Current therapies for most neurodegenerative disorders are only symptomatic in nature and do not change the course of the disease. Gene therapy plays an important role in disease modifying therapeutic strategies. Herein, we have designed and optimized a series of highly branched poly(β-amino ester)s (HPAEs) containing biodegradable disulfide units in the HPAE backbone (HPAESS) and guanidine moieties (HPAESG) at the extremities. The optimized polymers are used to deliver minicircle DNA to multipotent adipose derived stem cells (ADSCs) and astrocytes, and high transfection efficiency is achieved (77% in human ADSCs and 52% in primary astrocytes) whilst preserving over 90% cell viability. Furthermore, the top-performing candidate mediates high levels of nerve growth factor (NGF) secretion from astrocytes, causing neurite outgrowth from a model neuron cell line. This synergistic gene delivery system provides a viable method for highly efficient non-viral transfection of ADSCs and astrocytes.
Cell and gene therapies have been considered for a range of neurological disorders1,2. Transplanted cells can either be used to secrete factors such as neurotrophic/neuroprotective agents, or they can be used to replace lost cell types3,4. Manipulating stem cells to further improve their beneficial secretome by overexpressing neuroprotrophic/neuroprotective growth factors prior to transplantation (ex vivo manipulation) is an attractive strategy for neural repair5,6,7. Alternatively, directly transfecting a major support cell (such as astrocytes) in vivo would allow secretion of factors to support damaged neurons8. One major hurdle for both strategies arises due to the fact that these cell types are typically hard to transfect.
Adipose-derived stem cells (ADSCs) are easy to isolate, expand and engraft, and can secrete a broad spectrum of angiogenic, neurotrophic factors and chemokines9. They are therefore an exciting cell resource for neural tissue regeneration with good clinical applicability10,11. ADSCs also have the ability to regulate the inflammatory response and hold antioxidant capacity12. Moreover, under the induction of specific genetic signals, ADSCs can differentiate into neuron-like or glia-like cells13,14. However, ADSCs are difficult to transfect14, thus driving the design of better gene delivery systems. Astrocytes are also hard to transfect showing far lower levels of transgene expression than other cell types15,16, making direct gene transfer into the brain somewhat limited17.
Gene transfection vectors, especially non-viral vectors have attracted increasing attention because of high safety profile, large gene loading capacity and ease of large-scale production18,19,20,21, but are consistently plagued by the unsatisfied gene transfection capability22,23,24. Lynn and Langer25 developed linear poly(β-amino ester)s (LPAEs) through the conjugation addition of amines to diacrylates. Owing to the broad monomer availability, the chemical composition of LPAEs is highly tailorable, and so far more than 2350 LPAEs have been developed26,27,28. The top-performing LPAE series have demonstrated their high gene transfection potency and biocompatibility on a variety of cell types29,30,31. In-depth mechanistic studies illustrate that the terminal units of LPAEs play a critical role in achieving high gene transfection efficiency28,32. For example, by altering the alcohol terminals to primary amines, the transfection efficiency can be improved by three orders-of-magnitude33,34.
As such, one can now envisage that dendritic poly(β-amino ester)s could be more conducive for efficient gene transfection, because, unlike LPAEs with only two terminals, dendritic poly(β-amino ester)s contain multiple terminal units. The three-dimensional (3D) topological structure of dendritic poly(β-amino ester)s would provide a large chemical space for functionalization and would be more favorable for DNA condensation and protection from enzymatic degradation35. As such, recently we have developed highly branched poly(β-amino ester)s (HPAEs) as gene delivery vectors36,37,38,39. Both in vitro and in vivo studies demonstrated the high efficiency of HPAEs in gene transfection. Importantly, the inherent nature of highly branched structure: multiple terminal groups makes HPAEs a highly flexible and tailorable platform for the development of various functionality-enhanced gene delivery vectors aiming at different clinical targets.
Aside from the vector, the DNA cassette itself also plays a crucial role in determining overall gene transfection safety and efficiency. For instance, earlier results showed that by removing the prokaryotic sequences, minicircle DNA constructs (MC DNA), a supercoiled minimally sized DNA cassette, were capable of mediating a prolonged non-integrative transgene expression40,41.
The goal of this work is therefore to develop multifunctional HPAEs and combine them with a MC DNA for high-performance gene transfection of ADSCs and astrocytes. We aim to navigate the three key barriers associated with gene delivery: cytotoxicity, polyplex cellular uptake and DNA release. It is hypothesized that by integrating multiple disulfide bonds into HPAE backbone (HPAESS), glutathione-mediated biodegradation can be achieved. This will not only facilitate DNA release from HPAE/DNA polyplexes but also reduce the cytotoxicity of HPAEs after transfection. By adding guanidine groups to the terminals of HPAEs (HPAESG), the formation of multiple hydrogen bonds between guanidine moieties and polyhydroxyl compounds or heparan sulfate on the cell membrane will enhance cellular uptake of polyplexes. Three optimization steps are carried out (depicted in Fig. 1), with each being subjected to an iterative screening process, allowing assessment of the synergy between each modification. Optimization of the branched structure, disulfide bond content, and guanidinylation degree leads to a HPAESG, which, combining with MC DNA, gives a far superior transfection profile in both ADSCs and primary astrocytes.
Identification of the optimal HPAEs for gene transfection
Numerous studies have demonstrated that for branched polymeric gene vectors, the different topological structures have substantial effects on DNA binding affinity and size, zeta potential and morphology of polyplexes, all of which are relevant to the ultimate transfection efficiency and cytotoxicity36,42. To better understand the structure-property relationship and determine the optimal branched structure for sequential functionalization, we began by synthesizing HPAEs with gradually transited structures. By utilizing 4-amino-1-butanol (S4) and bisphenol A ethoxylate diacrylate (BE) as functional monomers and varying the content of the branching monomer trimethylolpropane triacrylate (TMPTA) in the feed ratio, we prepared a total of five HPAEs and one LPAE with similar molecular weights (Supplementary Tables 1 and 2 and Supplementary Figs. 1 and 2). As the TMPTA feed ratio increases (Supplementary Table 2), the evolution of the molecular weight of the corresponding HPAE-based polymer becomes faster, as reflected by the gel permeation chromatography (GPC) curves (Supplementary Fig. 3), indicating the acceleration of oligomer combinations by increasing the branching unit amount. The attempt to calculate the branching degree (BD) from nuclear magnetic resonance (NMR) spectra (Supplementary Fig. 2) was failed due to the identical chemical environment of the three vinyl groups in TMPTA (Supplementary Fig. 4). Instead, Mark-Houwink plots of the HPAEs were measured and the exponent (α) values were extracted to compare their extents of branching. As shown in Supplementary Table 2 and Supplementary Fig. 5, the α value for HPAE-1 to HPAE-5 was 0.48, 0.46, 0.44, 0.37, and 0.32, respectively, which was less than that of LPAE: 0.63, demonstrating the dendritic nature of HPAEs. Moreover, smaller α values were obtained from those HPAEs with higher TMPTA to BE feed ratios, corresponding to more spherical morphologies and thereby higher branching degrees. It is noteworthy that, although those HPAEs have broad molecular weight distributions with dispersity (Đ) values ranging from 2.94 to 6.80, which is a common feature for polymers from polycondesation reations43,44, their branched structures and molecular weights are consistent from batch to batch as shown in Supplementary Fig. 6 and Supplementary Table 3, highlighting their potential for the clinical applications.
Next, we characterized and compared three physiological properties of the polymer/DNA polyplexes: binding efficiency, size and surface charge. Picogreen assays showed that at polymer/DNA weight ratios (w/w) of 10:1 and 20:1, all polymers showed a strong DNA binding affinity (Fig. 2a). Dynamic light scattering (DLS) measurements further showed that all the polyplexes had sizes less than 250 nm (Fig. 2b). Of all the HPAE/DNA polyplexes, HPAE-3/DNA were slightly smaller than the other HPAE counterparts. The stability of LPAE/DNA and HPAE-3/DNA polyplexes (w/w = 20:1) was also tested. As shown in Supplementary Fig. 7, HPAE-3/DNA polyplexes remained stable in the presence of bovine serum albumin (BSA). Whereas, sizes of LPAE/DNA polyplexes increased dramatically, which is correlated to a recent observation by Anderson and colleagues45. With respect to the surface charge, all the polyplexes showed moderate positive zeta potentials (Fig. 2c). We speculate that the deviation in polyplex size and zeta potential between HPAEs and LPAE is possibly due to the different interaction mechanisms of polymers with DNA. As the branching degree increases, the polymers gradually transit from a linear, flexible structure to a globular, more rigid structure, meanwhile the number of terminal primary amines per polymer molecule also increases, contributing to the rise in positive charge. Since the DNA chain is highly charged and rigid because of the electrostatic repulsion, and HPAEs are globular, they perhaps condense DNA into a toroidal nano-ring structure, as opposed to LPAEs condensing the DNA into a more compact/spherical nanoparticle of smaller size. To validate our speculation, we used transmission electron microscopy (TEM) to observe the morphologies of different polyplexes. As shown in Fig. 2d, the HPAE-3/DNA polyplexes manifested a uniform and toroidal morphology while the LPAE/DNA counterparts showed a spherical morphology. We believe that the different size, zeta potential as well as morphologies would lead to different cellular uptake efficiency of polyplexes. Using Cy3 (a red fluorescence dye, used for DNA labeling) and Lyso-Tracker Green (a green fluorescence indicator of endo/lysosomes) as reporters, we showed that on HeLa cells, HPAE/DNA polyplexes indeed have a higher cellular uptake efficiency than the LPAE/DNA counterparts (Fig. 2e). The endo/lysosomal escape ability of the polyplexes was also compared by quantifying the Person correlation coefficient (PCC) using Image J. As shown in Supplementary Fig. 8, at the w/w ratio of 20:1, the average PCC of the HPAE-3/DNA and LPAE/DNA polyplexes calculated from three representative cell images were 0.30 and 0.62, respectively. The much lower PCC indicates that the HPAE-3/DNA polyplexes exhibit a stronger endo/lysosomal escape ability in comparison with the LPAE/DNA counterparts.
The gene transfection efficiency of the HPAEs was evaluated on HKC8 and HeLa cells, with three widely used commercial transfection reagents polyethylenimine (PEI), SuperFect and Lipofectamine 2000 (Lipo2k) as positive controls. As shown in Fig. 3a, Gluciferase activity of cells after transfection with HPAEs was substantially higher than that of the LPAE. Moreover, at the w/w ratio of 20:1, all HPAEs outperformed the three commercial reagents and orders-of-magnitude higher Gluciferase activity was observed. The images of cells after transfection with green fluorescent protein (GFP) further validated the high-transfection capability of the HPAE library (Fig. 3b–d and Supplementary Figs. 9 and 10). Our results conclude that the branched structure is much more conducive for gene transfection, with a relatively moderate branching degree (HPAE-3) showing higher transfection capability than the more branched HPAE-4 and HPAE-5 or less branched HPAE-1 and HPAE-2. This trend is in agreement with our previous report36, and we speculate that this is probably due to a good balance between polymer chain flexibility and rigidity. Moreover, HPAEs did not induce obvious cytotoxicity (Supplementary Fig. 11). To explore the possible mechanism of the good biocompatibility of HPAEs, the degradation of HPAE-3 was studied (Supplementary Methods). As shown in Supplementary Fig. 12, after 6 h of incubation in phosphate buffer solution (PBS), the molecular weights of HPAE-3 and LPAE both decreased obviously. The cytotoxicity of the degraded byproducts of HPAE-3 was further evaluated. They exerted negligible cytotoxicity; even if the concentration of degraded byproducts was up to 250 μg mL−1, over 90% of cell viability was maintained (Supplementary Fig. 13). All these data confirm that HPAEs are biodegradable and that the degraded byproducts are highly biocompatible without inducing any obvious cytotoxicity during the gene transfection process.
Integration of disulfide bonds to improve biodegradability
Vector degradability matters for gene transfection by affecting vector cytotoxicity and DNA release18,42,46. An intrinsic feature that distinguishes poly(β-amino ester)s from other vectors is its hydrolytic degradability in the physiological environment. However, the hydrolysis process is random and the duration ranges from several hours to a few days, which would result in poorly timed or off-target DNA release47,48, therefore spatiotemporally controlled DNA release is highly desired for gene transfection. GSH is a natural tripeptide with a concentration inside cells of around 2–10 mM while outside it is only 1–10 μM18,49. Cationic polymers containing disulfide bonds in the backbone can maintain extracellular stability, but can be cleaved quickly upon cell entry due to the high concentration of GSH causing the thiol-disulfide interchange reaction. Numerous researches have incorporated disulfide bonds into cationic polymers to induce material degradation and ultimate high-transfection efficacy50,51,52,53. Therefore, the integration of disulfide bonds into the backbone of HPAEs is of great significance for two reasons. Firstly, the branched structure has demonstrated to have very strong DNA condensation affinity (Fig. 2a), which would potentially lead to slow DNA release by hydrolysis. Secondly, the high-charge density (Fig. 2c) derived from the multiple terminal primary amines could induce cytotoxicity. To realize this realm, disulfanediylbis(ethane-2,1-diyl) diacrylate (DSDA) was introduced to the monomer combination for HPAE-3 synthesis (Supplementary Table 4 and Supplementary Fig. 14), and five disulfide-containing HPAEs (HPAESSs) with different DSDA feed ratios were produced via Michael addition approach (Supplementary Table 5 and Supplementary Figs. 15 and 16).
We firstly used GPC and Picogreen assays to confirm whether HPAESSs can be cleaved by GSH to enhance DNA release. The molecular weights of HPAESS-4 before and after incubation in 10 mM GSH solution for 1 h were shown in Fig. 4a. It is evident that after incubation with GSH, the molecular weight of HPAESS-4 substantially decreased from 16 to 6 kDa. In contrast, the molecular weight of HPAE-3, a polymer without disulfide bonds in the backbone, only decreased slightly from 14 to 13 kDa. In agreement with the GPC results, Picogreen assays further showed that in the presence of GSH, the DNA binding affinity of HPAESS-4 was significantly dropped from 97 to 35%, in sharp contrast with that of HPAE-3 (Fig. 4b). Moreover, at high concentrations ( > 100 μg mL−1), HPAESS-4 preserved substantially higher viability of primary astrocytes (Fig. 4c). Further, as the content of disulfide bonds increased, HPAESSs showed decreasing cytotoxicity (Fig. 4d). Similar to HPAEs, all the HPAESSs could effectively condense DNA to form nano-sized polyplexes with moderate surface charge (Supplementary Fig. 17). As a consequence, as confirmed by the Gluciferase activity analysis and GFP measurements, the gene transfection efficiency of HPAESSs is enhanced to a different degree by the introduction of disulfide bonds and HPAESS-4 exhibits the highest efficiency (Fig. 5). The fact that both enhanced DNA release and reduced cytotoxicity can be achieved simultaneously makes this strategy advantageous for the development of HPAE-based gene delivery vectors, in terms of ease of integration and improved performance.
Guanidinylation to facilitate polyplex cellular uptake
Cellular uptake of polyplexes poses another key barrier for achieving high gene transfection efficiency. In 2000, breakthrough studies by Wender et al.54 discovered that arginine-rich cellular penetrating peptides (CPPs) can form multiple hydrogen bonds with the phosphate, carboxylate, or sulfate groups located on cell surfaces, facilitating greater transportation of cargos (e.g., drug, DNA, siRNA, protein, quantum dots etc.) across the cellular membrane. Inspired by CPPs, a variety of non-viral gene vectors bearing guanidine moieties have been developed55,56. The multivalence of guanidine moieties can enhance polyplexes cellular membrane affinity and improve the cellular uptake efficiency of polyplexes.
Given that cellular uptake of polyplexes substantially affects the overall gene transfection efficiency of poly(β-amino ester)-based gene delivery systems, and the fact that HPAEs offer multiple reaction sites for further functionalization, one can envisage that guanidine groups can be incorporated to the peripheries of HPAE to enhance the cellular uptake of polyplexes. To this end, HPAESS-4 was selected for guanidinylation at a 10%, 30%, 60 and 100% degree (Supplementary Figs. 18 and 19, denoted as HPAESG-1 to HPAESG-4, respectively). The gunidinylation did not reduce the positive charges of HPAESS, instead, the formulated HPAESG/DNA polyplexes exhibited a slightly bigger size and comparatively higher zeta potential compared with the HPAESS/DNA counterparts (Supplementary Fig. 20), which is in accordance with previous studies55. Interestingly, some of the HPAESG-1/DNA polyplexes manifested a polyhedral morphology in comparison with that of the HPAESS/DNA counterparts exhibiting a uniform toroidal morphology (Fig. 6a). The effects of guanidinylation on promoting polyplex cellular uptake were evaluated on HeLa cells using Cy3 as a fluorescence reporter. After 4 h of incubation, there were numerous HPAESG-1/Cy3-DNA polyplexes inside the cells and the majority were accumulating around the nucleus (Fig. 6b). In contrast, the HPAESS-4/Cy3-DNA polyplexes showed a lower uptake efficiency. Furthermore, although the percentage of Cy3-positive cells after treatment with different polyplexes was similar (Fig. 6c), HPAESG/DNA polyplexes mediated much stronger fluorescence than the HPAESS-4/DNA counterparts (Fig. 6d). In contrast to the previous report55, here as the guanidinylation degree increased, the cellular uptake efficiency of HPAESG/DNA polyplexes decreased. Correspondingly, Gluciferase activity of cells after transfection with HPAESG library also gradually decreased with HPAESG-1 showing the highest transfection efficiency (Fig. 7). These results demonstrate that guanidinylation can indeed enhance the affinity of HPAESG/DNA polyplexes with cells, however, it is not simply a case of more guanidinylation giving better transfection.
HPAESG-1 shows high efficacy in ADSCs and astrocytes
We next transfected rADSC, hADSC, Neu7 astrocytes, and primary astrocytes using optimized HPAESG-1. As shown in Supplementary Fig. 21, HPAESG-1 exhibited high gene transfection activity on all the cell types. An approximate 1–4 orders of magnitude increase in transfection was shown compared to LPAE, which was also 15–106-fold higher than that of PEI, SuperFect and Lipo2k. For both hADSC and primary astrocytes, the Gluciferase activity after transfection by HPAESG-1 was still 15–18-fold stronger than the Lipo2k. Such high gene transfection performance by HPAESG-1 is outperformed most of the reported polymer-based vectors. For instance, a previous study using a cyclized poly(2-(dimethylami- noethyl) methacrylate) (PDMAEMA) to transfect hADSCs and Neu7, showing that Gluciferase activity of hADSC after transfection was only similar or even slightly lower than that mediated by SuperFect and PEI57. In another study, Gluciferase activity of Neu7 after transfection with a bio-reducible DSP8 polymer at its optimal w/w ratio of 3:1 was slightly higher than that mediated by SuperFect16. In contrast, here, the Gluciferase activity of ADSCs and astrocytes after transfection with HPAESG-1 is orders-of-magnitude higher than that mediated by PEI, SuperFect and Lipo2k. The high gene transfection capability of HPAESG-1 in ADSC and astrocytes was further compared with that of FuGENE, Xfect and Lipofectamine 3000 (Lipo3000). As shown in Supplementary Fig. 22, Gluciferase activity of rADSC and astrocytes after transfection with HPAESG-1 at the w/w ratio of 20:1 was between 4.6 and 170-fold higher than that mediated by FuGENE, Xfect and Lipo3000. Altogether, these results demonstrate the high gene transfection capability of HPAESG-1 in neurodegenerative disease relevant cells. Furthermore, HPAESG-1 is well tolerated by all cell types at the effective dosage, with at least 90% cell viability being preserved, starkly contrasting the severe cytotoxicity induced by PEI, SuperFect and Lipo2k (Supplementary Fig. 23).
HPAESG-1/MC DNA shows high efficacy in ADSCs and astrocytes
To further improve the transfection performance of HPAESG-1, we optimized the DNA itself by constructing a MC DNA encoding for GFP (MC GFP, 3.0 kbp). Interestingly, the difference in plasmid size significantly affects the physiological characteristics of the formulated polyplexes. All the polyplexes formulated from MC DNA showed an obviously smaller size in comparison with the counterparts formulated from normally sized 5.6 kbp GFP DNA (Supplementary Fig. 24). Across all the cell types, MC GFP mediated substantially higher transfection efficiency than the standard GFP regardless of gene vectors used; HPAESS-4 and HPAESG-1 showed significantly higher transfection efficiency than the LPAE and Lipo2k, however, HPAESG-1/MC GFP exhibited the most robust gene transfection efficiency: in rADSC, hADSC, Neu7, and primary astrocytes, the efficiency was 46%, 77%, 67%, and 52%, respectively (Fig. 8). These are very promising results because previously, the highest transfection efficiency of hADSCs achieved by Yang et al.58 was only 24%. Similarly, previous multiple repeats of lipofection only achieved 19% transfection efficiency in primary astrocytes59. These results show that HPAESG-1 in combination of MC DNA is capable of enhancing the gene transfection efficiency of ADSCs and astrocytes significantly. Moreover, HPAESG-1/MC GFP show high biocompatibility, with over 90% of cell viability being maintained (Supplementary Fig. 25).
High levels of nerve growth factor expression in astrocytes
The intended application target of the HPAESG-1/MC DNA polyplexes is neurodegenerative diseases, and thus a therapeutic gene—nerve growth factor (NGF) encoding plasmid PP NGF (7.7 kbp) and its MC construct MC NGF (3.7 kbp) were further constructed and used for transfection in Neu7 and primary astrocytes. NGF plays a critical protective role in the development and survival of sympathetic, sensory and forebrain cholinergic neurons by promoting neurite outgrowth and nerve cell recovery60,61,62. Given the strong dependency of the neurons on NGF, effective delivery of NGF encoding plasmid to relevant cells to promote NGF secretion is a promising strategy for gene therapy of neurodegenerative diseases63,64,65. The PP NGF was synthesized by subcloning the NGF fragment into the parental plasmid MN511A1 (PPMN511A1, 7063 bp) (Supplementary Figs. 26 and 27). MC NGF was then produced in ZYCY10P3S2T E. coli using the PhiC31 Integrase system (Fig. 9a and Supplementary Fig. 28). There was a GFP tag in the plasmids, therefore, both the GFP and NGF expression could be quantified with flow cytometry and ELISA (Supplementary Fig. 29), respectively. The most favorable parameters for a high level of human beta-NGF expression was first identified and it was found that in general, a relatively higher cell density, DNA dosage, longer transfection time, and serum-free condition were more favorable for NGF accumulation in the cell supernatant while no obvious cytotoxicity was induced. Figure 9 and Supplementary Fig. 30 showed that at the w/w = 20:1, the GFP expression in Neu7 and primary astrocyte transfected by HPAESG-1/MC NGF was up to 84.55% and 59.80%, respectively, even higher than the HPAESG-1/ MC GFP counterpart as reported above, which is likely due to the serum-free condition used. In contrast, only 44.04% and 31.23% GFP expression was achieved by the PP NGF. The NGF expression in the supernatants of Neu7 and primary astrocytes after transfection with the HPAESG-1/ MC NGF was measured to be at high levels as well, which was 6.5- and 12.3-fold higher than that mediated by the HPAESG-1/PP NGF counterparts (Fig. 9d and Supplementary Fig. 30c). These results demonstrate not only the superiority of MC DNA in gene transfection compared to normally sized plasmids, but also the robust transfection capability of the HPAESG-1/MC DNA polyplexes in delivering and mediating the expression of therapeutic genes in neurodegenerative disease relevant cells, highlighting its great applicability for potential clinical gene therapy. Bioactivity of the secreted NGF was further assessed by exploring its ability to promote neurite outgrowth in pheochromocytoma cells (PC12), and thus conditioned cell culture experiments were carried out. PC12 cells were incubated under four different conditions: standard PC12 cell culture media (DMEM with high a glucose concentration, PC12 media group), standard Neu7 cell culture media (DMEM with a low glucose concentration, Neu7 media group), conditioned Neu7 cell culture media (media saved from Neu7 cells after transfection with HPAESG-1/MC NFG, the concentration of NGF was determined to be 26.9 ng mL−1, Conditioned Neu7 media group) and standard PC12 cell culture media but with 50 ng mL−1 recombinant NGF (PC12 + NGF group), respectively. As shown in Fig. 10, after 7 days, the PC12 media group and Neu7 media group did not show any neurite outgrowth (as expected when NGF is absent). In contrast, clearly visible neurite outgrowth was detected in the conditioned Neu7 media group and the PC12 + NGF group. Owing to the higher concentration of NGF, the PC12 + NGF media promoted the outgrowth of neurite more significantly, as evidenced by the higher number and longer neurites. After 14 days of incubation, similar to the PC12 + NGF media, much more obvious neurite outgrowth was observed in the conditioned Neu7 media group. However, although the cell density increased substantially in the PC12 media group and Neu7 media group, there was still no neurite outgrowth detected. All these results demonstrate the high bioactivity of the NGF produced by the astrocytes, which is secreted to the surrounding environment. We also tried to directly transfect the PC12 with the HPAESG-1/MC NGF polyplexes. At the w/w ratio of 20:1, although around 18.76% GFP expression was observed, unfortunately, very limited neurite outgrowth was detected, as shown in Supplementary Fig. 31. This is because the level of NGF expression in PC12 cells was too low as confirmed by ELISA (< 5.0 pg mL−1).
If ex vivo or in vivo cell manipulation is to reach the clinical use, the transfection efficiency and the safety of non-viral vectors have to be drastically improved. Some of the most successful developments in the non-viral field have been through the development of poly(β-amino ester)s27,66. To date, most of this type of polymers has been focused upon linear structures14,25. However, we have recently shown that HPAEs may have a substantial advantage over their linear counterpart36,37. Herein, we have performed a stepwise modification and optimization strategy to break the hurdles of poor non-viral gene vectors.
In this work, we focused on two specific cell types relevant to gene therapy strategies for neurodegenerative disorders: ADSCs and astrocytes. Apart from the clinical implications of being able to transfect these cells, they were also chosen as a tough test bed for the development of an efficient vector. Using HKC8 and HeLa cells for the optimization steps, an iterative modification strategy was employed to optimize HPAEs to navigate the key barriers of gene transfection, including cytotoxicity, polyplex uptake, and DNA release. We started with optimization of the branched structure by synthesizing five HPAEs differing in branching degree. Polyplex characterization and gene transfection indicate that HPAEs with a moderate branching degree is more favorable for transfection. Increasing amounts of disulfide bonds were introduced into the backbone of HPAE-3, our results showed that the degradability of HPAESS was enhanced, with a corresponding increase in the rate of DNA release, and the cytotoxicity was significantly reduced. This work therefore corroborates that shown with PEI by Breunig et al.67. HPAESS-4 was further modified by guanidine for improved cellular penetrating ability. Interestingly, the lower guanidinylation degree is more effective, and at a high w/w ratio (e.g., 20:1) all the HPAESGs have similar transfection capability.
Turning towards the cell types of interest, the leading polymer from the third optimization step (HPAESG-1) was initially evaluated using a standard DNA construct. Up to 106-fold higher transfection efficiency was achieved by HPAESG-1 in comparison with the commercial reagents, whilst over 90% cell viability was preserved. Having optimized the vector, it was then desired to analyze whether a small DNA construct could add another layer of synergistic improvement. The accessory sequences for propagation of plasmid DNA can have adverse effects such as the viral/bacterial sequence triggering immune responses, or the antibiotic resistance sequences potentially transferring to the host68. Additionally, high level and long-term expression of functional proteins is highly sought after for gene therapy, to avoid high cost and repeated gene administrations. To this end, MC DNA constructs have been designed by removing the prokaryotic sequences resulting in a supercoiled minimally sized DNA cassette40,41,69.
When MC DNA was combined with HPAESG-1, high-transfection efficacy in rADSC, hADSC, Neu7 and primary astrocytes was achieved, indicating the synergistic effects of vector structure, degradability, functionalization and DNA construct. To demonstrate the potential clinical applicability, a therapeutic MC NGF was further constructed and it was found that high level of NGF expression in astrocytes was achieved. Importantly, the NGF showed high bioactivity to promote neurite outgrowth from PC12 cells. All these results demonstrate that the synergistic gene delivery system comprising an optimized gene vector and an optimal DNA construct can achieve robust transfection activity and high safety simultaneously, implying the great potential of this system in the treatment of neurological diseases. In addition, given the ease of operation and versatility, our synergistic modification strategy may be used for the development of various non-viral gene delivery vectors targeting diverse cell types and diseases.
Iterative modification and optimization of HPAEs
As outlined in Supplementary Table 1, to synthesize HPAE-1 to HPAE-5, the stoichiometric ratio of the overall amines to acrylates was kept at 1:1.2. Monomers S4, TMPTA and BE with varying ratios were dissolved in dimethyl sulfoxide (DMSO), respectively, to an overall monomer concentration of 500 mg mL−1. The reaction occurred at 90 oC to generate acrylate terminated base polymers. Afterwards, DMSO was added to dilute the reaction mixture to 100 mg mL−1, and then a second amine DT was added to end-cap the generated base polymers at room temperature for 48 h. To purify the polymers, the reaction mixtures were precipitated into diethyl ether three times. Polymers were collected, dried under vacuum for 24 h at room temperature and then stored at −20 oC for the following studies. The corresponding linear polymer LPAE, was prepared following the same procedures using bulk polymerization without triacrylate monomer TMPTA or the solvent DMSO.
The HPAE-3 was functionalized by introducing disulfide bonds to the backbone. As outlined in Supplementary Table 4, the stoichiometric ratio of the overall amines to acrylates was 1:1.2, TMPTA and S4 and the monomer feed ratios were the same as above, while varying amounts of DSDA and BE were employed. Five HPAEs that differed in the content of disulfide component, termed as HPAESS-1 to HPAESS-5, respectively, were prepared as above. The HPAESS-4 was further functionalized by introducing multiple guanidine groups at the periphery primary amines (calculated to be 0.64 mmol g−1). Briefly, 94 mg HPAESS-4 was dissolved in DMSO, and then the guanidinylation agents 1H-pyrazole-1-carboxamidine hydrochloride (HPCH) and N,N-diisopropylethylamine (DIPEA) (in equivalent mole, 0.006, 0.018, 0.036, and 0.06 mmol, respectively) were added. After 2 days of reaction at room temperature, the reaction mixtures were directly dialyzed against DMSO for 3 days. The final products, HPAESG-1 to HPAESG-4 of 10%, 30%, 60% or 100% guanidinylation degree, respectively, were lyophilized.
HPAESS degradation in the presence of GSH
Fifty milligram of polymers were dissolved in 1 mL sodium acetate buffer, followed by addition of GSH solution (20 mM, 1 mL). The mixtures were kept stirring at room temperature (RT) for 1 h and then lyophilized immediately. Molecular weights of the degraded products were measured with GPC.
Polyplex size and zeta potential
To measure the size and zeta potential, polyplexes were firstly prepared by adding polymer solution into DNA solution at a 1:1 volume ratio, mixing and incubating for 10 min, 2 μg Gluc DNA was used for each sample. The polyplexes were then diluted to 1 mL with PBS. Size and zeta potential were measured with DLS and electrophoretic light scattering, respectively. To test polyplex stability in the presence of protein, LPAE/DNA and HPAE-3/DNA polyplexes (w/w = 20 :1) were prepared as above and then diluted to 1 mL with BSA containing deionized water, the final concentration of BSA was 0.5%. Size of the polyplexes was measured with DLS immediately at 0, 0.5 and 1 h after preparation, respectively.
Subcloning of NGF into PPMN511A1
The parental plasmid (PPMN511A1) was used as a minicircle construction system (System Biosciences). The PPMN511A1 (vector, V) (7.0 kbp) was digested by XbaI and BamHI enzymes. Simultaneously, XbaI and BamHI enzymes digestion sites were used to cut the human NGF gene fragment (insert, I) (0.7 kbp) from pEX-A2-NGF plasmid, which was synthesized by Eurofins. After the digestion, DNA was run on a 0.8% agarose gel in 1X tris-acetate EDTA buffer (TAE) at 110 V for 1 h to separate NGF bands from the pEX-A2 backbone band. Then NGF containing gel fragments was cut by a scalpel and placed into a microcentrifuge tube. For successful ligations, NGF fragment was then purified from agarose gel using advanced QIAEX II® Gel Extraction Kit. After that, PPMN511A1 (V) and purified NGF fragment (I) were ligated using T4 DNA Ligase at 1:3 molar ratio of V: I at 22 °C for 3 h, followed by inactivation at 70 °C for 10 min. The ligation products were transformed into competent ZYCY10P3S2T E. coli, and eight colonies were selected for screening from the agar plates with kanamycin (50 µg mL−1). The NGF fragment was inserted into the PP (V) at a position downstream of the CMV promoter. The new generated plasmid is the PPMN511A1-NGF DNA (PP NGF, 7.7 kbp). The structure of the PP NGF was determined by restriction digestion and electrophoresis analysis on 1% agarose gels.
MC NGF production
Highly pure MC NGF (3.7 kbp) under the control of CMV promoter was produced as following: On the first day, 20 µL of transformed ZYCY E. coli with constructed PP NGF were cultured in 5 mL of lysogeny broth (LB) media contains kanamycin (50 µg mL−1) at 37 °C under shaking (250 rpm) for 5 h (starting culture). Following which, 400 mL of terrific broth (TB) with kanamycin (50 µg mL−1) was inoculated with 100 µL of the TB from the starting culture media and incubated at 37 °C and 250 rpm shaking overnight. The next day, around 416 mL of MC Induction Mix (I.M.) (400 mL of LB, 16 mL of 1 N NaOH and 420 μL of 20% l-arabinose) was added and the culture media was incubated at 31 °C and 250 rpm shaking for 7 h. Next day, the bacterial cells contain MC NGF were centrifuged at 4149 x g and the plasmid was purified following standard procedures. The structure of the PP NGF and MC NGF were determined by restriction digestion and electrophoresis analysis on 1% agarose gels.
Further information on research design is available in the Nature Research Reporting Summary linked to this article.
All data relevant to this study are available from the corresponding author upon reasonable request.
Lindvall, O. & Kokaia, Z. Stem cells for the treatment of neurological disorders. Nature 441, 1094–1096 (2006).
Bray, N. A second wave. Nat. Rev. Neurosci. 17, 76 (2016).
Barker, R. A., Drouin-Ouellet, J. & Parmar, M. Cell-based therapies for Parkinson disease-past insights and future potential. Nat. Rev. Neurol. 11, 492–503 (2015).
Emerich, D. F., Orive, G., Thanos, C., Tornoe, J. & Wahlberg, L. U. Encapsulated cell therapy for neurodegenerative diseases: from promise to product. Adv. Drug Del. Rev. 67-68, 131–141 (2014).
Teixeira, F. G., Carvalho, M. M., Sousa, N. & Salgado, A. J. Mesenchymal stem cells secretome: a new paradigm for central nervous system regeneration? Cell. Mol. Life Sci. 70, 3871–3882 (2013).
Hoban, D. B., Howard, L. & Dowd, E. GDNF-secreting mesenchymal stem cells provide localized neuroprotection in an inflammation-driven rat model of Parkinson’s disease. Neuroscience 303, 402–411 (2015).
Hoban, D. B. et al. The reduction in immunogenicity of neurotrophin overexpressing stem cells after intra-striatal transplantation by encapsulation in an in situ gelling collagen hydrogel. Biomaterials 34, 9420–9429 (2013).
Pekny, M. et al. Astrocytes: a central element in neurological diseases. Acta Neuropathol. 131, 323–345 (2016).
Chan, T. M. et al. ADSC therapy in neurodegenerative disorders. Cell Transplant. 23, 549–557 (2014).
Tai, Y. T. & Svendsen, C. N. Stem cells as a potential treatment of neurological disorders. Curr. Opin. Pharmacol. 4, 98–104 (2004).
Chang, K. A., Lee, J. H. & Suh, Y. H. Therapeutic potential of human adipose-derived stem cells in neurological disorders. J. Pharmacol. Sci. 126, 293–301 (2014).
Dantuma, E., Merchant, S. & Sugaya, K. Stem cells for the treatment of neurodegenerative diseases. Stem Cell Res. Ther. 1, 37 (2010).
Crook, J. M., Wallace, G. & Tomaskovic-Crook, E. The potential of induced pluripotent stem cells in models of neurological disorders: implications on future therapy. Expert Rev. Neurother. 15, 295–304 (2015).
Yang, F. et al. Genetic engineering of human stem cells for enhanced angiogenesis using biodegradable polymeric nanoparticles. Proc. Natl Acad. Sci. U.S.A 107, 3317–3322 (2010).
Tzeng, S. Y. et al. Non-viral gene delivery nanoparticles based on poly(beta-amino esters) for treatment of glioblastoma. Biomaterials 32, 5402–5410 (2011).
Newland, B. et al. GDNF gene delivery via a 2-(dimethylamino)ethyl methacrylate based cyclized knot polymer for neuronal cell applications. ACS Chem. Neurosci. 4, 540–546 (2013).
Newland, B. et al. Untying a nanoscale knotted polymer structure to linear chains for efficient gene delivery in vitro and to the brain. Nanoscale 6, 7526–7533 (2014).
Bauhuber, S., Hozsa, C., Breunig, M. & Goepferich, A. Delivery of nucleic acids via disulfide-based carrier systems. Adv. Mater. 21, 3286–3306 (2009).
Pack, D. W., Hoffman, A. S., Pun, S. & Stayton, P. S. Design and development of polymers for gene delivery. Nat. Rev. Drug Discov. 4, 581–593 (2005).
Breunig, M., Lungwitz, U., Liebl, R. & Goepferich, A. Breaking up the correlation between efficacy and toxicity for nonviral gene delivery. Proc. Natl Acad. Sci. U.S.A. 104, 14454–14459 (2007).
Liu, S. et al. Bioreducible zinc(II)-coordinative polyethylenimine with low molecular weight for robust gene delivery of primary and stem cells. J. Am. Chem. Soc. 139, 5102–5109 (2017).
Mintzer, M. A. & Simanek, E. E. Nonviral vectors for gene delivery. Chem. Rev. 109, 259–302 (2009).
Guo, X. & Huang, L. Recent advances in nonviral vectors for gene delivery. Acc. Chem. Res. 45, 971–979 (2012).
Wei, H., Schellinger, J. G., Chu, D. S. H. & Pun, S. H. Neuron-targeted copolymers with sheddable shielding blocks synthesized using a reducible, RAFT-ATRP double-head agent. J. Am. Chem. Soc. 134, 16554–16557 (2012).
Lynn, D. M. & Langer, R. Degradable poly(beta-amino esters): synthesis, characterization, and self-assembly with plasmid DNA. J. Am. Chem. Soc. 122, 10761–10768 (2000).
Lynn, D. M., Anderson, D. G., Putnam, D. & Langer, R. Accelerated discovery of synthetic transfection vectors: parallel synthesis and screening of degradable polymer library. J. Am. Chem. Soc. 123, 8155–8156 (2001).
Akinc, A., Lynn, D. M., Anderson, D. G. & Langer, R. Parallel synthesis and biophysical characterization of a degradable polymer library for gene delivery. J. Am. Chem. Soc. 125, 5316–5323 (2003).
Green, J. J., Langer, R. & Anderson, D. G. A combinatorial polymer library approach yields insight into nonviral gene delivery. Acc. Chem. Res. 41, 749–759 (2008).
Green, J. J. et al. Combinatorial modification of degradable polymers enables transfection of human cells comparable to adenovirus. Adv. Mater. 19, 2836–2842 (2007).
Li, C., Tzeng, S. Y., Tellier, L. E. & Green, J. J. 3-aminopropyl)-4-methylpiperazine end-capped poly(1,4-butanediol diacrylate-co-4-amino-1-butanol)-based multilayer films for gene delivery. ACS Appl. Mater. Interfaces 5, 5947–5953 (2013).
Anderson, D. G., Akinc, A., Hossain, N. & Langer, R. Structure/property studies of polymeric gene delivery using a library of poly(beta-amino esters). Mol. Ther. 11, 426–434 (2005).
Sunshine, J. C., Akanda, M. I., Li, D., Kozielski, K. L. & Green, J. J. Effects of base polymer hydrophobicity and end-group modification on polymeric gene delivery. Biomacromolecules 12, 3592–3600 (2011).
Anderson, D. G. et al. A polymer library approach to suicide gene therapy for cancer. Proc. Natl. Acad. Sci. U. S. A. 101, 16028–16033 (2004).
Sunshine, J. et al. Small molecule end group of linear polymer determines cell-type gene delivery efficacy. Adv. Mater. 21, 4947–4951 (2009).
Lee, C. C., MacKay, J. A., Frechet, J. M. & Szoka, F. C. Designing dendrimers for biological applications. Nat. Biotechnol. 23, 1517–1526 (2005).
Zhou, D. et al. The transition from linear to highly branched poly(beta-amino ester)s: branching matters for gene delivery. Sci. Adv. 2, e1600102 (2016).
Cutlar, L. et al. Highly branched poly(beta-amino esters): synthesis and application in gene delivery. Biomacromolecules 16, 2609–2617 (2015).
Huang, J. Y. et al. Tailoring highly branched poly(beta-amino ester)s: a synthetic platform for epidermal gene therapy. Chem. Commun. 51, 8473–8476 (2015).
Zhou, D. et al. Highly branched poly(β-amino ester)s for skin gene therapy. J. Control. Release 244, 336–346 (2016).
Darquet, A. M., Cameron, B., Wils, P., Scherman, D. & Crouzet, J. A new DNA vehicle for nonviral gene delivery: supercoiled minicircle. Gene Ther. 4, 1341–1349 (1997).
Bigger, B. W. et al. An araC-controlled bacterial cre expression system to produce DNA minicircle vectors for nuclear and mitochondrial gene therapy. J. Biol. Chem. 276, 23018–23027 (2001).
Zhao, T. Y. et al. Significance of branching for transfection: synthesis of highly branched degradable functional poly(dimethylaminoethyl methacrylate) by vinyl oligomer combination. Angew. Chem. Int. Ed. 53, 6095–6100 (2014).
Sun, M., Hong, C. Y. & Pan, C. Y. A unique aliphatic tertiary amine chromophore: fluorescence, polymer structure, and application in cell imaging. J. Am. Chem. Soc. 134, 20581–20584 (2012).
You, Y. Z., Yu, Z. Q., Cui, M. M. & Hong, C. Y. Preparation of photoluminescent nanorings with controllable bioreducibility and stimuli‐responsiveness. Angew. Chem. Int. Ed. 49, 1099–1102 (2010).
Patel, A. K. et al. Inhaled nanoformulated mRNA polyplexes for protein production in lung epithelium. Adv. Mater. 31, 1805116 (2019).
Kozielski, K. L., Tzeng, S. Y., De Mendoza, B. A. & Green, J. J. Bioreducible cationic polymer-based nanoparticles for efficient and environmentally triggered cytoplasmic siRNA delivery to primary human brain cancer cells. ACS Nano 8, 3232–3241 (2014).
Sunshine, J. C., Peng, D. Y. & Green, J. J. Uptake and transfection with polymeric nanoparticles are dependent on polymer end-group structure, but largely independent of nanoparticle physical and chemical properties. Mol. Pharm. 9, 3375–3383 (2012).
Kozielski, K. L., Tzeng, S. Y. & Green, J. J. A bioreducible linear poly(beta-amino ester) for siRNA delivery. Chem. Commun. 49, 5319–5321 (2013).
Liu, S. et al. Biodegradable highly branched poly(β-amino ester)s for targeted cancer cell gene transfection. ACS Biomater. Sci. Eng. 3, 1283–1286 (2017).
Elzes, M. R., Akeroyd, N., Engbersen, J. F. & Paulusse, J. M. Disulfide-functional poly (amido amine) s with tunable degradability for gene delivery. J. Control. Release 244, 357–365 (2016).
Ou, M., Xu, R., Kim, S. H., Bull, D. A. & Kim, S. W. A family of bioreducible poly (disulfide amine) s for gene delivery. Biomaterials 30, 5804–5814 (2009).
Yu, H., Russ, V. & Wagner, E. Influence of the molecular weight of bioreducible oligoethylenimine conjugates on the polyplex transfection properties. AAPS J. 11, 445–455 (2009).
Oupický, D., Parker, A. L. & Seymour, L. W. Laterally stabilized complexes of DNA with linear reducible polycations: strategy for triggered intracellular activation of DNA delivery vectors. J. Am. Chem. Soc. 124, 8–9 (2002).
Wender, P. A. et al. The design, synthesis, and evaluation of molecules that enable or enhance cellular uptake: peptoid molecular transporters. Proc. Natl Acad. Sci. U.S.A. 97, 13003–13008 (2000).
Zhang, B., Ji, W., Liu, W. & Yao, K. Guanidinylated allylamine-N-isopropylacrylamide copolymer nonviral transgene vectors. Int. J. Pharm. 331, 116–122 (2007).
Kim, T. I., Lee, M. & Kim, S. W. A guanidinylated bioreducible polymer with high nuclear localization ability for gene delivery systems. Biomaterials 31, 1798–1804 (2010).
Newland, B. et al. Single cyclized molecule versus single branched molecule: a simple and efficient 3D “knot” polymer structure for nonviral gene delivery. J. Am. Chem. Soc. 134, 4782–4789 (2012).
Yang, F. et al. Gene delivery to human adult and embryonic cell-derived stem cells using biodegradable nanoparticulate polymeric vectors. Gene Ther. 16, 533–546 (2009).
Wu, B. Y., Liu, R. Y., So, K. L. & Yu, A. C. H. Multi-lipofection efficiently transfected genes into astrocytes in primary culture. J. Neurosci. Meth. 102, 133–141 (2000).
Aloe, L., Rocco, M. L., Balzamino, B. O. & Micera, A. Nerve growth factor: a focus on neuroscience and therapy. Curr. neuropharmacol. 13, 294–303 (2015).
Weissmiller, A. M. & Wu, C. Current advances in using neurotrophic factors to treat neurodegenerative disorders. Transl. Neurodegener. 1, 14 (2012).
Lindsay, R. M. Neurotrophic growth factors and neurodegenerative diseases: therapeutic potential of the neurotrophins and ciliary neurotrophic factor. Neurobiol. Aging 15, 249–251 (1994).
Tuszynski, M. H. et al. Nerve growth factor gene therapy: activation of neuronal responses in Alzheimer disease. JAMA Neurol. 72, 1139–1147 (2015).
Malkki, H. NGF gene therapy activates neurons in the AD patient brain. Nat. Rev. Neurol. 11, 548 (2015).
Iulita, M. F. & Cuello, A. C. Nerve growth factor metabolic dysfunction in Alzheimer’s disease and Down syndrome. Trends Pharmacol. Sci. 35, 338–348 (2014).
Anderson, D. G., Lynn, D. M. & Langer, R. Semi-automated synthesis and screening of a large library of degradable cationic polymers for gene delivery. Angew. Chem. Int. Ed. 42, 3153–3158 (2003).
Breunig, M. et al. Mechanistic investigation of poly(ethylene imine)-based siRNA delivery: disulfide bonds boost intracellular release of the cargo. J. Control. Release 130, 57–63 (2008).
Chen, Z. Y., He, C. Y., Meuse, L. & Kay, M. A. Silencing of episomal transgene expression by plasmid bacterial DNA elements in vivo. Gene Ther. 11, 856–864 (2004).
Keeney, M. et al. Development of poly(beta-amino ester)-based biodegradable nanoparticles for nonviral delivery of minicircle DNA. ACS Nano 7, 7241–7250 (2013).
This work was funded by Science Foundation Ireland (SFI) Principal Investigator Program (13/IA/1962), National Natural Science Foundation of China (NSFC) (51873179) and University College Dublin.
The authors declare no competing interests.
Peer review information: Nature Communications thanks anonymous reviewer(s) for their contribution to the peer review of this work.
Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Liu, S., Gao, Y., Zhou, D. et al. Highly branched poly(β-amino ester) delivery of minicircle DNA for transfection of neurodegenerative disease related cells. Nat Commun 10, 3307 (2019). https://doi.org/10.1038/s41467-019-11190-0
Strategies and materials of "SMART" non-viral vectors: Overcoming the barriers for brain gene therapy
Nano Today (2020)
ACS Applied Materials & Interfaces (2020)
Bioreducible, branched poly(β-amino ester)s mediate anti-inflammatory ICAM-1 siRNA delivery against myocardial ischemia reperfusion (IR) injury
Biomaterials Science (2020)
Acta Pharmaceutica Sinica B (2020)
Self-responsive co-delivery system for remodeling tumor intracellular microenvironment to promote PTEN-mediated anti-tumor therapy