This study investigated micro-patterned, high-density complementary metal–oxide–semiconductor (CMOS) electrode array to be used as biologically permissive environment for organization, guidance and electrical stimulation of spiral ganglion neurons (SGN). SGNs extracted and isolated from cochleae of P5-P7 rat pups and adult guinea pigs were cultured 1, 4 and 7 days in vitro on glass coverslips (control) and CMOS electrode array. The cultures were analyzed visually and immunohistochemically for SGN presence, outgrowth, neurite alignment, neurite length, neurite asymmetry as well as the contact of a neuronal soma and neurites with the micro-electrodes. Our findings indicate that topographical environment of CMOS chip with micro-patterned pillars enhanced growth, survival, morphology, neural orientation and alignment of SGNs in vitro compared to control. Smaller spacing (0.8–1.6 µm) between protruding pillars on CMOS led SGNs to develop structured and guided neurites oriented along three topographical axes separated by 60°. We found morphological basis for positioning of the micro-electrodes on the chip that was appropriate for direct contact of SGNs with them. This configuration allowed CMOS electrode array to electrically stimulate the SGN whose responses were observed with live Fluo 4 calcium imaging.
The cochlear implant (CI) is currently the prevailing neuro-prosthetic treatment for partial restoration of hearing in deaf people. Despite its significant success, it is rather limited in terms of full recovery of sensorineural hearing loss (SNHL), caused by the loss or impairment of either hair cells, i.e. sensory cells in the inner ear or spiral ganglion neurons (SGN), or both, which affects majority of hearing impaired patients1,2,3. A CI comprises a linear electrode array containing up to 26 electrodes that is surgically inserted into the cochlea, typically within the perilymph-filled scala tympani4. This arrangement functionally bypasses some or all of approximately 3,400 malfunctioned hair cells by directly stimulating preserved spiral ganglion neurons which forms the auditory nerve5,6. Due to the limited spectro-temporal information delivered with electrical stimulation, speech perception as well as listening to music are still rather inadequate in the majority of CI users, especially in real-world settings7,8. The neuron-electrode interface plays a crucial role in neural coding of the auditory information. Our approach to overcome major constraint of non-focal and non-selective electrical stimulation of SGNs, located in the auditory nerve, is based on substantial increase in the number of stimulating electrodes. The significant reduction in the size of stimulating electrodes allows comparability to the cellular size of SGNs. This approach targets not only decreased SGN survival which largely depends on the duration and etiology of deafness, but also the anatomical gap between the implanted electrode array and the stimulated regions of the auditory nerve3,5,6,7,9,10,11. Survival, regeneration and guidance of spiral ganglion neurons were the focus of recent studies10,12,13,14,15,16. However, controlled guidance and patterned growth of the auditory neurons to form intimate contact with stimulating electrodes remain elusive. Several studies reported chemical cues, like nerve growth factors or neurotrophins for regeneration and guidance of SGN10,17,18,19. Due to safety issues and the degradation of the chemicals such an approach may not be desirable for clinical applications. For this reason, several in vitro studies demonstrated topographical cues for organization and guidance of neurites18,20,21,22,23,24,25,26,27,28,29. One of them, the so called the “passive model”- silicon micro-pillar substrates (MPS), is composed of biocompatible material with surfaces proven to control neuronal growth and morphology in vitro23,25,27,28,30. Studies by Mattotti et al.27 with SGNs isolated from neonatal rats and Repić et al.29 with neonatal and adult dorsal root ganglion neurons demonstrated the capacity of micro-pillar substrates to support normal neuronal growth, enhance neurite alignment, promote outgrowth and induce specific morphologies on micro-pillars. Furthermore, several recent attempts to embed microelectrodes into multi-electrode arrays (MEA) using complementary metal–oxide–semiconductor (CMOS) technology yield promising results31,32,33,34,35. MPS can attract and guide spiral ganglion neurons but cannot ensure long-term neuronal survival due to absence of electrical stimulation. In vivo studies have demonstrated that electrical stimulation from CI electrodes promotes survival of SGN36,37. Another important issue, specifically investigated in this study, is whether neuronal morphology is affected by the position of CMOS micro-electrodes’ embedded by CMOS among the pillars. In contrast, MPS is a “passive substrate” containing only pillars and cannot provide information on the effect of the position of micro-electrodes’. Thus, a step further from MPSs is an “active model” which is a substrate incorporating CMOS with a potential to simultaneously stimulate neurons and record their electrical activity. In this study, we developed and used CMOS chip substrates consisting of protruding pillars and pillar-like titanium nitride (TiN) micro-electrodes between 1.4 and 4.8 µm in diameter and with a spacing between 0.8 and 1.6 µm with a height of 1 µm. These dimensions are similar to typical mammalian cell bodies31,32,33. Furthermore, these micro-electrodes incorporate in situ circuits for voltage and current stimulation with an amplification transistor, all embedded in a silicon oxide environment.
For successful electrical stimulation it is crucial to investigate electrophysiologically relevant morphological specializations of SGN cultured in vitro in this active model and to assess whether its topography can serve as favorable environment for the organization and guidance of SGNs. Adult-derived SGNs from guinea pigs were cultured on these CMOS substrates and were compared with SGN cultures from neonatal (P5-P7) rat pups in order to assess the effect of micro-patterned surfaces of CMOS chips on neuronal presence, survival, morphology and alignment as well as the effect of age on sensitivity to topography. Finally, CMOS electrode array was used to investigate electrical stimulation of the SGN.
Materials and Methods
Complementary semi-conductor metal oxide (CMOS) chip design
In this study, we used the CMOS chip with the design, fabrication and specifications reported in Huys et al.35. Briefly, the 0.18 µm TSCM platform technology was used to create probe-card wafers, consisting of a field dielectric layer of 400 nm SiO2 and one aluminum metal interconnect layer of 800 nm and 400 nm on top. Formation of three-dimensional structures with electrodes was supported by introducing vias and a layer of 100 nm TiN coating as well as with etching the oxide layer around the electrodes. In this way, an 8 × 8 mm2 chip array with 16,184 electrodes with individual addressability for electrical stimulation and recording was obtained. Figure 1 shows CMOS chip design together with scanning electron micrographs of superficial areas of an electrode array at different scales. Chips were grouped into two categories, depending on pillar widths. Narrow pillar widths were from 1.4 µm to 2.4 µm (1.4, 1.6, 2 and 2.4 µm) while wide pillar widths were from 2.8 µm to 4.8 µm (2.8, 3.2, 4 and 4.8 µm). Pillar spacing was from 0.8 µm to 1.6 µm (0.8, 1, 1.4 and 1.6 µm) and was equally distributed in areas of both narrow and wide pillars. Pillar height was kept constant at 1 µm. Chips were fabricated at Imec vzw (Leuven, Belgium).
Preparation of CMOS chips and glass coverslips
CMOS chips were cleaned overnight with acetone (Gram-Mol, Zagreb, Croatia). All substrates were sterilized in 70% ethanol (Carlo Garba Reagents, Val de Reuil, France) and coated with 0.01% poly-L-ornithine (Sigma-Aldrich, St. Louis, Missouri, US) at room temperature overnight, cleaned with sterile water and allowed to dry under sterile conditions. All samples were then placed in 24-well plates (TPP, Trasadingen, Switzerland) for testing.
The University of Split School of Medicine Animal Care and Use Committee as Veterinary and Food Safety Office of the Ministry of Agriculture of Republic of Croatia approved all protocols and experimental plans used in the study (Class.003-08/15-03/0001). SGNs were isolated from 5 to 7 day-old rat pups (Sprague-Dawley) and adult guinea pigs (male and female, 350–430 g, Dunkin-Hartley). Rat pups were placed on ice, anesthetized then decapitated. Dissecting buffer contained phosphate buffered saline (PBS) supplemented with 0.3% bovine serum albumin (BSA, Sigma-Aldrich, St. Louis, Missouri, US) and 0.6% glucose (Merck, Kenilworth, New Jersey, US). Under an operating microscope, the skull was opened along the mid-sagittal plane and the brain removed. The temporal bone was harvested and transferred to clean dissecting buffer. The otic capsule was dissected and the cochlea was identified and isolated. The organ of Corti and modiolar cartilage were removed and the spiral ganglia collected in the dissecting buffer. Guinea pigs were anesthetized by intraperitoneal injection of ketamine (150 mg/kg, Richter Pharma, Wels) and xylazine (10 mg/kg, Alfasan, Woerden, Netherlands) then decapitated. The skull was bisected and the brain removed. The temporal bone was harvested and transferred to clean dissecting buffer in such way that it was rested on the external acoustic meatus. The opening in the bulla was made using fine forceps. Using this hole, the rest of the roof of the middle ear cavity was removed with a pair of a fine forceps. The bony cochlea appeared in view when the cavity of the middle ear was fully opened. With delicate movements, the spiral lamina was isolated from the rest of the bony cochlea. The modiolus became exposed and separated from the rest of the temporal bone. Following its removal, the modiolus was broken up into several small pieces using fine forceps and collected in the dissecting buffer.
For dissociation, 500 µl of 0.25% trypsin-EDTA (Sigma-Aldrich, St. Louis, Missouri, US) with the addition of 38 U/ml DNase (Sigma Aldrich, St. Louis, Missouri, US) was used. Dissociation was performed at 37 °C for 30 minutes. The trypsinization was stopped by adding an equal volume (500 µl) of DMEM:F12 (Gibco, Waltham, Massachusetts, US) supplemented with 10% of Fetal Bovine Serum (FBS, Sigma-Aldrich, St. Louis, Missouri, US), also termed the STOP solution. For adult SGNs, the trypsinization was repeated twice for better dissociation. The tissue was then triturated, first with a 1000 µl pipette tip (gentle up and down suction for 20–25 times), followed by a 200 µl pipette tip (gentle suction for 20–25 times). Large pieces were allowed to settle down and the cell suspension was collected. The cell suspension was then centrifuged for 5 minutes at 1000 rpm and the pellet was resuspended in 500 µl of culture medium which consisted of Neurobasal-A (Gibco, Waltham, Massachusetts, US) supplemented with 1% Pen/Strep (Lonza, Basel, Switzerland), 0.25% L-Glutamine (Milipore, Billerica, Massachusetts, US), 2% B27-supplement (Gibco, Waltham, Massachusetts, US) and 30 ng/ml GDNF (Milipore, Billerica, Massachusetts, US). For the adult SGNs, centrifugation was performed for 5 minutes at 2000 rpm and the pellet was resuspended in the same culture medium where two additional growth factors were added: 30 ng/ml BDNF (Milipore, Billerica, Massachusetts, US) and 30 ng/ml NT-3 (Milipore, Billerica, Massachusetts, US). Cells were counted using a Bürker-Türk chamber and seeded in a 100 µl volume at a density of 20,000 cells/well. Cells were allowed to settle down for 1–2 h in the incubator (37 °C, 5% CO2, 85% humidity) when they were cultivated on glass coverslips and for 2–3 h when they were cultivated on CMOS chips, after which the rest of the medium was carefully added to the well. Half of the medium was changed every 2–3 days.
Immunocytochemistry, cell imaging and scanning electron microscopy (SEM)
SGNs were cultured during 1, 4 and 7 days in vitro (DIV) and fixed with 4% paraformaldehyde for 30 minutes. For immunocytochemical analyses, samples were washed three times with 0.01 M PBS, permeabilized with 0.1% Triton X-100 (Milipore, Billerica, Massachusetts, US) for 5 minutes and blocked with PBS containing 1% normal goat serum (Dako, Glostrup, Denmark) for 90 minutes. The cells were then incubated in dark humidity chamber overnight at 4 °C in PBS with 1% normal goat serum and mouse monoclonal anti-ßIII-tubuline (1:500, Milipore, Billerica, Massachusetts, US) to stain neurons (named Tuj) and rabbit polyclonal anti-S100 (1:500, Sigma-Aldrich, St. Louis, Missouri, US) to stain glial cells. Type I neurons compose ≈95% of the spiral ganglion and innervate the inner hair cells, while Type II neurons, which compose only ≈5% of the ganglion, innervate the outer hair cells38,39. We used peripherin-specific (an intermediate filament) immunolabelling in order to differentiate Type II SGNs from Type I SGNs in guinea pigs, as Type II SGNs showed more powerful peripherin positivity than Type I SGNs40,41,42. Rabbit polyclonal anti-peripherin (1:200; Milipore, Billerica, Massachusetts, US) was used in combination with Tuj (1:500). On the next day, cells were washed three times with 0.01 M PBS, incubated for 90 minutes at room temperature in PBS with 1% normal goat serum with Alexa 488 goat anti mouse (1:500, Life Technologies, Carlsbad, California, US) and Alexa 568 goat anti-rabbit (1:500, Life Technologies, Carlsbad, California, US) secondary antibodies. At the end, DAPI (Molecular Probes, Eugene, Oregon, US) in a ratio of 1:500 for 5 minutes was added. The samples were finally washed five more times with 0.01 M PBS and prepared for imaging with Immu-Mount (Thermo Scientific, Waltham, Massachusetts, US). Imaging was carried out with the Olympus BX51 fluorescence microscope (Shinjuku, Tokyo, Japan) equipped with an Olympus DP71 camera. For SEM imaging, samples were fixed with 4% paraformaldehyde for 30 minutes, washed three times with 0.01 M PBS followed by washing three times in distilled water (5–10 min each time) and immersing in increasing concentrations of ethanol (steps: 25% EtOH for 5 min; 50% EtOH for 10 min; 70% EtOH for 10 min; 96% EtOH for 10 min and 100% EtOH for 10 min, three times) and then brought to the critical point of drying under air flow. A sputter coat of a thin layer of Au on top of the samples was added prior to SEM. Samples were visualized with a MIRA3 scanning electron microscope (TESCAN, Brno, Czech Republic).
Presence and survival rate of SGNs
Given that the geometry of surface pillars exerts influence on in vitro grown neuronal cultures27, the presence and survival rates of SGNs on CMOS were analyzed across three types of areas depending on micro-pillar widths: the narrow pillar CMOS group (“Narrow”) contains neurons grown in areas with narrow pillars (1.4–2.4 µm), the wide pillar CMOS group (“Wide”) have neurons grown in areas with wide pillars (2.8–4.8 µm) whereas the flat CMOS group (“Flat”) contains neurons grown in areas of CMOS with no pillars. The number of SGNs for each experiment was calculated for each CMOS group and then the SGN presence on glass coverslips and CMOS chips was assessed and compared between different CMOS groups and a control. To quantify the total neuronal cell number, Tuj+ cells were counted under the microscope on each sample and the numbers were converted into cell densities representing the relative number of cells per mm2 with areas normalized by sample surface areas (8 mm2 for each area of a CMOS chip with micro-pillars, 132 mm2 for a control glass coverslip and 48 mm2 for the flat surface of the CMOS chip). The survival rate was calculated as previously described10,13 using the ratio of glial cells/neurons and the number of SGN/sample and is given as a percentage of the initial number of seeded cells per experiment which was set as 100%.
Morphometric analysis of SGN
To describe the effect of the CMOS chip on SGN morphology, we carried out the analysis with ImageJ software (version 1.49, NIH, Bethesda, US). We focused on the following parameters: the neurite length and interaction with glial cells, the number of sprouting and neuronal alignment, each described in following sections.
Neurite length and interaction with glial cells
A large network of axons and dendrites of spiral ganglion neurons are non-specifically referred to as neurites when grown in culture1,10,13,14,40. The average neurite length was described as a function of time (1 DIV, 4 DIV and 7 DIV), and as a function of different CMOS chip areas (Narrow, Wide or Flat). Neuronal cultures seeded and grown on glass coverslips represented a control. Neurites of every SGN were taken into account and their length was measured by submitting fluorescent images into ImageJ and analyzed with a Simple neurite tracer plugin (Longair MH, Baker DA, Armstrong JD. Simple Neurite Tracer: Open Source software for reconstruction, visualization and analysis of neuronal processes. Bioinformatics 2011). The values were then represented in graphs with standard deviation bars. In addition, we assessed the interaction between SGNs with S100+ (glial) cells by direct overlapping or contact, both on CMOS chips and in control samples, as a function of time (1 DIV, 4 DIV and 7 DIV). We defined two categories: SGNs having neurites in overlap/contact with S100+ glial cells and SGN neurites not touching S100+ glial cells. The S100+ /SGN ratio and the number of neurites of SGNs in contact with S100+ glial cells were counted manually in fluorescent, double stained images.
SGN sprouting and morphology
The sprouting number and its relation to neuronal morphology was determined on CMOS chips, as well as on the control glass coverslips as a function of time (1 DIV, 4 DIV and 7 DIV). The morphological features were analyzed in accordance with previous work13,14,40. The number of neurites was scored visually in images for each Tuj+ cells to determine whereas neurons were neurite-free, mono-, bi-, multi- or pseudo-unipolar. We did not count cells that were not clearly identified or were in clumps. The percentages of different morphologies were calculated from the total number of counted neurons.
SGN alignment on control glass coverslips and CMOS chips was quantified using the ImageJ Fast Fourier Transform (FFT) Oval Profile plugin (authored by Bill O’Connell, https://imagej.nih.gov/ij/plugins/oval-profile.html), as previously described27,43,44,45. Briefly, 8-bit grayscale images of Tuj+ cells with a radial feather mask were created in Adobe Photoshop CS6 software (Adobe Systems Incorporated, San Jose, US), then processed with the FFT function of the ImageJ software. The directionality of the objects in the resulting images depends on the intensity and distribution of the pixels. The Oval profile plugin performed the sum of the pixel intensities for 360 radii around the center of the FFT image. A straight line from the center to the edge of the FFT image (at angle θ) quantifies the objects oriented in that direction. The directionality of the original image is represented in plots of the sum of pixel intensities along angle θ. Images with no alignment showed constant pixel intensities across all angles, while peaks along one specific direction represented an image with pixels preferentially aligned in that direction43,44,45. The values (pixel intensities) from the analyses of the orientation of each neuron were averaged between neurons and plotted in the figure between 0° and 180°, because the FFT decomposition is symmetrical around the horizontal axis and pixel summation between 180° and 360° is unnecessary.
Analysis of neurite width asymmetry
In each CMOS sample, we identified neurons with bipolar morphology to be analyzed for neurite width asymmetry with the following procedure: first, we submitted SEM images consisting of neurons with clear bipolar morphology into ImageJ. Then, the diameter of the soma was estimated for each identified bipolar neuron. Finally, the width of each neurite (“central” and “peripheral”) emanating from the soma was measured from the soma center at distance corresponding to three times the diameter of the soma. This procedure was repeated for every bipolar SGN identified.
Electrical stimulation set-up and live Fluo-4-AM calcium imaging
The electrical stimulation set-up consisted of a custom printed circuit board connecting PC and the CMOS electrode array. Electrical connections of the chip were sealed with a biocompatible epoxy glue (Epotek 353ND, Epoxy Technology, Inc., Billerica, Massachusetts, US). Stimulation train pulse protocols were made in the Clampex software (version 10, Molecular Devices, LLC, San Jose, California, US) and consisted of short biphasic voltage pulses32, each with duration of 10 µs and voltage of 1.45 V. Cells were loaded with the calcium dye Fluo-4 AM (Invitrogen, Belgium) to be able to monitor the changes in the intracellular calcium concentration ([Ca2+]i) when cells responded to electrical stimulation. The fluorescent marker Fluo-4 AM (Invitrogen, Belgium) was brought in the cells by ester loading. The final bath concentration was 5 µg/ml. The accurate position of potentially responsive SGN cells was identified by visual inspection and we chose the electrode touching either soma or neurite of the neuron for delivery of stimulus pulse trains consisting of 10 biphasic pulses. Relative fluorescent changes in the intracellular calcium concentration ([Ca2+]i) were measured using 494 nm excitation and 516 nm emission filters of an upright Examiner microscope (Carl Zeiss, Belgium) equipped with a Hamamatsu cooled CCD camera. The fluorescent changes were measured as ΔF/Fbase, the change in fluorescence intensity relative to the baseline fluorescence intensity (Fbase) prior to each stimulation pulse train.
Data were transferred to spreadsheets and analyzed with MedCalc (version 15.2, MedCalc Software, Ostend, Belgium) and Sigmaplot (version 12.5, Systat Software, Inc., San Jose, US). The Shapiro-Wilk test, used to test the normality of the distribution of data, confirmed a parametric distribution. For the comparison of two groups we used the Student’s t-test. Multiple comparison analysis was done using one-way ANOVA, followed by a Tukey post-hoc test. Data are shown as mean ± standard deviation (SD). We considered P value of less than 0.05 as significant. Significance was labeled as not significant, ns, (P > 0.05); *, +, # (P < 0.05); **, ++, ## (P < 0.01) and ***, +++, ### (P < 0.001). Label M in the text refers to the number of experiments, label N to the number of samples used in each experiment and label n to the number of neurons analyzed. An experiment represents one 24-well plate with all samples and one sample is one glass coverslip or CMOS chip with cells.
CMOS chip is a favorable environment for the growth of neonatal and adult SGNs
Figures 2 and 3 show an overview of the SGNs of neonatal rat pups and adult guinea pig cell cultures, respectively, on a) glass coverslips and b) a CMOS chip. Visual examination shows that neurons and non-neural cells are present both in the control and on CMOS chips with neurons growing neurites in both conditions (CMOS and control). Figure 2c shows significant differences in the average neuronal density of neonatal SGN between CMOS and control substrates. Neonatal SGN cultures on CMOS chip micro-patterned surfaces were 3-fold more dense than on control substrates (4.8 vs. 1.6 per mm2 respectively, Student’s t-test, P < 0.001, M = 3, N = 18 for Narrow and Wide CMOS groups. In addition, micro-patterned surfaces of CMOS chip also yielded a significantly higher density of neonatal SGNs compared to the flat zones of CMOS areas (5.1 vs. 3.2 per mm2, one-way ANOVA, Tukey post-hoc test, P < 0.001, M = 3, N = 18). Figure 2d shows significant differences (one-way ANOVA, Tukey post-hoc test; P < 0.001) in the survival rates between neonatal SGN grown on the different areas of the CMOS chip (Narrow, Wide and Flat) and the control glass surfaces. Survival rates of SGNs grown on the Flat surfaces of the chip and glass coverslips were similar (9.8 ± 3.4% for control vs. 11.5 ± 5.4% for Flat areas after 4 DIV) and were significantly lower, almost halved, compared to SGNs grown on the Narrow and Wide areas of the chip (22.8 ± 6.1% for Narrow areas and 19.7 ± 6.9% for Wide areas after 4 DIV). At 7 DIV, both the control and the CMOS chips yielded somewhat lower survival rates compared to 4 DIV, with the Narrow and Wide areas of the CMOS showing a smaller decrease compared to control (one-way ANOVA, Tukey post-hoc test, P < 0.05).
Figure 3a,b show an overview of the adult SGN cell culture on (a) glass coverslips and (b) CMOS chip. Figure 3c shows significant differences in the average densities of adult SGNs grown on CMOS substrates compared to control condition (one-way ANOVA, Tukey post-hoc test, P < 0.001). Adult SGN cultures on micro-patterned surfaces of the CMOS chip were about 2.4-fold more dense than cultures on glass coverslips (2.9 vs. 1.2 per mm2 respectively). Areas with wide pillars seem to additionally enhance SGN growth as maximal cell densities were obtained in these areas (Wide vs. Narrow areas, Student’s t-test, P < 0.01, M = 3, N = 18). We also observed differences in the neuronal density between flat areas of CMOS chips (Flat area) and micro-patterned surfaces (Narrow and Wide Zones grouped together) with Flat areas having a significantly lower density of adult SGN (2.5 vs. 1.7 per mm2, one-way ANOVA, Tukey post-hoc test, P < 0.001, Fig. 3c). Importantly, the control and flat areas of the CMOS chip were similar in terms of neuronal density for both neonatal and adult SGN (Figs 2c and 3c). The control group yielded survival rates of 1.4 ± 0.6% after 1 DIV, 1.4 ± 0.5% after 4 DIV and 1 ± 0.4% after 7 DIV and were comparable with the survival rates of adult guinea pig SGN growing on the flat areas of the chip (1.8 ± 0.56% after 1 DIV; 2 ± 0.74% after 4 DIV and 1.5 ± 0.23% after 7 DIV). Both were significantly lower from survival rates of SGN growing on the narrow and wide areas of the chip (5.4 ± 1.2% after 1 DIV, 5.8 ± 0.78% after 4 DIV and 4.9 ± 0.98% after 7 DIV for Narrow, one-way ANOVA, Tukey post-hoc test; P < 0.001, and 7.1 ± 2.3% after 1 DIV, 7.9 ± 1.7% after 4 DIV and 6.8 ± 1.6% after 7 DIV for Wide, one-way ANOVA, Tukey post-hoc test; P < 0.001; Fig. 3d). As for neonatal SGNs, the survival rates of adult SGN were decreased over time, and such a decrease was significantly lower on CMOS micro-patterned surface (Narrow and Wide) compared to the control (one-way ANOVA, Tukey post-hoc test, P < 0.05). When comparing neuronal densities across species, we found a significantly higher average density of neonatal SGNs compared to adult neurons (4.8 vs. 2.1 per mm2 respectively).
CMOS substrates induce more bipolar and multipolar SGN morphology
The number of neurites sprouting from the SGN soma, producing neurite-free, pseudo-unipolar, monopolar, bipolar and multipolar morphologies determined the morphological shape of the SGN. As we did not observe any significant differences between Narrow, Wide and Flat areas of the CMOS chip regarding morphology, further referred to comparisons were between the control and the CMOS chip. Figure 4 shows the percentages of SGN neurons morphologically analyzed across time (columns), species (neonatal SGNs in upper panel, and the adult SGNs in the lower panel) and the area type (white bars for control and black bars for CMOS chips). Overall, bipolar neurons were the most abundant type for neonatal SGNs at all DIVs, as well as in the adults after 4 DIV. At 7 DIV, bipolar neurons were the most abundant type of neurons both in the CMOS and control conditions. Further analyses, detailed below, are performed depending on the polarity of the cells, separately for neonatal and adult neurons. First, neonatal neurite-free neurons were exceedingly more abundant in the control compared to CMOS (35.6 ± 15.9% and 0.1 ± 0.1% at 1 DIV respectively, Student’s t-test, P < 0.001; Fig. 4a). After 4 DIV and 7 DIV, there were no neurite-free neurons on CMOS. On the control coverslips, the number of neurite-free neurons decreased to 4.5 ± 2.9% after 4 DIV and to 3.8 ± 3.1% after 7 DIV. Second, in the neonatal monopolar morphology, a dramatic effect of the CMOS was observed: after only 1 DIV, the CMOS chip produced just a few neonatal SGN neurons with a monopolar morphology (1.2 ± 0.8%) representing only 1/32 fraction of the value in the control condition (38.7 ± 15.1%), with similar findings at 4 DIV (1.4 ± 0.6% on CMOS and 40 ± 19.8% on controls). After 7 DIV, percentages of monopolar neurons in the control condition was reduced by 7 times (5.8 ± 4.0%) compared to 4 DIV (40.0 ± 19.8%), and is as approximately 7 times more abundant with respect to the CMOS (0.8 ± 0.47%). Third, the CMOS seems to have a strong opposite effect on neonatal bipolar morphology: at 1 DIV, CMOS produced 2.5 times more neonatal SGN (64.6 ± 13.6%) with respect to the control (25.6 ± 12%, Fig. 4a–c). After 4 DIV, the percentages of bipolar neurons increased in the control (47 ± 19.1%) and slightly decreased on the CMOS (58 ± 13.4%), probably because the neurons developed other neurite(s) that transformed into multipolar type. Fourth, in contrast to mono- and bi- polar conditions, there were no multipolar neurons present in the control condition after 1 DIV, while the CMOS produced a high number of multipolar neurons (32.4 ± 13.3%). At 4 DIV, the percentage of neonatal multipolar SGN was still much higher on the CMOS (40.7 ± 14.9%), five times the number in the control condition (8.1 ± 3.6%, Fig. 4a–c). However, with increasing DIVs, the percentages of multipolar SGNs increased particularly on control surfaces (23.6 ± 9.4% after 7 DIV), while multipolar population on the CMOS remained fairly stable (45.4 ± 18.9% after 7 DIV).
Regarding the morphology of SGNs in adult guinea pigs, neurite-free neurons were more abundant on control surfaces compared to the CMOS (86.6 ± 4.6% vs. 48.8 ± 10% after 1 DIV, 23.2 ± 5.6% vs. 4.9 ± 1.3% after 4 DIV and 14.8 ± 9.6% vs. 4.8 ± 2.3%, after 7 DIV, Fig. 4d–f). There were no differences in the number of monopolar neurons at all DIVs between the control group and the CMOS (Fig. 4d–f). Similar to the neonatal group, bipolar morphology on the CMOS was significantly more abundant with respect to the control group at all DIVs except 7 DIV: 35.1 ± 13.9% after 1 DIV, 70.5 ± 12.7% after 4 DIV and 52.5 ± 8.7% after 7 DIV compared to control with 5.2 ± 1.8% after 1 DIV, 54.2 ± 14.8 after 4 DIV and 53.9 ± 15.2% after 7 DIV. Similar to the neonatal neurons, no multipolar adult neurons after 1 DIV on control glass coverslips were observed, while on CMOS chips, 15.3 ± 4.2% of the adult SGN were of the multipolar type. At 4 DIV, the percentages of multipolar neurons on CMOS and control surfaces were similar (Fig. 4d–f), with 7 DIV again showing more multipolar neurons on CMOS compared to the control. These results suggest that CMOS environment dramatically influenced neuronal morphology, strongly favoring bipolar and multipolar morphology, and to a less extent monopolar morphology both in neonatal and adult spiral ganglion neurons.
CMOS micro-patterned surfaces induces elongation of a neurite and decrease neurite-glial cells interaction in neonatal and adult SGN
Already after 1 DIV, the neurites of neonatal SGNs on the CMOS were 3.6 times longer compared to the control group (347.6 ± 115.5 µm vs. 95.6 ± 37 µm respectively, Student’ s t-test, P < 0.001, M = 3, N = 18, Fig. 5a). The axon length was measured only at 1 DIV and 4 DIV for neonatal neurons, however, over time, the neurites from neonatal SGNs were found intertwined between each other and it was difficult to identify neurites belonging to the same cell somas. Nevertheless, in both conditions (CMOS and the control group), the neurites were significantly longer with more days in vitro (one-way ANOVA, Tukey post-hoc test, P < 0.001, Fig. 5a) and the increase was larger for adult neurons. There were no significant differences in the neurite length between neurons growing on narrow and wide areas of the CMOS chip for both neonatal and adult SGNs. However, the neurite length of neonatal and adult SGNs that were grown on the flat surface of the CMOS chip was similar to those on control surfaces (476.1 ± 101 µm vs. 480 ± 86.2 µm after 4 DIV for neonatal SGN and 90.4 ± 19 µm vs. 74.1 ± 16.2 after 4 DIV for adult SGNs respectively, one-way ANOVA, Tukey post-hoc test, P > 0.05, Fig. 5a,b) and was significantly lower compared to the micro-patterned surfaces of the CMOS chip (one-way ANOVA, Tukey post-hoc test, P < 0.001, Fig. 5b). Neonatal neurons had longer axons compared to adult neurons (580.1 ± 136.2 µm vs. 127 ± 17.7 µm at 4 DIV respectively). Previous observations of SGNs in vitro cell cultures demonstrated that these neurons often grow their neurites in contact with the S100+ cells, indicating glial type of cell17,27,30, most probably Schwann and satellite cells15,27,46. For the neonatal SGNs, the ratio of glial cells/neurons was 2.3 ± 0.6 on the CMOS chips and 3.2 ± 0.9 for the control group after 4 DIV, 5.1 ± 1.2 (CMOS) vs. 8.6 ± 3.7 (control) after 7 DIV. For the adult SGNs, the ratio of glial cells/neurons was 2.6 ± 1.0 for the CMOS chips and 3.6 ± 1.3 for the control group after 4 DIV and 2.1 ± 0.7 (CMOS) vs. 2.9 ± 1.1 (control) after 7 DIV. Furthermore, we analyzed the interaction of a neurite from neonatal and adult SGNs with the S100+ cells after 1 DIV, 4 DIV and 7 DIV for CMOS and control surfaces (Fig. 5c,d). After 1 DIV, in the control group, 72.4 ± 13.2% of the neonatal SGN neurites and 37.6 ± 9.1% of the adult SGN neurites sprouting from the somas were in contact with the S100+ cells which was not significantly different from the micro-patterned surfaces of the CMOS chip where 57.6 ± 18.4% of the neonatal neurites and 24.1 ± 7.6% of the adult neurites were touching the glial cells. (One-way ANOVA, Tukey post-hoc test, P > 0.05). After 4 DIV, in the control group, 67.4 ± 14.6% of the neurites sprouting from the neonatal SGN soma were in contact with the glial cells, while on the micro-patterned surfaces of the CMOS chip this percentage was almost 3 times lower (22.9 ± 5.1% for Narrow Pillar areas and 26.7 ± 9.7% for Wide Pillar areas, one-way ANOVA, Tukey post-hoc test, P < 0.001). Adult SGNs growing on micro-patterned surfaces of the CMOS chip had 15.5 ± 4.6% (Narrow Pillar) and 14.1 ± 5.8% (Wide Pillar) neurites in contact with glial cells after 4 DIV, which was significantly lower compared to the control (43.4 ± 8.6%) and flat surface of the chip (34.1 ± 7.4%, one-way ANOVA, Tukey post-hoc test, P < 0.001). A similar outcome was also found after 7 DIV for adult SGNs, since neonatal neurons were difficult to analyze.
Specific CMOS topography elicits directional SGN neurite orientation and alignment
In order to determine how micro-pillars dimensions (width and spacing) of the CMOS chips influenced the neurite orientation and alignment, we stained and visualized neonatal and adult SGNs grown on CMOS chips and glass coverslips with Tuj+ (Fig. 6). The FFT Oval Profile analysis showed that the hexagonal topographical pattern of the pillars had a strong influence on the alignment and orientation of neurite outgrowth on CMOS micro-patterned surfaces (Fig. 6b). On specific micro-patterns, neurites were shown to be preferentially oriented and aligned along three directional axes, spaced by 60° angle intervals (30°; 90°; 150°), closely following angles within hexagon. On the other hand, the topographic guidance was rather reduced on glass coverslips (control) and flat areas of the chip (Fig. 6a,c), suggesting that only specific topographic structures of the CMOS substrates provide mechanical support and guidance for growth and differentiation of SGNs. Pillars width was shown not to have influence on neuronal alignment and orientation, since the effect of pillar widths was similar in narrow and wide areas of the CMOS substrates.
To visualize neurons growing on the CMOS areas with micro-patterned pillars, we obtained scanning electron images (SEM) of the spiral ganglion neurons after cultures were properly stained and prepared. Figure 7 shows the interaction of neurites with pillar structures and micro-electrodes. Neurites grew in straight lines on top and between pillars in mostly a single direction with occasional perpendicular branching. Neurites on pillars also formed a nerve growth cone which filopodia utilize as anchoring points for axon repositioning when on the CMOS pillar.
CMOS topography promotes growth of Type I and Type II of adult SGNs
Adult SGNs cultured on CMOS chips and glass coverslips were stained with rabbit polyclonal anti-peripherin to distinguish between Type I and Type II SGN. While there were no anti-peripherin positive neurons in the control condition, the CMOS substrates contained 3.3 ± 1.9% of neurons (n = 386, M = 3, N = 18) showing a strongly positive effect for anti-peripherin (Fig. 8b,c). The rest of SGNs were not strongly positive for anti-peripherin and were identified as Type I SGNs (Fig. 8a,c). The average diameter of somas from Type II SGNs was 11.4 ± 1.32 μm and was significantly smaller than the somas from Type I SGNs (23.6 ± 7.8 µm, Student’s t-test, P < 0.001). The average length of a neurite was 137.9 ± 26.9 μm and was also significantly shorter than the length of a neurite from Type I SGNs (200.3 ± 56.7 µm, Student’s t-test, P < 0.001). Type II SGNs can be bipolar or pseudounipolar38,39,47. In this study, mostly bipolar Type II SGNs appeared on the CMOS chip (Fig. 8b).
Micro-patterned surfaces of the CMOS chip represent a favorable environment for electrophysiological applications
The position of the micro-electrodes on the chip and spacing between pillars are parameters that affect electrophysiological measurements. Recordings of electrical activity and electrical stimulation on SGNs can presumably be performed if their soma lies directly on the top of a micro-electrode or if their neurites are in direct contact with a micro-electrode. Figure 9 shows that 28 ± 8.7% of the total neonatal SGNs growing on Narrow areas and 25.7 ± 6.3% of the total neonatal SGNs growing on Wide areas had their soma positioned on the top of a micro-electrode. Similarly, 23.9 ± 7.6% of the total adult SGNs growing on Wide pillars and 19.2 ± 7.1% of the total number of adult SGNs growing on Narrow areas had their soma positioned on the top of a micro-electrode. Comparing across species and CMOS areas, we found that only the Narrow areas of CMOS chips yielded a significantly higher number of neonatal SGNs with their soma residing on the top of the micro-electrode (Student’s t-test, P < 0.05, M = 3, N = 18). Similar findings were observed within all days in vitro for both, neonatal and adult SGNs. Expanding analyses with neurites going over the micro-electrode, we found that neonatal SGNs had 45.2 ± 9.2% of the total neurites growing on Narrow areas are in direct contact with a micro-electrode and 43.2 ± 8.5% of the total neurites have direct contact with a micro-electrode on Wide areas. Adult SGN had 32.7 ± 8.3% of the total neurites growing on Narrow areas being in direct contact with a micro-electrode and 36.7 ± 7.5% in the case of Wide pillars, which is significant smaller compared to the neonatal SGNs on narrow pillars (Student’s t-test, P < 0.05, M = 3, N = 18). Similar results were confirmed for all of the days in vitro (Fig. 9e,f). These results suggest that CMOS micro-patterned surfaces provide not only a favorable environment for the growth and alignment of neonatal and adult SGN, but can also enable effective electrophysiological stimulation and recording.
The CMOS electrode array enables electrical stimulation of the SGNs
We cultured spiral ganglion neurons for 6 DIV and 7 DIV on top of the CMOS electrode array chip to investigate the ability to electrically stimulate SGNs. Neurons were loaded with the calcium dye Fluo-4-AM to be able to monitor the changes in the intracellular calcium concentration ([Ca2+]i) of the SGNs close to the stimulation electrode. We selected a pair of electrodes that was located near or beneath the presumptive neuronal soma or neurite of the neuron and applied a train of biphasic pulses between electrodes. Stimulation pulses were applied through the electrodes while monitoring the changes in [Ca2+]i. Here we report calcium imaging responses in five spiral ganglion neurons stimulated with biphasic pulse trains (Fig. 10e). Strong increase in the relative [Ca2+]i initiated in neurons whose soma lies directly on the top of a micro-electrode or whose neurites are in a direct contact with a micro-electrode in response to electrical stimulation. Stimuli were trains of either 5 or 10 pulses, each with duration of 10 µs and stimulation voltages of 1.45 V. Figure 10a–d show calcium influx responses from a single spiral ganglion neuron 7 DIV, isolated from rat pup, with the soma positioned on top of the electrode which was stimulated with three biphasic voltage pulses, indicated with the asterisk. In Fig. 10a, we indicated three regions of interest (ROI 1, ROI 2 and ROI 3) along Fluo-4 calcium stained spiral ganglion neuron and noticed that the signal of calcium fluorescent changes spread from neuronal soma along both neurites (Fig. 10b,d - inset). The same neuron was then stained with both the neuronal marker Tuj and glial marker S-100. The stimulated cell was positive only to Tuj marker, indicating the cell was indeed a spiral ganglion neuron (Fig. 10c). The overall temporal dynamics of calcium imaging responses followed relatively similar time courses in all five observed neurons (Fig. 10e).
Neurite width asymmetry
The bipolar spiral ganglion soma has multiple morphological specializations, such as the proximity to surrounding nodes and the differential diameter of its central versus peripheral neurite processes. This neurite width asymmetry presumably counteracts “branch failures” which, if unchecked, would ultimately impede action potential conduction towards the central nervous system48. Thus, we analyzed neurite width asymmetry for each SGN with the bipolar morphology using SEM images providing clear neurite processes. Figure 11a demonstrates this phenomenon observed in the SEM image for neonatal SGNs cultured in vitro on the CMOS chip showing two opposite neurite processes with differential widths; the wider one presumably represents the central process and the thinner one indicates the peripheral process in accordance with the neuroanatomy of the SGNs39. Measuring neurite width asymmetry in all neonatal SGNs with a bipolar morphology available on SEM images, we found significantly wider widths of one neurite process compared to the opposite neurite process (Fig. 11b. the average width of thinner process (peripheral process) was 0.41 ± 0.24 µm and that of wider process was 0.85 ± 0.28 µm Student’s t-test, P < 0.001, M = 1, N = 5, n = 24.
Micro-patterned surfaces of the CMOS chip demonstrate feasibility for normal neuronal growth without coating
To assess the extent of the advantageous environment of the micro-patterned surfaces with embedded electrodes for neuronal growth, we looked at whether non-coating of the substrate surfaces would be detrimental to neural growth. Specifically, we cultured SGNs on the CMOS chips without the addition of any coating chemicals (i.e., poly-L-ornithine) which is usually required for in vitro cultures. In our case, we found similar SGN presence on the chips with and without coating only on micro-patterned areas of the chips containing pillars and micro-electrodes (Fig. 12a). On the other hand, neuronal density was significantly decreased on non-coated Flat areas of the chip compared to the same surface coated with poly-L-ornithine (3.2 ± 1.2% on coated Flat areas of the CMOS vs. 0.97 ± 0.44% on non-coated Flat areas of the CMOS, Student’s t-test, P < 0.001, M = 2, N = 12). Similar to neurons, the number of glial cells identified as S100 positive cells was also decreased on non-coated Flat areas of the CMOS chip. As for neurite length, we found that neurons express similar growth patterns on non-coated micro-patterned CMOS surfaces as on coated surfaces. No significant differences were found in neurite length for coated and non-coated CMOS micro-patterned surfaces (one-way ANOVA, Tukey post-hoc test, P > 0.05, M = 2, N = 12). However, there was a significant difference in neurite length between coated and non-coated Flat areas of the CMOS; neurites on non-coated flat surfaces of the CMOS chip were almost half the length (56.7 ± 19.2 µm) when compared to coated flat surfaces (123.3 ± 37.4) after 1 DIV and 2.5-fold shorter (189.4 ± 58.6 µm) after 4 DIV in comparison to coated flat surfaces (476.1 ± 101 µm). Neuronal alignment as well as interaction with glial cells and morphology were similar on non-coated substrates as for coated substrates described above. In striking contrast with the micro-patterned CMOS surfaces, neuronal attachment to control glass coverslips without coating was negligible, demonstrating the necessity for substrate coating. These results confirm that micro-patterned surfaces with embedded micro-electrodes of the CMOS chip represent a favorable environment for neuronal attachment and growth without coating chemicals.
Our results demonstrate that micro-patterned and high-density CMOS based electrode array represents an advantageous and favorable environment for in vitro SGN cultures by demonstrating stronger cell presence of the SGN, faster neurite sprouting with strong bipolar morphological polarity, reduced neuronal-glial interactions and with the ability to electrically stimulate the SGNs. More specifically, micro-patterned surfaces of the CMOS substrates promoted neuronal growth more effectively than glass coverslips and even flat areas of the chip containing no protruding pillars (Figs 2c and 3c). These effects were similar for neonatal and adult SGN cultures. Measurements of neurite lengths highlighted longer neurites, which also implies faster sprouting on CMOS chips compared to control for neonatal and adult SGNs (Fig. 5a,b). The study by Mattotti et al. with neonatal SGNs on passive silicon micro-patterned surfaces, albeit with no active CMOS component shows that neurons favor pillar spacing between 1.2 and 2.4 μm for improved growth and neurite elongation27. Our studies further extended these findings by showing differences in neuronal distribution between neonatal and adult SGNs cultured on CMOS chips with different pillar widths and pillar spacing between 0.8 and 1.6 µm. To the best of our knowledge, this is the first study where SGNs express normal growth also on non-coated micro-patterned CMOS surfaces, which can be useful in future clinical application due to the degradation of the coating chemicals over time and safety issues. Cultures on non-coated glass coverslips poorly attached, preventing neuronal growth on non-coated substrates. The flat surfaces of the non-coated chips showed poor neuronal growth, because the neurons could not firmly attach without pillar support. These findings demonstrate that micro-patterned surfaces consisting of protruding pillars and embedded micro-electrodes serve as an advantageous environment for neuronal attachment and growth. Neonatal SGNs have shown preferential growth in areas with both narrow and wide pillars, while adult SGNs seem to prefer to grow on wide pillars. This may be the consequence of either larger soma diameter or lower plating yield of adult SGNs making preference for wide pillars in adult SGNs. Similar observation was presented in Repić et al. study for adult dorsal root ganglion neurons. Our data indicate that neonatal and adult SGNs on CMOS chips had the highest survival rates, whereas control glass coverslips induced weaker cell survival (Figs 2d and 3d). The best survival rate was observed at 4 DIV, for both, neonatal and adult SGNs, showing neuronal viability peaking around that time. We surmise lower survival rates at 7 DIV are due to proliferation of non-neuronal cells, such as glial cells over time. This is consistent with previous studies in which fibroblasts and glial cells proliferate but neurons do not15,49,50. However, such a decrease was significantly weaker on micro-patterned surfaces of the CMOS chip. Compared with other studies reporting primary SGN cell cultures, we found our survival rates to be comparable and improved in some conditions. For instance, Jin et al.19 report a P5 SGN survival rate of 0.98% after 3 DIV, Vieira et al.13 describe the survival rate of adult SGNs from rats, mice or guinea pigs ranging between 1 and 6%, Mattotti et al.27 report a P5 SGN survival rate on MPS of 4.8% and Schwieger et al.10 describe P2-P4 SGN survival rate ranging from 3.57 to 40.69%, depending on the combination of different growth factors. Thus, the results in the present study confirm that micro-patterned CMOS substrates represent more supportive and permissive environment for neuronal growth and survival, compared to glass coverslips. Topographical cues strongly promote neuronal orientation and neurite guidance21,23,24,25,26,27 which are observed in SEM images (Fig. 7) and in polar plots of neural orientation showing neurite growth along 30°, 90° and 150° radial angles, compared to the control where there was no preferred orientation of the neurites (Fig. 6). SEM images highlight how SGNs develop their neurites in straight lines on top and between pillars (Fig. 7). Only areas with pillars and micro-electrodes favor neurite alignment along preferred angles. These findings strongly suggest that pillar width and spacing significantly influenced SGN neurite orientation and alignment that is crucial for structuring neurite connectivity. Pillars and micro-electrodes represent a strong and stable adhesion milieu where neurites are extended. It seems that the protruding shape and carefully crafted three-dimensional structureof pillars behave like geometrical constraints providing directional guidance. Closely spaced pillars and micro-electrodes stimulate neuronal growth by creating boosts at their contacts with neurons, compared to more separated pillars where signaling delay occurs. Other studies using silicon MPS28,29 demonstrated that neurites were found to “search” for a new nearby permissive cue (pillar) and attach to areas with the largest pillar spacing, whereby this process elicits a structural change. Our SEM images also showed the formation of nerve growth cones provided cells with a mechanical apparatus that guided neurite growth to mechanical, chemical and electrical cues51. On micro-patterned surfaces of the CMOS chips, filopodia of the growth cone used pillars or micro-elecrodes as an anchoring point from where neuronal growth may occur. The presence of particular structures of micro-pillars and micro-electrodes on CMOS chips also strongly influenced SGN morphology. The number of neurons with bipolar and multipolar morphologies grown on CMOS substrates was stable over time while the number of neurons with monopolar and other morphologies was significantly reduced compared to the control group. Mattotti et al. reported that neonatal SGNs developed more monopolar and bipolar morphologies, when they were cultured on MPSs, while there was a reduction in the number of neurons with multipolar morphologies and concluded that MPSs might be more beneficial to induce neuronal morphologies more similar to in vivo conditions27. Our study with neonatal and adult SGNs cultured on CMOS chips demonstrated that CMOS substrates encouraged neurons to develop more bipolar and multipolar morphologies. In vitro neurite-free, mono-, bi- and multi-polar morphologies were also observed in other studies10,13,14,27,40,52. Different sprouting behaviors can be related to neuronal polarization and neurite pathfinding28. The appearance of SGNs in vitro may vary between studies, depending on the species of origin, the age of the animals and the cell culture protocol27,40,52. Khalifa et al. reported a drastic increase of multipolar neurons from 5% on non-structured surfaces to 86–87% on surfaces with alternating lines53. They stated that controlled sprouting and branching can be an essential process in the sense that additional neurites contribute in augmenting the chances that neurites reach their targets53. We surmise that the micro-topography of CMOS chips probably utilizes similar stimulation mechanisms that could be integrated synergistically with biochemical support in the design of optimal electrode arrays. The comparison of our results with results of other studies is difficult because of different material, size, shape and uniformity of the CMOS chips as well as different techniques used for the analysis of the alignment and neuronal behavior and measurements. In vitro cultures of SGNs also comprise an important presence of non-neuronal cells, mostly glial cells, where the ratio to neurons can vary, for example from 1:1 to 20:14,13. However, our study suggests different ratios of glial cells/neurons. The ratio of glial cells/neurons of neonatal SGNs increased over time, from 2.3 ± 0.6 (4 DIV) to 5.1 ± 1.2 (7 DIV) on CMOS chips and from 3.2 ± 0.9 (4 DIV) to 8.6 ± 3.7 (7 DIV) on control glass coverslips, due to glial cell proliferation. On the other hand, the opposite effect was found for adult neurons, since ratio of glial cells/neurons decreased over time, from 2.6 ± 1.0 to 2.1 ± 0.7 (4 DIV) on CMOS chips and from 3.6 ± 1.3 to 2.9 ± 1.1 (7 DIV) on control glass coverslips. This might be related to the age of animals and animal species, since other studies13,14,49,50,54 reported that the density of non-neuronal cells decreased with increasing age of the animal which can explain why dissociated SGN cultures of mature animals could be maintained for several weeks. The proliferation of glial cells was slower on micro-patterned surfaces of the CMOS chip in both, neonatal and adult SGN cultures, shown by lower ratios of glial cells/neurons, which increase the survival rate of neurons on these areas. Schwann and satellite cells are the most commonly SGN-associated cells in the spiral ganglion or spiral lamina, and they are immune-reactive for the marker S10015,46. These types of glial cells play an important role in neuronal growth, survival, regeneration and axonal guidance in vivo and in vitro15,20,27,53. It has been shown that SGNs in culture prefer to grow in proximity to glial cells, due to the adhesive molecular patterns like Laminin-1, that these cells secrete15,20,27. Our data show that neurites of the neonatal and adult SGNs on CMOS substrates were encouraged to grow more in direct contact with micro-pillars and micro-electrodes rather than to seek interaction with glial cells that were present in their surroundings. In fact, SGNs (Figs 2b and 3b) intertwined their neurites exchanging information from the environment instead being in the contact with glial cells. Neonatal SGNs have shown a tendency towards highly patterned neuronal networks promoting connections between neurites while discouraging contacts with glial cells. Previous studies by several groups18,21,22,27,28 demonstrated cytoskeletal alterations and upstream signaling related to neurons interacting with pillars and grooves indicating consistency with our findings. This suggests that topographic cues presented with micro-pillars on CMOS chips support direct neurite guidance without the mediating action of glial cells, creating an advantageous environment for neuronal growth and neurite sprouting. The mature mammalian cochlea exhibits segregated innervation of its two populations of sensory hair cells: inner hair cells (IHC) and outer hair cells (OHC), by the SGNs39,51. Type I SGNs comprise 90 to 95% of the SGN population and extend single, unbranched, myelinated neurites to innervate a single inner hair cell (IHC)39,51. The IHCs with Type I SGN innervation are responsible for the signal transduction of sound stimuli to be delivered up-stream along the auditory pathway39,51. The remaining 5 to 10% of SGN are Type II neurons with thin, unmyelinated fibers innervating numerous outer hair cells (OHCs)39,51. Adult SGNs cultured on glass coverslips and CMOS chips were stained with Tuj and peripherin to distinguish between Type I and Type II of SGNs. Peripherin positive (appeared in green)39 neurons were identified as Type II SGNs (Fig. 8). Only SGNs isolated from adult guinea pigs were stained with peripherin antibody because neonatal Type II SGNs occurred between 6 to 8 DIV and at that time-point it was impossible to distinguish between two neuronal types as observed morphological differences develop only later40,42. Consequently, rat pups are an inappropriate model to investigate the appearance of Type II SGNs. The presence of Type II SGNs on CMOS chips indicates the ability of the micro-structured surfaces to promote the natural appearances of both types of SGNs that are important for natural cochlear innervation. Spiral ganglion neurons have unusual morphological configuration in which electrogenic soma reside directly in the signal transduction pathway representing internodal axonal structure that serves for transmitting, integrating and conducting signals48. The position of the micro-electrodes within the CMOS chip is certainly an important aspect for electrophysiological recordings. The electrical activity of the SGNs can presumably be recorded if an electrogenic soma is positioned directly on the top of a micro-electrode or the neurite spans the micro-electrode ensuring neuron-electrode proximity. In this study, considering the extremely demanding and sensitive in vitro conditions for peripheral sensory neurons, we showed that there is a satisfactory number of SGNs either with soma placement directly on the top of a micro-electrode or a neurite spanning a micro-electrode, or both, which represent realistic requirements for electrophysiological applications. These findings were confirmed with live calcium imaging experiments of SGN cultures which were electrically stimulated with the CMOS electrode array. We observed that neurons with either soma positioned directly on the top of a micro-electrode or the neurite contacting the micro-electrode have shown a strong increase in the [Ca2+]i after being stimulated with biphasic pulse trains. The fast increase in the [Ca2+]i could be caused by two mechanisms: opening of voltage-gated Ca2+ channels causing influx of extracellular Ca2+ during stimulation and formation of pores along the membrane allowing extracellular Ca2+ to flow inside the cell. One of the first studies that utilize MEAs for assessing electrophysiological characteristics of SGNs in vitro was from Hahnewald et al.9. They used SGN explants and a MEA containing 68 platinum electrodes with a dimension of 40 × 40 µm and an inter-electrode distance of 200 µm and showed that the stimulation and recording of auditory neuronal activity from SGN explants using MEA is feasible. In our study we presented MEA with a much higher number of integrated microelectrodes that enables successful electrical stimulation of dissociated SGN cultures. We showed that the pillars of CMOS electrode array maintain a stable environment for SGNs cultured in vitro, while microelectrodes enable electrophysiological stimulation of each individual neuron. A smaller inter-electrode distance of the CMOS electrode array encourages a closer contact between auditory neurons and electrodes that can result in lower stimulation thresholds. Based on the position of the soma relative to the central process (usually referred to as the axon) and the peripheral process (usually referred to as the dendrite), neurite width asymmetry between these two processes in bipolar neurons can be observed in Type I SGN39. This asymmetry is shown in SEM images (Fig. 11) and was statistically quantified. Overall, these findings suggest micro-patterned and high-density complementary metal–oxide–semiconductor electrode array as a promising model of a neuro-electronic interface which supports neuronal growth, alignment, orientation of in vitro cultured spiral ganglion neurons and which has an ability to electrically stimulate neurons. We assume that electrical cues of micro-patterned and high-density CMOS electrode array would enable growth stimulation of regenerating neurites of spiral ganglion neurons attracting them toward electrodes. Future in vitro and in vivo studies will be necessary to elucidate the electrophysiological properties of auditory neurons interfaced with types of micro-patterned and high-density CMOS electrode arrays.
Euteneuer, S. et al. Glial cell line-derived neurotrophic factor (GDNF) induces neuritogenesis in the cochlear spiral ganglion via neural cell adhesion molecule (NCAM). Mol Cell Neurosci 54, 30–43, https://doi.org/10.1016/j.mcn.2012.12.004 (2013).
Kaiser, O. G. et al. TGF-beta superfamily member activin A acts with BDNF and erythropoietin to improve survival of spiral ganglion neurons in vitro. Neuropharmacology 75, 416–425, https://doi.org/10.1016/j.neuropharm.2013.08.008 (2013).
Shepherd, R. K. & Hardie, N. A. Deafness-induced changes in the auditory pathway: implications for cochlear implants. Audiol Neurootol 6, 305–318 (2001).
Rask-Andersen, H. et al. Human cochlea: anatomical characteristics and their relevance for cochlear implantation. Anat Rec (Hoboken) 295, 1791–1811, https://doi.org/10.1002/ar.22599 (2012).
Wilson, B. S. & Dorman, M. F. Cochlear implants: a remarkable past and a brilliant future. Hearing Research 242, 3–21, https://doi.org/10.1016/j.heares.2008.06.005 (2008).
Zeng, F. G., Rebscher, S., Harrison, W., Sun, X. & Feng, H. Cochlear implants: system design, integration and evaluation. IEEE Rev Biomed Eng 1, 115–142 (2008).
Blamey, P. et al. The development of speech production following cochlear implantation. Clinical Linguistics and Phonetics. 15, 363–82 (2001).
O’Leary, S. J., Richardson, R. R. & McDermott, H. J. Principles of design and biological approaches for improving the selectivity of cochlear implant electrodes. Journal of Neural Engineering 6, 1741–1752, https://doi.org/10.1088/1741-2560/6/5/055002 (2009).
Hahnewald, S. et al. Response profiles of murine spiral ganglion neurons on multi-electrode arrays. Journal of Neural Engineering 13, 1–14, https://doi.org/10.1088/1741-2560/13/1/016011 (2016).
Schwieger, J., Warnecke, A., Lenarz, T., Esser, K. H. & Scheper, V. Neuronal Survival, Morphology and Outgrowth of Spiral Ganglion Neurons Using a Defined Growth Factor Combination. PLoS One 10, e0133680, https://doi.org/10.1371/journal.pone.0133680 (2015).
Shibata, S. B., Budenz, C. L., Bowling, S. A., Pfingst, B. E. & Raphael, Y. Nerve maintenance and regeneration in the damaged cochlea. Hearing Research 281, 56–64, https://doi.org/10.1016/j.heares.2011.04.019 (2011).
Tong, M., Brugeaud, A. & Edge, A. S. Regenerated synapses between postnatal hair cells and auditory neurons. J Assoc Res Otolaryngol 14, 321–329, https://doi.org/10.1007/s10162-013-0374-3 (2013).
Vieira, M., Christensen, B. L., Wheeler, B. S., Feng, A. S. & Kollmar, R. Survival and stimulation of neurite outgrowth in a serum-free culture of spiral ganglion neurons from adult mice. Hearing Research 230, 17–23 (2007).
Whitlon, D. S. et al. Survival and morphology of auditory neurons in dissociated cultures of newborn mouse spiral ganglion. Neuroscience 138, 653–662 (2006).
Whitlon, D. S., Tieu, D., Grover, M., Reilly, B. & Coulson, M. T. Spontaneous association of glial cells with regrowing neurites in mixed cultures of dissociated spiral ganglia. Neuroscience 161, 227–235, https://doi.org/10.1016/j.neuroscience.2009.03.044 (2009).
Whitlon, D. S. et al. Novel High Content Screen Detects Compounds That Promote Neurite Regeneration From Cochlear Spiral Ganglion Neurons. Sci. Rep. 5, 15960, https://doi.org/10.1038/srep15960 (2015).
Boström, M. et al. Effects of neurotrophic factors on growth and glial cell alignment of cultured adult spiral ganglion cells. Audiololgy & Neurootology 15, 175–86, https://doi.org/10.1159/000XXXXXX (2010).
Bruder, J. M., Lee, A. P. & Hoffman-Kim, D. Biomimetic materials replicating Schwann cell topography enhance neuronal adhesion and neurite alignment in vitro. Journal of Biomater Sci Polym Ed. 18, 967–982 (2007).
Jin, Y. et al. Developmental changes in the responsiveness of rat spiral ganglion neurons to neurotrophic factors in dissociated culture: differential responses for survival, neuritogenesis and neuronal morphology. Cell Tissue Research 351, 15–27, https://doi.org/10.1007/s00441-012-1526-1. (2013).
Clarke, J. C. B. W. et al. Micropatterned methacrylate polymers direct spiral ganglion neurite and Schwann cell growth. Hearing Research 278, 96–105, https://doi.org/10.1016/j.heares.2011.05.004 (2011).
Dowell-Mesfin, N. M. et al. Topographically modified surfaces affect orientation and growth of hippocampal neurons. Journal of Neural Engineering 1, 78–90, https://doi.org/10.1088/1741-2560/1/2/003 (2004).
Ferrari, A. et al. Neuronal polarity selection by topography-induced focal adhesion control. Biomaterials 31, 4682–4694, https://doi.org/10.1016/j.biomaterials.2010.02.032 (2010).
Fozdar, D. Y., Lee, J. Y., Schmidt, C. E. & Chen, S. Hippocampal neurons respond uniquely to topographies of various sizes and shapes. Biofabrication 2, 1–19, https://doi.org/10.1088/1758-5082/2/3/035005 (2010).
Gomez, N., Chen, S. & Schmidt, C. E. Polarization of hippocampal neurons with competitive surface stimuli: contact guidance cues are preferred over chemical ligands. J R Soc Interface 4, 223–233 (2007).
Hoffman-Kim, D., Mitchel, J. A. & Bellamkonda, R. V. Topography, cell response, and nerve regeneration. Annual Reviews Biomed Engineering 12, 203–231, https://doi.org/10.1146/annurev-bioeng-070909-105351 (2010).
Kundu, A. et al. Superimposed topographic and chemical cues synergistically guide neurite outgrowth. Lab on a Chip 13, 3070–3081, https://doi.org/10.1039/c3lc50174d (2013).
Mattotti, M., Micholt, L., Braeken, D. & Kovačić, D. Characterization of spiral ganglion neurons cultured on silicon micro-pillar substrates for new auditory neuro-electronic interfaces. Journal of Neural Engineering 12, 1–12, https://doi.org/10.1088/1741-2560/12/2/026001 (2015).
Micholt, L. et al. Substrate topography determines neuronal polarization and growth in vitro. PLoS One 8, e66170, https://doi.org/10.1371/journal.pone.0066170 (2013).
Repić, T. et al. Characterization of dorsal root ganglion neurons cultured on silicon micro-pillar substrates. Sci. Rep. 6, 39560, https://doi.org/10.1038/srep39560 (2016).
Rak, K. et al. Growth behavior of cochlear nucleus neuronal cells on semiconductor substrates. J Biomed Mater Res A 97, 158–166, https://doi.org/10.1002/jbm.a.33042 (2011).
Braeken, D. et al. Local electrical stimulation of single adherent cells using three-dimensional electrode arrays with small interelectrode distances. Conf Proc IEEE Eng Med Biol Soc. 2009, 2756–9, https://doi.org/10.1109/IEMBS.2009.5333871 (2009).
Braeken, D. et al. Localized electrical stimulation of in vitro neurons using an array of sub-cellular sized electrodes. Biosens Bioelectron. 26, 1474–7, https://doi.org/10.1016/j.bios.2010.07.086 (2010).
Braeken, D. et al. Open-cell recording of action potentials using active electrode arrays. Lab on a Chip. 12, 4397–4402, https://doi.org/10.1039/c2lc40656j (2012).
Hierlemann, A., Frey, U., Hafizovic, S. & Heer, F. Growing cells atop microelectronic chips: Interfacing electrogenic cells in vitro with CMOS-based microelectrode array. Proceedings of the IEEE 99, 252–284, https://doi.org/10.1109/JPROC.2010.2066532 (2011).
Huys, R. et al. Single cell recording and stimulation with a 16k micro-nail electrode array integrated on a 0.18 µm CMOS chip. Lab on a chip 12, 1274–1280, https://doi.org/10.1039/c2lc21037a (2012).
Leake, P. A., Hradek, G. T. & Snyder, R. L. Chronic electrical stimulation by a cochlear implant promotes survival of spiral ganglion neurons after neonatal deafness. J. Comp. Neurol. 412, 543–562 (1999).
Leake, P. A., Stakhovskaya, O., Hetherington, A., Rebscher, S. J. & Bonham, B. Effects of brain-derived neurotrophic factor (BDNF) and electrical stimulation on survival and function of cochlear spiral ganglion neurons in deafened developing cats. J. Assoc. Res. Otolaryngol. 14, 187–211, https://doi.org/10.1007/s10162-013-0372-5 (2013).
Spoendlin, H. & Schrott, A. Quantitative evaluation of the human cochlear nerve. Acta Otolaryngol 470, 61–69 (1990).
Nayagam, B. A., Muniak, M. A. & Ryugo, D. K. The spiral ganglion: connecting the peripheral and central auditory systems. Hearing Research 278, 2–20, https://doi.org/10.1016/j.heares.2011.04.003 (2011).
Rusznák, Z. & Szucs, G. Spiral ganglion neurones: an overview of morphology, firing behaviour, ionic channels and function. Pflugers Arch. 457, 1303–1325, https://doi.org/10.1007/s00424-008-0586-2 (2009).
Hafidi, A. Peripherin-like immunoreactivity in type II spiral ganglion cell body and projections. Brain Research 805, 181–190 (1998).
Romand, R. & Romand, M. R. Qualitative and quantitative observations of spiral ganglion development in the rat. Hearing Research 1, 111–20 (1985).
Alexander, J. K., Fuss, B. & Colello, R. J. Electric field-induced astrocyte alignment directs neurite outgrowth. Neuron & Glia Biology 2, 93–103, https://doi.org/10.1017/S1740925X0600010X (2006).
Ayres, C. E. et al. Measuring fiber alignment in electrospun scaffolds: a user’s guide to the 2D fast Fourier transform approach. Journal of biomaterials science. Polymer edition 19, 603–621, https://doi.org/10.1163/156856208784089643 (2008).
Taylor, S. A., Cao, T., Talauliker, P. M. & Lifshitz, J. In Current Protocols Essential Laboratory Techniques (eds Gallagher, S. R. & Wiley, E. A.) (Wiley, 2012).
Liu, W., Boström, M., Kinnefors, A., Linthicum, F. & Rask-Andersen, H. Expression of myelin basic protein in the human auditory nerve - an immunohistochemical and comparative study. Auris Nasus Larynx 39, 18–24, https://doi.org/10.1016/j.anl.2011.04.007 (2012).
Coate, T. M. & Kelley, M. W. Making connections in the inner ear: Recent insights into the development of spiral ganglion neurons and their connectivity with sensory hair cells. Seminars in Cell & Develomental Biology 24, 460–469, https://doi.org/10.1016/j.semcdb.2013.04.003 (2013).
Dabdoub, A. The primary auditory neurons of the mammalian cochlea (ed. Dabdoub, A., Fritzsch, B., Popper, A. N., Fay, R. R.) 1–286 (New York, 2016).
Scwieger, J., Esser, K. H., Lenarz, T. & Scheper, V. Establishment of a long term spiral ganglion neuron culture with reduced glial cell number: Effects of AraC on cell composition and neurons. Journal of Neuroscience Methods 268, 106–116, https://doi.org/10.1016/j.jneumeth.2016.05.001 (2016).
Boström, M. et al. Neural network and ganglion formations in vitro. Otol. Neurotol. 28, 1109–1119 (2007).
Anderson, M. et al. Structure and locomotion of adult in vitro regenerated spiral ganglion growth cones-A study using video microscopy and SEM. Hearing research 215, 97–107, https://doi.org/10.1016/j.heares.2006.03.014 (2006).
Whitlon, D. S., Grover, M., Tristano, J., Williams, T. & Coulson, M. T. Culture conditions determine the prevalence of bipolar and monopolar neurons in cultures of dissociated spiral ganglion. Neuroscience 146, 833–840 (2007).
Khalifa, S. A. M., Björk, P., Vieider, C., Ulfendahl, M. & Scarfone, E. Neuronal polarity mediated by micro-scale protein patterns and Schwann cells in vitro. Tissue Engineering & Regenerative Medicine 10, 266–272 (2013).
Rask-Andersen, H. et al. Regeneration of human auditory nerve. In vitro/in video demonstration of neural progenitor cells in adult human and guinea pig spiral ganglion. Hearing research 203, 180–191, https://doi.org/10.1016/j.heares.2004.12.005 (2005).
The research was financially supported by EU structural grants for Croatia (code: HR.3.2.01-0320, RC.2.2.08-0059 and STIM-REI KK.01.1.1.01.0003) and by Split-Dalmatia County. The doctoral student scholarship for VR was supported in part by the Foundation for Audiological Research (Gothenburg, Sweden). MM was supported with the postdoctoral position funded from the HAMAG-BICRO grant (PoC IV_10). We would like to thank Professor Ante Bilušić from the Faculty of Science in Split and Jasna Arapov and her co-workers from IZOR for the SEM microscopy assistance, Professor Damir Sapunar for technical support and advice, Jordi Cools for the SEM protocol, Jagoda Dujić for help from the animal facility, Shelly Pranić for manuscript proofreading and Marica Maretić for technical support.
The authors declare no competing interests.
Publisher's note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Radotić, V., Braeken, D., Drviš, P. et al. Advantageous environment of micro-patterned, high-density complementary metal–oxide–semiconductor electrode array for spiral ganglion neurons cultured in vitro. Sci Rep 8, 7446 (2018) doi:10.1038/s41598-018-25814-w