Macular edema due to neovascular age-related macular degeneration, diabetes or retinal vein occlusion can cause central vision loss. Intravitreal treatment with antibody-based biopharmaceutical compounds designed to neutralize vascular endothelial growth factor (VEGF) has proven to be an efficient strategy to ameliorate macular edema and restore visual acuity. At the same time, the use of anti-VEGF drugs places an economic burden on the health care system; the drugs are expensive, and repeated injections are usually required to maintain the therapeutic effect. Thus, there is an unmet need for more cost-effective procedures. We here describe how the most recently approved anti-VEGF drug, aflibercept, can be compounded into prefilled sterile syringes and stored for up to 4 weeks without compromising its quality, stability or functional properties, including VEGF and neonatal Fc receptor (FcRn) binding. The novel compounding method for repackaging of aflibercept in sterile plastic syringes can greatly reduce both cost and time spent per patient in the injection room.
Over the last decade, antibody-based biopharmaceutical compounds designed to target vascular endothelial growth factor (VEGF) have revolutionized treatment and prognosis for several retinal diseases, including wet age-related macular degeneration1,2, diabetic macular edema3 and macular edema secondary to retinal vein occlusion4. The three most commonly used anti-VEGF drugs are aflibercept (Eylea®, Bayer Healthcare), ranibizumab (Lucentis®, Genentech) and bevacizumab (Avastin®, Genentech). Aflibercept and ranibizumab are approved for ophthalmological use by national and multinational drug agencies, while bevacizumab is an off-label alternative whose efficacy and safety are well established through extensive clinical research5,6,7,8.
These costly drugs are administered as intravitreal injections, and regular retreatment is usually necessary to achieve and maintain therapeutic effect. Their introduction as the standard of care in several prevalent conditions has thus led to a greatly increased workload for ophthalmological clinics, and has placed a heavy economic burden on health care systems. Intravitreal injections also involve a risk of infectious endophthalmitis. The incidence of this rare but sight-threatening complication depends on the injection procedure used9,10. In this context, a standardized, quality-controlled, time- and cost- efficient injection practice is paramount, and any means of improving either efficiency or safety is invaluable.
Aflibercept is the anti-VEGF drug that was most recently approved for treatment of ocular diseases. It is a recombinant fragment crystallizable (Fc) fusion protein consisting of parts of the extracellular domains of human VEGF receptors 1 and 2 that are genetically fused to the Fc portion of human IgG1. Compared to other anti-VEGF drugs aflibercept has a higher binding affinity for VEGF11, longer intravitreal half-life12 as well as the capacity to antagonize growth factors other than VEGF12.
Compounded preparations of bevacizumab are commercially available in many countries; pharmacies split vials into injection-ready syringes that are sold to ophthalmological clinics. Although aflibercept is supplied in considerably smaller vial volumes than bevacizumab, a compounding procedure with splitting of each aflibercept vial into several syringes would have a large impact on treatment costs. In addition to reducing costs, the production of prefilled syringes in a pharmacy rather than in the injection room can potentially lower the risk of microbial contamination13. It will also be time-saving for the clinician14. However, compounding and storage of antibody-based drugs in plastic syringes diverges from the administration approved by manufacturers and drug authorities. Thus, any compounding procedure must be carefully controlled to guarantee its security and quality.
In this study, we describe a novel pharmacy compounding method for repackaging of aflibercept into sterile plastic syringes. A thorough investigation shows that aflibercept fully maintains its structural stability, VEGF and Fc binding properties after up to 28 days of storage.
To investigate whether aflibercept can be compounded and stored in sterile plastic syringes without affecting protein integrity or VEGF and Fc binding properties, commercially obtained aflibercept was drawn into insulin plastic syringes in an isolator unit and transfer chamber following aseptic production procedures. The prefilled syringes were stored at 4 °C in the dark for 0, 7 or 28 days (D0, D7 and D28). The aliquots were then immediately analyzed using an array of methods to measure the quality, stability and binding properties of aflibercept.
Protein quality and stability
We initially determined the concentration of aflibercept in the plastic syringes. Aflibercept was collected from the syringes and both undiluted and diluted (1:10) samples were measured using a DeNovix DS-11+ Spectrophotometer. There were no statistically significant differences in concentrations between samples collected at D0, D7 and D28 (Fig. 1A,B). Thus, the storage in syringes did not result in any loss of protein over 4 weeks.
We then analyzed the structural integrity of aflibercept by adding equal amounts on SDS-PAGE gels under non-reducing and reducing conditions (Fig. 2A–D). Under non-reducing conditions all fractions migrated as major bands corresponding to the aflibercept homodimer with a molecular weight of ~150 kDa. Under reducing conditions, where the disulfide bonds of the IgG1 Fc hinge region are disrupted, aflibercept migrated, as expected, as a major band of ~70 kDa. Notably, under reducing conditions we observed two additional minor bands with molecular weights of roughly 55–45 kDa. These bands were found for all storage durations including D0.
The aflibercept samples were also analyzed with size exclusion chromatography (SEC). All fractions showed identical elution profiles with a major peak (peak A) corresponding to homodimeric aflibercept. A minor peak (peak B) corresponding to a dimeric form of homodimeric aflibercept was also seen in all samples (D0, D7 and D28, Fig. 3A,C). Calculation of the area under the curve (AUC) showed no statistically significant differences between the D0, D7 (p = 0.805) and D28 samples (p = 0.280) (Fig. 3B,D, n = 6 for each comparison). Finally, thermal stability was measured for D0 and D28 samples by differential scanning fluorimetry (DSF). Again, no statistically significant differences were found, as all samples reached 50% unfolding (Tm value) at 62.9 °C (p = 0.874, Fig. 4).
Thus, storage of aflibercept in sterile prefilled syringes did not affect thermal stability or cause degradation or formation of covalent or non-covalent aggregates.
Antigen and Fc binding properties
Preserving the functional integrity of therapeutic antibodies during manufacture and storage represents a major challenge. Aflibercept has two inherent functional properties; it binds VEGF via VEGF receptor subunits fused to the N-terminal end of each of the Fc heavy chains, and to Fc receptors via constant Fc domains derived from human IgG1. One of the most important Fc receptors is the neonatal Fc receptor (FcRn), which is responsible for the 3-week serum half-life of IgG15,16. A finding relevant to storage stability is that oxidation of methionine residues on the Fc part of IgG1 causes reduced binding to FcRn, consequently shortening the serum half-life17,18. Presumably, this would also affect the dynamics of intravitreally administered drugs containing an Fc portion (aflibercept and bevacizumab), as FcRn has been shown to play a central role in removing intravitreally administered IgG via the blood-retinal barrier19.
To investigate how the aflibercept compounded and stored in syringes bound human VEGF, ELISA was performed; the plates were coated with constant amounts of VEGF before titrated amounts of aflibercept were added. Captured aflibercept was detected using a polyclonal anti-human IgG Fc antibody. The binding profiles obtained showed that the VEGF binding integrity was visually indistinguishable for D7 and D28 samples compared to D0 samples (Fig. 5A,B). Statistical analysis of values derived from the exponential phase of the curves showed no significant differences in VEGF binding capacity (D7: p = 0.386, D28: p = 0.287, Fig. 5C,D). This could also be shown using surface plasmon resonance (SPR) where VEGF was immobilized and equal amounts of aflibercept were injected. The resulting sensorgrams showed completely overlapping binding profiles (Fig. 6A,B), which confirmed that the VEGF binding properties were unaffected by storage.
To evaluate the functional integrity of the Fc part of aflibercept, binding to human FcRn was measured by ELISA. Since FcRn binds IgG in a strictly pH dependent manner, i.e. binding at acidic pH and no binding or release at pH 7.415,16, the assay was performed at both pH 7.4 and pH 6.0. Specifically, titrated amounts of aflibercept were captured on VEGF followed by adding of recombinant GST-tagged human FcRn and detection using an anti-GST antibody (Fig. 7A,B). The results showed that human FcRn bound aflibercept stored for 7 or 28 days equally well and in the same pH dependent manner as freshly drawn aflibercept (Fig. 7A,B), without statistically significant differences (Fig. 7C,D).
Thus, up to 28 days storage of alifbercept in prefilled syringes did not affect either of the two functional binding properties of aflibercept, neither binding to VEGF nor pH dependent binding to human FcRn.
The practice of pharmacy compounding of anti-VEGF antibody-based drugs essentially dates back to their introduction. Compounding has been most widespread for bevacizumab, and a large body of research exists demonstrating functional stability of bevacizumab for up to 6 months of storage in pharmacy-produced syringes20,21,22,23,24,25,26. Considering ranibizumab, there are two reports with conflicting results; one reports reduced VEGF binding activity after 1 week26, while the other reports unaltered activity after 4 weeks27.
We describe a novel method for compounding of aflibercept into sterile syringes prepared for intravitreal injection. When stored in the dark at 4 °C a range of assays show that the molecular integrity, stability and functional properties of aflibercept remain unaffected for up to 4 weeks. The present paper is the first to present such a thorough investigation. Adding to the evidence, a recent paper describes unaltered activity of aflibercept using an ELISA set-up where binding to placental growth factor instead of VEGF was measured and different syringes were used27. The authors conclude that aflibercept can be stored in plastic syringes for up to 4 weeks before use.
Aflibercept is also approved for treatment of metastatic colorectal cancer (Zaltrap, Sanofi-Aventis and Regeneron). The so-called ziv-aflibercept, which is produced by a different procedure, has higher osmolarity and lower drug concentration than aflibercept28. Regardless, there are many reports on intravitreal use of ziv-aflibercept29,30,31,32. It has been shown that ziv-aflibercept maintains some of its ability to bind VEGF after 4 weeks of storage in polycarbonate syringes28. However, a significant decline in affinity (61% reduction after 4 weeks of storage) suggests that the activity of ziv-aflibercept is negatively affected by the storage. This discrepancy from our findings can most likely be ascribed to the differences in production and formulation of the two aflibercept drugs.
In the current study, aflibercept from freshly drawn, injection-ready syringes were used as the reference (D0), and not aflibercept from the original vial. The rationale behind this choice was that the drug will always have to be withdrawn into a syringe before intravitreal injection. In a previous paper assessing the stability of bevacizumab in syringes prepared by 11 different compounding pharmacies, bevacizumab from the original vial was used as reference25. Using drug from the original vial as reference introduces a source of error, as protein stability and integrity may be affected simply by the withdrawal into a syringe, while the question of interest is whether it is affected by storage.
We chose four weeks storage duration to address how aflibercept was affected over time and to facilitate comparison with previous studies where the same timeframe has been used20,21,22,23,24,26,27,28. In a Norwegian context one week is the more relevant storage time, as this is the maximum shelf life allowed in Norway when an aseptic production procedure without renewed sterilization is employed. Our data demonstrate that fully active aflibercept ready for intravitreal injection can be guaranteed after one week of storage.
Both the aflibercept and bevacizumab molecules include an Fc portion derived from human IgG1. The Fc portion has been shown to be important for clearance of intravitreally injected IgG through interaction with FcRn19. In this study, we show that human FcRn binds aflibercept in a strictly pH dependent manner and that there is no differences in binding activity between D28 and D7 samples compared to D0 controls. This implies that intra-ocular transport kinetics are unaltered and thus should not interfere with the clinical efficacy. This is an aspect of bevacizumab and aflibercept function that has not been investigated in previous stability studies.
Despite being in line with the drug agency-approved administration, preparing syringes in the operating room involve a risk of bacterial contamination. The aseptic production described in this paper most likely reduces the risk of contamination and thereby lowers the risk of bacterial endophthalmitis13. This issue was not investigated in the present paper, as the sample size needed to obtain statistical power for this presumably very rare occurrence would have been prohibitive. Previous studies on bevacizumab, however, show no bacterial contamination of repackaged syringes24,25, but carry the same statistical caveat. In our clinic, we have used pharmacy-prepared aflibercept as described in this paper since March 2016 (until September 2017 practicing a shelf-life of 24 hours), and performed more than 10.000 intravitreal injections, so far without any cases of endophthalmitis. Although not enough to conclude statistically due to the low overall incidence of bacterial endophthalmitis, this indicates that our practice of pharmacy compounding is at least as safe as preparation of syringes in the operating room.
Aside from an apparent improvement in safety and decreased time spent per patient in the operating room14, the main benefit from pharmacy compounding is the reduced health care expenses. In 2016, our eye department performed around 10 000 intravitreal injections with aflibercept. Pharmacy compounding at our clinic alone thus saved an annual 44 million NOK (5.6 million USD) for the Norwegian public health care system.
In conclusion, aflibercept compounded into injection-ready syringes can be stored for 4 weeks without affecting neither VEGF nor FcRn binding properties and thus should retain unaltered clinical efficacy.
Materials and Methods
Aflibercept was acquired commercially (Eylea®). Prefilled injection syringes intended for intravitreal injection were produced under standard conditions at the hospital pharmacy. The syringes were filled aseptically in an isolator unit with a class A production chamber and class B transfer chambers (classifications according to EU GMP33 and ISO 14644-134). The production followed validated aseptic production procedures33, which involves closed systems, sterile single-use equipment and certified personnel. The contents of two vials of aflibercept (~0.22 ml/vial) were drawn into one syringe (Injekt-F, 1 ml, Braun). From the tip of this syringe, ~0.055 ml was drawn into each of six insulin plastic syringes (BD Micro-Fine Plus, 0.5 ml, 30 G, 8 mm, Becton, Dickson and Co.). The syringes were then capped, packed separately in sterile transparent plastic bags (Intervoid Steril, 150 × 220 ml, Coveris) and eventually visually inspected and labelled outside the isolator. The finished syringes were stored under dark conditions at 4 °C for 0, 7 or 28 days (D0, D7 and D28). The D7 and D28 experiments were performed on separate days, and were compared to separate sets of D0 samples. Thus, the D0 sample size was 12 while the D7 and D28 sample size was 6.
Aflibercept samples were transferred from prefilled syringes to sterile Eppendorf tubes (Eppendorf) and incubated on ice while being protected from direct light. Each sample was diluted 1:10 in sterile phosphate buffered saline (PBS) (Sigma-Aldrich). The concentrations of both undiluted and diluted samples were determined using a DeNovix DS-11+ Spectrophotometer (Saveene Werner) following the manufacturer instructions. Two independent measurements were done for each sample and the average value calculated.
Aliquots of 1 µg of aflibercept collected from prefilled syringes were mixed with distilled water and LDS sample buffer (Novex) with or without DL-dithiothreitol solution (Sigma-Aldrich). Samples containing DL-dithiothreitol were incubated for 5 min. at 95 °C before being applied onto 12% Bis-Tris Plus gel (Invitrogen) and run at 200 V for 22 min. Spectra™ Multicolor Broad Range Protein Ladder (ThermoFisher) was used for molecular size comparisons, and the protein bands were visualized by Coomassie staining (Bio-Rad).
Size exclusion chromatography (SEC)
SEC was performed using an Avant-25 ÄKTA instrument (GE Healthcare) and Superdex 200 Increase 10/300 GL column (GE Healthcare). Aliquots of aflibercept collected from prefilled syringes were diluted in PBS (8 mg/ml) and 77 µl of each sample was injected using an auto-sampler (Spark). The sample compartment was kept at 4 °C while the analysis temperature was 25 °C.
Anti-human Fc ELISA
96-well ELISA plates (Corning-Costar) were coated with 0.2 µg/ml human VEGF165 (Sigma-Aldrich) diluted in PBS (Sigma-Aldrich). After overnight incubation at 4 °C, plates were blocked with PBS containing 4% skimmed milk (S) (Sigma-Aldrich) for 1 hour at room temperature and washed 4 times with PBS containing 0.05% Tween-20 (T) (Sigma-Aldrich). Serial dilutions of collected aflibercept samples (1000.0–0.5 ng/ml) in PBS/S/T were added to the plates followed by incubation at room temperature for 1.5 hours. Plates were then washed as described above, before an alkaline phosphatase-conjugated goat polyclonal antibody directed towards human IgG Fc (Sigma-Aldrich), diluted (1:5000) in PBS/S/T, was added and incubated at room temperature for 1.5 hours. The plates were washed as above before 100 µl of the p-nitrophenylphospate substrate (Sigma-Aldrich), diluted to 10 µg/ml in diethanolamine buffer, was added. The absorbance was measured at 405 nm using a Sunrise spectrophotometer (TECAN).
FcRn binding ELISA
96-well ELISA plates (Costar) were coated with 0.5 µg/ml human VEGF165 (Sigma-Aldrich) and blocked before serial dilutions of collected aflibercept samples were added as above. Plates were washed with PBS/T (pH 7.4) or 67 mM phosphate buffer (pH 5.5), before 1.0 µg/ml of GST-tagged receptor FcRn35, diluted in pH 7.4 or pH 5.5 buffer, was added and incubated at room temperature for 1.5 hours. The plates were washed as above before a horseradish peroxidase-conjugated goat polyclonal antibody directed towards GST (Rockland Immunochemicals Inc), diluted (1:8000) in pH 7.4 or pH 5.5 buffer, was added and incubated at room temperature for 1.5 hours. After washing as above, bound receptor was detected using the tetramethylbenzidine substrate (Calbiochem) and the reaction was stopped by adding 50 µl 1 M HCl. The absorbance was measured at 450 nm using a Sunrise spectrophotometer (TECAN).
Surface plasmon resonance (SPR)
SPR was performed using a Biacore T200 instrument (GE Healthcare) with CM5 sensor chips coupled with human VEGF165 (Sigma-Aldrich) (~300 resonance units (RU)) using amine-coupling chemistry as described by the manufacturer. Briefly, the coupling was performed by injecting 5 μg/ml of VEGF diluted in 10 mM sodium acetate, pH 4.5 (GE Healthcare) using the amine-coupling kit (GE Healthcare). HBS-EP pH 7.4 buffer (0.01 M HEPES, 0.15 NaCl, 3 mM EDTA 0.005% surfactant P20) was used as both dilution and running buffer. Binding analysis was performed by injecting 100 nM of each aflibercept sample over the immobilized surface using a flow rate of 50 µl/min and 10 mM NaOH was used to regenerate the CM5 surface. The sample compartment was kept at 4 °C while the binding analysis was performed at 25 °C. The binding data were zero adjusted and the maximum binding responses of the individual injections were normalized using the BIAevaluation software version 4.1.
Differential scanning fluorimetry (DSF)
Thermal stability of aflibercept was determined by DSF using a Lightcycler RT-PCR machine (Roche). SYPO Orange (Sigma-Aldrich) was used at a 1:500 dilution and protein concentration at 0.1 mg/ml in a final volume of 25 µl. All samples were run in triplicates in 96 well Lightcycler 480 Mulltiwell Plate (Roche). The peak of excitation and emission of SYPO Orange were 490 nm and 580 nm, respectively, and the 450 nm excitation and 568 nm emission filters on the RT-PCR machine were used. The RT-PCR machine was programmed to raise the temperature from 20 °C to 95 °C after a stabilization period of 10 min at 20 °C. Two measurements at each temperature were recorded, and data collected every 0.5 °C. Data transformation and analysis were performed using the DSF analysis protocol36.
Figures and statistical analyses were performed using GraphPad Prism 7 for Windows (Version 7.02; GraphPad Software Inc.) and Microsoft Excel 2010 (Microsoft). P-values lower than 0.05 were considered statistically significant.
The datasets generated during and/or analyzed during the current study are available from the corresponding author on reasonable request.
Rosenfeld, P. J. et al. Ranibizumab for neovascular age-related macular degeneration. The New England journal of medicine 355, 1419–1431, https://doi.org/10.1056/NEJMoa054481 (2006).
Brown, D. M. et al. Ranibizumab versus verteporfin for neovascular age-related macular degeneration. The New England journal of medicine 355, 1432–1444, https://doi.org/10.1056/NEJMoa062655 (2006).
Baker, C. W., Jiang, Y. & Stone, T. Recent advancements in diabetic retinopathy treatment from the Diabetic Retinopathy Clinical Research Network. Current opinion in ophthalmology 27, 210–216, https://doi.org/10.1097/ICU.0000000000000262 (2016).
Oellers, P., Grewal, D. S. & Fekrat, S. Role of aflibercept for macular edema following branch retinal vein occlusion: comparison of clinical trials. Clinical ophthalmology 10, 411–418, https://doi.org/10.2147/OPTH.S98853 (2016).
Group, C. R. et al. Ranibizumab and bevacizumab for neovascular age-related macular degeneration. The New England journal of medicine 364, 1897–1908, https://doi.org/10.1056/NEJMoa1102673 (2011).
Berg, K. et al. Ranibizumab or Bevacizumab for Neovascular Age-Related Macular Degeneration According to the Lucentis Compared to Avastin Study Treat-and-Extend Protocol: Two-Year Results. Ophthalmology 123, 51–59, https://doi.org/10.1016/j.ophtha.2015.09.018 (2016).
Chakravarthy, U. et al. Alternative treatments to inhibit VEGF in age-related choroidal neovascularisation: 2-year findings of the IVAN randomised controlled trial. Lancet 382, 1258–1267, https://doi.org/10.1016/S0140-6736(13)61501-9 (2013).
Wells, J. A. et al. Aflibercept, Bevacizumab, or Ranibizumab for Diabetic Macular Edema: Two-Year Results from a Comparative Effectiveness Randomized Clinical Trial. Ophthalmology 123, 1351–1359, https://doi.org/10.1016/j.ophtha.2016.02.022 (2016).
McCannel, C. A. Meta-analysis of endophthalmitis after intravitreal injection of anti-vascular endothelial growth factor agents: causative organisms and possible prevention strategies. Retina 31, 654–661, https://doi.org/10.1097/IAE.0b013e31820a67e4 (2011).
Merani, R. & Hunyor, A. P. Endophthalmitis following intravitreal anti-vascular endothelial growth factor (VEGF) injection: a comprehensive review. International journal of retina and vitreous 1, 9, https://doi.org/10.1186/s40942-015-0010-y (2015).
Papadopoulos, N. et al. Binding and neutralization of vascular endothelial growth factor (VEGF) and related ligands by VEGF Trap, ranibizumab and bevacizumab. Angiogenesis 15, 171–185, https://doi.org/10.1007/s10456-011-9249-6 (2012).
Balaratnasingam, C., Dhrami-Gavazi, E., McCann, J. T., Ghadiali, Q. & Freund, K. B. Aflibercept: a review of its use in the treatment of choroidal neovascularization due to age-related macular degeneration. Clinical ophthalmology 9, 2355–2371, https://doi.org/10.2147/OPTH.S80040 (2015).
VanderBeek, B. L., Bonaffini, S. G. & Ma, L. Association of compounded bevacizumab with postinjection endophthalmitis. JAMA ophthalmology 133, 1159–1164, https://doi.org/10.1001/jamaophthalmol.2015.2556 (2015).
Subhi, Y., Kjer, B. & Munch, I. C. Prefilled syringes for intravitreal injection reduce preparation time. Danish medical journal 63 (2016).
Ward, E. S. & Ober, R. J. Chapter 4: Multitasking by exploitation of intracellular transport functions the many faces of FcRn. Adv Immunol 103, 77–115, https://doi.org/10.1016/S0065-2776(09)03004-1 (2009).
Roopenian, D. C. & Akilesh, S. FcRn: the neonatal Fc receptor comes of age. Nat Rev Immunol 7, 715–725, https://doi.org/10.1038/nri2155 (2007).
Gao, X. et al. Effect of individual Fc methionine oxidation on FcRn binding: Met252 oxidation impairs FcRn binding more profoundly than Met428 oxidation. Journal of pharmaceutical sciences 104, 368–377, https://doi.org/10.1002/jps.24136 (2015).
Stracke, J. et al. A novel approach to investigate the effect of methionine oxidation on pharmacokinetic properties of therapeutic antibodies. mAbs 6, 1229–1242, https://doi.org/10.4161/mabs.29601 (2014).
Kim, H., Robinson, S. B. & Csaky, K. G. FcRn receptor-mediated pharmacokinetics of therapeutic IgG in the eye. Molecular vision 15, 2803–2812 (2009).
Bakri, S. J. et al. Six-month stability of bevacizumab (Avastin) binding to vascular endothelial growth factor after withdrawal into a syringe and refrigeration or freezing. Retina 26, 519–522, https://doi.org/10.1097/01.iae.0000225354.92444.7a (2006).
Paul, M. et al. Long-term stability of bevacizumab repackaged in 1mL polypropylene syringes for intravitreal administration. Annales pharmaceutiques francaises 70, 139–154, https://doi.org/10.1016/j.pharma.2012.03.006 (2012).
Pereboom, M. et al. Stability assessment of repackaged bevacizumab for intravitreal administration. International journal of pharmaceutical compounding 19, 70–72 (2015).
Phasukkijwatana, N., Tanterdtham, J. & Lertpongparkpoom, D. Stability of Bevacizumab Divided in Multiple Doses for Intravitreal Injection. Journal of the Medical Association of Thailand = Chotmaihet thangphaet 98, 798–803 (2015).
Signorello, L. et al. Quantification, microbial contamination, physico-chemical stability of repackaged bevacizumab stored under different conditions. Current pharmaceutical biotechnology 15, 113–119 (2014).
Yannuzzi, N. A. et al. Evaluation of compounded bevacizumab prepared for intravitreal injection. JAMA ophthalmology 133, 32–39, https://doi.org/10.1001/jamaophthalmol.2014.3591 (2015).
Grisanti, S. & Tura, A. Qualitative differences between ranibizumab from original and ready to use syringes. Der Ophthalmologe: Zeitschrift der Deutschen Ophthalmologischen Gesellschaft 107, 1123–1132, https://doi.org/10.1007/s00347-010-2299-0 (2010).
Cao, S., Cui, J., Matsubara, J. & Forooghian, F. Long-term in vitro functional stability of compounded ranibizumab and aflibercept. Canadian journal of ophthalmology. Journal canadien d’ophtalmologie 52, 273–276, https://doi.org/10.1016/j.jcjo.2016.11.012 (2017).
Mansour, A. M., Al-Ghadban, S. I., Yunis, M. H. & El-Sabban, M. E. Ziv-aflibercept in macular disease. The British journal of ophthalmology 99, 1055–1059, https://doi.org/10.1136/bjophthalmol-2014-306319 (2015).
Andrade, G. C. et al. Intravitreal injections of ziv-aflibercept for diabetic macular edema: A Pilot Study. Retina 36, 1640–1645, https://doi.org/10.1097/IAE.0000000000001000 (2016).
Braimah, I. Z., Agarwal, K., Mansour, A., Chhablani, J. & Ziv-aflibercept Study, G. One-year outcome of intravitreal ziv-aflibercept therapy for non-responsive neovascular age-related macular degeneration. The British journal of ophthalmology, https://doi.org/10.1136/bjophthalmol-2017-310318 (2017).
Paulose, R., Chhablani, J., Dedhia, C. J., Stewart, M. W. & Mansour, A. M. Intravitreal ziv-aflibercept for macular edema following retinal vein occlusion. Clinical ophthalmology 10, 1853–1858, https://doi.org/10.2147/OPTH.S116343 (2016).
Videkar, C., Kapoor, A., Chhablani, J. & Narayanan, R. Ziv-aflibercept: a novel option for the treatment of polypoidal choroidal vasculopathy. BMJ Case Rep 2015, https://doi.org/10.1136/bcr-2015-212988 (2015).
European Commission. The Rules Governing Medicinal Products in the European Union; Volume 4; EU Guidelines to Good Manufacturing Practice; Medicinal Products for Human and Veterinary Use; Annex; Manufacture of Sterile Medicinal Products (corrected version). https://ec.europa.eu/health/documents/eudralex/vol-4_en (2008).
International Organization for Standardization. ISO 14644-1 Cleanrooms and associated controlled environments - Part 1: Classification of air cleanliness by particle concentration. https://www.iso.org/standard/53394.html (2015).
Andersen, J. T. et al. Ligand binding and antigenic properties of a human neonatal Fc receptor with mutation of two unpaired cysteine residues. The FEBS journal 275, 4097–4110, https://doi.org/10.1111/j.1742-4658.2008.06551.x (2008).
Niesen, F. H., Berglund, H. & Vedadi, M. The use of differential scanning fluorimetry to detect ligand interactions that promote protein stability. Nature protocols 2, 2212–2221, https://doi.org/10.1038/nprot.2007.321 (2007).
The authors would like to thank Dag Fossum, Head of Sterile Production and his team at the Hospital Pharmacy Unit, Oslo University Hospital, Ullevål, for the excellent collaboration in the continuous development and quality control of the compounding procedure. The work is supported by innovation grants from the South-Eastern Norway Regional Health Authority. J.T.A. was in part supported by the Research Council of Norway through its Centres of Excellence funding scheme (project number 179573) and the Research Council of Norway (Grant no. 230526/F20 and 179573/V40). S.F. was supported by the Research Council of Norway (251037/F20).
Magne Sand Sivertsen is an investigator in an Alcon sponsored clinical trial. Øystein Kalsnes Jørstad has received lecture fees from Allergan, Alcon, Bayer and Novartis, is member of a Bayer advisory board and is an investigator in an Alcon sponsored clinical trial. Morten C. Moe is member of Bayer and Novartis advisory boards and is an investigator in an Alcon sponsored clinical trial.
Publisher's note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Sivertsen, M.S., Jørstad, Ø.K., Grevys, A. et al. Pharmaceutical compounding of aflibercept in prefilled syringes does not affect structural integrity, stability or VEGF and Fc binding properties. Sci Rep 8, 2101 (2018). https://doi.org/10.1038/s41598-018-20525-8
Comprehensive biophysical and functional study of ziv-aflibercept: characterization and forced degradation
Scientific Reports (2020)
Compatibility of [99mTc]Tc-EDDA/HYNIC-TOC and [68Ga] Ga-DOTA-TOC in a syringe for intravenous administration
Nuclear Medicine Communications (2020)
Der Ophthalmologe (2020)
Graefe's Archive for Clinical and Experimental Ophthalmology (2020)
Acta Ophthalmologica (2019)