Cu2O nanocubes with mixed oxidation-state facets for (photo)catalytic hydrogenation of carbon dioxide

Abstract

Cuprous oxide (Cu2O), an earth-abundant, low-cost metal-oxide semiconductor, has received enormous attention for its CO2 reduction ability in aqueous media by photochemical, photoelectrochemical and electrochemical methods. An unresolved problem with all of these approaches, however, is the instability of the Cu2O caused by its tendency to undergo an irreversible redox disproportionation reaction. Here, we report a way to circumvent this troublesome behaviour of Cu2O by driving the CO2 reduction in the gas-phase via heterogeneous photocatalytic hydrogenation. To this end, Cu2O nanocubes with surfaces comprising mixed oxidation-state copper Cu(0,I,II) sites, oxygen vacancies [O] and hydroxyl OH groups were synthesized. These surfaces enable heterolysis of H2 and adsorption of CO2 under mild conditions; they facilitate the reverse water–gas shift reaction, while rendering the redox disproportionation reaction reversible. This synergism provides Cu2O nanocubes with high photocatalytic activity and stability.

Access options

Rent or Buy article

Get time limited or full article access on ReadCube.

from$8.99

All prices are NET prices.

Fig. 1: Growth mechanism of CF-Cu2O.
Fig. 2: Structure of CF-Cu2O.
Fig. 3: Photocatalytic performance of CF-Cu2O.
Fig. 4: In situ DRIFTS results for CF-Cu2O at 25 °C.
Fig. 5: In situ DRIFTS results for CF-Cu2O under light irradiation.
Fig. 6: Proposed reaction pathways for the photocatalytic hydrogenation of CO2.

Data availability

The data that support the plots within this paper and other findings of this study are available from the corresponding author upon reasonable request.

References

  1. 1.

    IPCC. Climate Change 2013: The Physical Science Basis: Working Group I Contribution to the Fifth Assessment Report of the Intergovernmental Panel on Climate Change (eds Stocker, T. F. et al.) (Cambridge Univ. Press, 2013).

  2. 2.

    Schreier, M. et al. Covalent immobilization of a molecular catalyst on Cu2O photocathodes for CO2 reduction. J. Am. Chem. Soc. 138, 1938–1946 (2016).

    CAS  Article  Google Scholar 

  3. 3.

    Tu, W., Zhou, Y. & Zou, Z. Photocatalytic conversion of CO2 into renewable hydrocarbon fuels: state‐of‐the‐art accomplishment, challenges, and prospects. Adv. Mater. 26, 4607–4626 (2014).

    CAS  Article  Google Scholar 

  4. 4.

    Roy, S. C., Varghese, O. K., Paulose, M. & Grimes, C. A. Toward solar fuels: photocatalytic conversion of carbon dioxide to hydrocarbons. ACS Nano 4, 1259–1278 (2010).

    CAS  Article  Google Scholar 

  5. 5.

    Wang, J. C. et al. Enhanced photoreduction CO2 activity over direct Z-scheme α-Fe2O3/Cu2O heterostructures under visible light irradiation. ACS Appl. Mater. Interfaces 7, 8631–8639 (2015).

    CAS  Article  Google Scholar 

  6. 6.

    Li, H., Zhang, X. & MacFarlane, D. R. Carbon quantum dots/Cu2O heterostructures for solar‐light‐driven conversion of CO2 to methanol. Adv. Energy Mater. 5, 1401077 (2015).

    Article  Google Scholar 

  7. 7.

    Handoko, A. D. & Tang, J. Controllable proton and CO2 photoreduction over Cu2O with various morphologies. Int. J. Hydrog. Energy 38, 13017–13022 (2013).

    CAS  Article  Google Scholar 

  8. 8.

    Grace, A. N. et al. Electrochemical reduction of carbon dioxide at low overpotential on a polyaniline/Cu2O nanocomposite based electrode. Appl. Energy 120, 85–94 (2014).

    CAS  Article  Google Scholar 

  9. 9.

    Chang, X. et al. Tuning Cu/Cu2O interfaces for the reduction of carbon dioxide to methanol in acqueous solutions. Angew. Chem. Int. Ed. 57, 15415–15419 (2018).

    CAS  Article  Google Scholar 

  10. 10.

    Tran, P. D., Wong, L. H., Barber, J. & Loo, J. S. Recent advances in hybrid photocatalysts for solar fuel production. Energy Environ. Sci. 5, 5902–5918 (2012).

    CAS  Article  Google Scholar 

  11. 11.

    Ghadimkhani, G., de Tacconi, N. R., Chanmanee, W., Janaky, C. & Rajeshwar, K. K. Efficient solar photoelectrosynthesis of methanol from carbon dioxide using hybrid CuO–Cu2O semiconductor nanorod arrays. Chem. Commun. 49, 1297–1299 (2013).

    CAS  Article  Google Scholar 

  12. 12.

    Xu, H. et al. Porous-structured Cu2O/TiO2 nanojunction material toward efficient CO2 photoreduction. Nanotechnol 25, 165402 (2014).

    Article  Google Scholar 

  13. 13.

    Li, F. et al. Photocatalytic CO2 conversion to methanol by Cu2O/graphene/TNA heterostructure catalyst in a visible-light-driven dual-chamber reactor. Nano Energy 27, 320–329 (2016).

    CAS  Article  Google Scholar 

  14. 14.

    Gou, L. & Murphy, C. J. Solution-phase synthesis of Cu2O nanocubes. Nano Lett. 3, 231–234 (2003).

    CAS  Article  Google Scholar 

  15. 15.

    Kuo, C. H., Chen, C. H. & Huang, M. H. Seed‐mediated synthesis of monodispersed Cu2O nanocubes with five different size ranges from 40 to 420 nm. Adv. Funct. Mater. 17, 3773–3780 (2007).

    CAS  Article  Google Scholar 

  16. 16.

    Park, J. C., Kim, J., Kwon, H. & Song, H. Gram‐scale synthesis of Cu2O nanocubes and subsequent oxidation to CuO hollow nanostructures for lithium‐ion battery anode materials. Adv. Mater. 21, 803–807 (2009).

    CAS  Article  Google Scholar 

  17. 17.

    Tsai, Y. H., Chanda, K., Chu, Y. T., Chiu, C. Y. & Huang, M. H. Direct formation of small Cu2O nanocubes, octahedra, and octapods for efficient synthesis of triazoles. Nanoscale 6, 8704–8870 (2014).

    CAS  Article  Google Scholar 

  18. 18.

    Huang, W. C., Lyu, L. M., Yang, Y. C. & Huang, M. H. Synthesis of Cu2O nanocrystals from cubic to rhombic dodecahedral structures and their comparative photocatalytic activity. J. Am. Chem. Soc. 134, 1261–1267 (2011).

    Article  Google Scholar 

  19. 19.

    Liu, H. et al. Scalable synthesis of hollow Cu2O nanocubes with unique optical properties via a simple hydrolysis-based approach. J. Mater. Chem. A. 1, 302–307 (2013).

    CAS  Article  Google Scholar 

  20. 20.

    Strandberg, H. Reactions of copper patina compounds—II. Influence of sodium chloride in the presence of some air pollutants. Atmos. Environ. 32, 3521–3526 (1998).

    CAS  Article  Google Scholar 

  21. 21.

    Lin, H. & Frankel, G. Atmospheric corrosion of Cu by UV, ozone and NaCl. Corros. Eng. Sci. Technol. 48, 461–468 (2013).

    CAS  Article  Google Scholar 

  22. 22.

    Sun, S., Yang, Q., Liang, S. & Yang, Z. Hollow CuxO (x = 2, 1) micro/nanostructures: synthesis, fundamental properties and applications. CrystEngComm 19, 6225–6251 (2017).

    CAS  Article  Google Scholar 

  23. 23.

    Liu, X. D., Hagihala, M., Zheng, X. G. & Guo, Q. X. Vibrational spectroscopic properties of botallackite-structure basic copper halides. Vib. Spectrosc. 56, 177–183 (2011).

    CAS  Article  Google Scholar 

  24. 24.

    Wang, Y. et al. Synthesis of porous Cu2O/CuO cages using Cu-based metal–organic frameworks as templates and their gas-sensing properties. J. Mater. Chem. A. 3, 12796–12803 (2015).

    CAS  Article  Google Scholar 

  25. 25.

    Colin, S., Beche, E., Berjoan, R., Jolibois, H. & Chambaudet, A. An XPS and AES study of the free corrosion of Cu-, Ni-and Zn-based alloys in synthetic sweat. Corros. Sci. 41, 1051–1065 (1999).

    CAS  Article  Google Scholar 

  26. 26.

    Jiang, P. et al. Experimental and theoretical investigation of the electronic structure of Cu2O and CuO thin films on Cu (110) using x-ray photoelectron and absorption spectroscopy. J. Chem. Phys. 138, 024704 (2013).

    Article  Google Scholar 

  27. 27.

    Azimi, H. et al. Effective ligand passivation of Cu2O nanoparticles through solid-state treatment with mercaptopropionic acid. J. Am. Chem. Soc. 136, 7233–7236 (2014).

    CAS  Article  Google Scholar 

  28. 28.

    Kattel, S., Yan, B., Yang, Y., Chen, J. G. & Liu, P. Optimizing binding energies of key intermediates for CO2 hydrogenation to methanol over oxide-supported copper. J. Am. Chem. Soc. 138, 12440–12450 (2016).

    CAS  Article  Google Scholar 

  29. 29.

    Toledo-Antonio, J. A. et al. Low-temperature FTIR study of CO adsorption on titania nanotubes. J. Phys. Chem. C. 111, 10799–10805 (2007).

    CAS  Article  Google Scholar 

  30. 30.

    Zecchina, A., Scarano, D., Bordiga, S., Spoto, G. & Lamberti, C. Surface structures of oxides and halides and their relationships to catalytic properties. Adv. Catal. 46, 265–397 (2001).

    CAS  Google Scholar 

  31. 31.

    Liu, L., Gao, F., Zhao, H. & Li, Y. Tailoring Cu valence and oxygen vacancy in Cu/TiO2 catalysts for enhanced CO2 photoreduction efficiency. Appl. Catal. B. 134, 349–358 (2013).

    Article  Google Scholar 

  32. 32.

    Liu, L. et al. Engineering coexposed {001} and {101} facets in oxygen-deficient TiO2 nanocrystals for enhanced CO2 photoreduction under visible light. ACS Catal. 6, 1097–1108 (2016).

    CAS  Article  Google Scholar 

  33. 33.

    Korzhavyi, P. A., Soroka, I. L., Isaev, E. I., Lilja, C. & Johansson, B. Exploring monovalent copper compounds with oxygen and hydrogen. Proc. Natl Acad. Sci. USA 109, 686–689 (2012).

    CAS  Article  Google Scholar 

  34. 34.

    Bennett, E. et al. How the surface structure determines the properties of CuH. Inorg. Chem. 54, 2213–2220 (2015).

    CAS  Article  Google Scholar 

  35. 35.

    Sun, B. Z., Chen, W. K., Zheng, J. D. & Lu, C. H. Roles of oxygen vacancy in the adsorption properties of CO and NO on Cu2O (1 1 1) surface: results of a first-principles study. Appl. Surf. Sci. 255, 3141–3148 (2008).

    CAS  Article  Google Scholar 

  36. 36.

    Hara, M. et al. Cu2O as a photocatalyst for overall water splitting under visible light irradiation. Chem. Commun. 3, 357–358 (1998).

    Article  Google Scholar 

Download references

Acknowledgements

Q.Z. wishes to thank NSFC (grant no. 21677080) for the partial support of this study. G.A.O. acknowledges the financial support of the following agencies: Ontario Ministry of Research and Innovation; Ministry of Economic Development, Employment and Infrastructure; Ministry of the Environment and Climate Change; Best in Science; Ministry of Research Innovation and Science Low Carbon Innovation Fund; Ontario Centre of Excellence Solutions 2030 Challenge Fund; Alexander von Humboldt Foundation; Imperial Oil; University of Toronto Connaught Innovation Fund; Connaught Global Challenge Fund and the Natural Sciences and Engineering Research Council of Canada. L.Wan acknowledges the financial support of the China Scholarship Council. W.S. acknowledges the 100-talents program of Zhejiang University, and Young Scientists Fund of the National Natural Science Foundation of China (grant no. 51902287). A. Tountas’ help on ASPEN estimation is acknowledged by all authors.

Author information

Affiliations

Authors

Contributions

L.Wan, W.S., Q.Z. and G.A.O. conceived and designed the experiments. L.Wan, W.S. and T.L. prepared the materials and performed the SEM, XRD and FTIR characterization with the support of X.W. L.Wan and W.S. carried out the batch with high intensity light experiments with the support of T.E.W. and J.J. W.S. and T.E.W. performed the long-term stability test in LED reactor. L.Wan, W.S., J.G., X.Y. and Y.F.L. performed the in situ DRIFTS study with the support of P.N.D. M.X. and L.Wang performed XPS characterizations. A.A.J. performed the TEM characterizations. U.U. performed the ICP–OES detection. L.Wan, W.S. and G.A.O. co-wrote the manuscript. All authors discussed the results and commented on the manuscript.

Corresponding authors

Correspondence to Qixing Zhou or Wei Sun or Geoffrey A. Ozin.

Ethics declarations

Competing interests

The authors declare no competing interests.

Additional information

Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Supplementary information

Supplementary Information

Supplementary Notes 1 and 2, Figs. 1–18, Tables 1–3 and references.

Rights and permissions

Reprints and Permissions

About this article

Verify currency and authenticity via CrossMark

Cite this article

Wan, L., Zhou, Q., Wang, X. et al. Cu2O nanocubes with mixed oxidation-state facets for (photo)catalytic hydrogenation of carbon dioxide. Nat Catal 2, 889–898 (2019). https://doi.org/10.1038/s41929-019-0338-z

Download citation

Further reading

Search

Nature Briefing

Sign up for the Nature Briefing newsletter — what matters in science, free to your inbox daily.

Get the most important science stories of the day, free in your inbox. Sign up for Nature Briefing