DeSantis, T. Z. et al. Greengenes, a Chimera-Checked 16S rRNA Gene Database and Workbench Compatible with ARB. Appl Environ Microbiol 72, 5069–5072, https://doi.org/10.1128/aem.03006-05 (2006).
Paulson, J. N., Pop, M. & Bravo, H. C. Metastats: an improved statistical method for analysis of metagenomic data. Genome biol 12(Suppl 1), P17, https://doi.org/10.1186/gb-2011-12-s1-p17 (2011).
This study was supported by the National Key Technology R&D Program of China (2015BAD15B01), China Agriculture Research System (No. CARS-10-B22, the National Natural Science for Youth Foundation of China (31400685), the National Natural Science for General Foundation of China (31770395), Science & Technology Program of Sichuan Province (2017NZ0018 and 2017HH0077), and the Open Fund of Key Laboratory of Environmental and Applied Microbiology (KLEAMCAS201501, KLCAS-2014-05 and KLCAS-2016-02) of the Chinese Academy of Sciences. We thank Professors Zhongyan Wang, Mingyang Zhuang and Yanyong Wu for providing valuable suggestions concerning liquor starter research.
The authors declare that they have no competing interests.
Publisher's note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Electronic supplementary material
About this article
Cite this article
Huang, Y., Yi, Z., Jin, Y. et al. New microbial resource: microbial diversity, function and dynamics in Chinese liquor starter. Sci Rep 7, 14577 (2017). https://doi.org/10.1038/s41598-017-14968-8
Food Bioscience (2021)
Probiotic properties of lactic acid bacteria isolated from traditionally prepared dry starters of the Eastern Himalayas
World Journal of Microbiology and Biotechnology (2021)
Daqu microbiota exhibits species-specific and periodic succession features in Chinese baijiu fermentation process
Food Microbiology (2021)
Storage period affecting dynamic succession of microbiota and quality changes of strong-flavor Baijiu Daqu
Bacterial community dynamics reveal its key bacterium, Bacillus amyloliquefaciens ZB, involved in soybean meal fermentation for efficient water-soluble protein production