Skip to main content

Thank you for visiting You are using a browser version with limited support for CSS. To obtain the best experience, we recommend you use a more up to date browser (or turn off compatibility mode in Internet Explorer). In the meantime, to ensure continued support, we are displaying the site without styles and JavaScript.

  • Article
  • Published:

Silicon integrated circuit thermoelectric generators with a high specific power generation capacity


Microelectronic thermoelectric generators (TEGs), which can recycle waste heat into electrical power, have applications ranging from the on-chip thermal management of integrated circuits to environmental energy sources for Internet-of-things sensors. However, the incompatibility of TEGs with silicon integrated circuit technology has prevented their broad adoption in microelectronics. Here, we report TEGs created using nanostructured silicon thermopiles fabricated on an industrial silicon complementary metal–oxide–semiconductor (CMOS) process line. These TEGs exhibit a high specific power generation capacity (up to 29 μW cm−2 K−2) near room temperature, which is competitive with typical (Bi,Sb)2(Se,Te)3-based TEGs. The high power capacity results from the ability of CMOS processing to fabricate a very high areal density of thermocouples with low packing fraction and to carefully control electrical and thermal impedances. TEG power was also found to increase significantly when thermocouple width was decreased, providing a path to further improvements. Unlike (Bi,Sb)2(Se,Te)3 TEGs, our silicon integrated circuit TEGs could be seamlessly integrated into large-scale silicon CMOS microelectronic circuits at very low marginal cost.

This is a preview of subscription content, access via your institution

Access options

Buy this article

Prices may be subject to local taxes which are calculated during checkout

Fig. 1: Description of TEG devices.
Fig. 2: Performance data on a TEG.
Fig. 3: Electrical resistance and thermal impedance models.
Fig. 4: Maximum power dependence on nanoblade width.

Similar content being viewed by others

Data availability

The numerical data used to generate Figs. 24 in this Article are available from the corresponding author on reasonable request.


  1. Bell, L. E. Cooling, heating, generating power and recovering waste heat with thermoelectric systems. Science 321, 1457–1461 (2016).

    Article  Google Scholar 

  2. Kraemer, D. et al. High-performance flat-panel solar thermoelectric generators with high thermal concentration. Nat. Mater. 10, 532–538 (2011).

    Article  Google Scholar 

  3. Chowdhury, I. et al. On-chip cooling by superlattice-based thin-film thermoelectrics. Nat. Nanotechnol. 4, 235–238 (2009).

    Article  Google Scholar 

  4. Li, G. et al. Integrated microthermoelectric coolers with rapid response time and high device reliability. Nat. Electron. 1, 555–561 (2018).

    Article  Google Scholar 

  5. Raihan, A., Siddique, M., Mahmud, S. & Van Heyst, B. A review of the state of the science on wearable thermoelectric power generators (TEGs) and their existing challenges. Renew. Sustain. Energy Rev. 73, 730–744 (2017).

    Article  Google Scholar 

  6. Kim, S. J., We, J. H. & Cho, B. J. A wearable thermoelectric generator fabricated on a glass fabric. Energy Environ. Sci. 7, 1959–1965 (2014).

    Article  Google Scholar 

  7. Vullers, R. J. M. et al. Micropower energy harvesting. Solid State Electron. 53, 684–693 (2009).

    Article  Google Scholar 

  8. Hsu, C. T. et al. Experiments and simulations on low-temperature waste heat harvesting system by thermoelectric power generators. Appl. Energy 88, 1291–1297 (2011).

    Article  Google Scholar 

  9. Rojas, J. P. et al. Review—Micro and nano-engineering enabled new generation of thermoelectric generator devices and applications. ECS J. Solid State Sci. Technol. 6, N3036–N3044 (2017).

    Article  Google Scholar 

  10. Tomita, M. et al. Modeling, simulation, fabrication and characterization of a 10-μW/cm2 class Si-Nanowire thermoelectric generator for IoT applications. IEEE Trans. Elec. Dev. 65, 5180–5188 (2018).

    Article  Google Scholar 

  11. Nolas, G. S., Sharp, J. & Goldsmid, H. J. Thermoelectrics: Basic Principles and New Materials Developments Ch. 1 (Springer, 2001).

  12. Tian, Z., Lee, S. & Chen, G. Comprehensive review of heat transfer in thermoelectric materials and devices. Annu. Rev. Heat. Transf. 17, 425–483 (2014).

    Article  Google Scholar 

  13. Huang, L. et al. Recent progress in half-Heusler thermoelectric materials. Mater. Res. Bull. 76, 107–112 (2016).

    Article  Google Scholar 

  14. Guo, J. et al. Development of skutterudite thermoelectric materials and modules. J. Elec. Mater. 4, 1036–1042 (2012).

    Article  Google Scholar 

  15. Weber, L. & Gmelin, E. Transport properties of silicon. Appl. Phys. A 53, 136–140 (1991).

    Article  Google Scholar 

  16. Hochbaum, A. I. et al. Enhanced thermoelectric performance of rough silicon nanowires. Nature 451, 163–167 (2008).

    Article  Google Scholar 

  17. Boukai, A. I. et al. Silicon nanowires as efficient thermoelectric materials. Nature 451, 168–171 (2008).

    Article  Google Scholar 

  18. Oh, J. H., Shin, M. & Jang, M. G. Phonon thermal conductivity in silicon nanowires: the effects of surface roughness at low temperatures. J. Appl. Phys. 111, 044304 (2012).

    Article  Google Scholar 

  19. Shi, L., Yao, D., Zhang, G. & Li, B. Size dependent thermoelectric properties of silicon nanowires. Appl. Phys. Lett. 95, 063102 (2009).

    Article  Google Scholar 

  20. Zhang, G. et al. Thermoelectric performance of silicon nanowires. Appl. Phys. Lett. 94, 213108 (2009).

    Article  Google Scholar 

  21. Zianni, X. Monte Carlo simulations on the thermoelectric transport properties of width-modulated nanowires. J. Electron. Mater. 45, 1779–1785 (2016).

    Article  Google Scholar 

  22. Curtin, B. M., Fang, E. W. & Bowers, J. E. Highly ordered vertical silicon nanowire array composite thin films for thermoelectric devices. J. Electron. Mater. 41, 887–894 (2012).

    Article  Google Scholar 

  23. Li, Y. et al. Chip-level thermoelectric power generators based on high-density silicon nanowire array prepared with top-down CMOS technology. IEEE Electron Device Lett. 32, 674–676 (2011).

    Article  Google Scholar 

  24. Dávila, D. et al. Monolithically integrated thermoelectric energy harvester based on silicon nanowire arrays for powering micro/nanodevices. Nano Energy 1, 812–819 (2012).

    Article  Google Scholar 

  25. Xu, B., Khouri, W. & Fobelets, K. Two-sided silicon nanowire array/bulk thermoelectric power generator. IEEE Electron Device Lett. 35, 596–598 (2014).

    Article  Google Scholar 

  26. Noyan, I. D. et al. SiGe nanowire arrays based thermoelectric microgenerator. Nano Energy 57, 492–499 (2019).

    Article  Google Scholar 

  27. Noyan, I. D. et al. All-silicon thermoelectric micro/nanogenerator including a heat exchanger for harvesting applications. J. Power Sources 413, 125–133 (2019).

    Article  Google Scholar 

  28. Strasser, M. et al. Micromachined CMOS thermoelectric generators as on-chip power supply. Sens. Actuat. A 114, 362–370 (2004).

    Article  Google Scholar 

  29. Xie, J., Lee, C. & Feng, H. Design, fabrication and characterization of CMOS MEMS-based thermoelectric power generators. J. Microelectromech. Syst. 19, 317–324 (2010).

    Article  Google Scholar 

  30. Yu, X. et al. CMOS MEMS-based thermoelectric generator with an efficient heat dissipation path. J. Micromech. Microeng. 22, 105011 (2012).

    Article  Google Scholar 

  31. Yuan, Z. et al. A planar micro thermoelectric generator with high thermal resistance. Sens. Actuat. A 221, 67–76 (2015).

    Article  Google Scholar 

  32. Min, G. in Thermoelectrics Handbook (ed. Rowe, D. M.) Ch. 11 (CRC Press, 2006).

  33. Glatz, W., Schwyter, E., Durrer, L. & Hierold, C. Bi2Te3-based flexible micro thermoelectric generator with optimized design. J. Microelectromech. Syst. 18, 763–772 (2009).

    Article  Google Scholar 

  34. Edwards, H. et al. in Innovative Materials and Systems for Energy Harvesting Applications (eds Mescia, L., Losito, O. & Prudenzano, F.) Ch. 9 (Engineering Science Reference, 2015).

  35. Santos, J. D. et al. Power response of a planar thermoelectric microgenerator based on silicon nanowires at different convection regimes. Energy Harvest. Syst. 3, 335–342 (2016).

    Google Scholar 

  36. Gustafsson, S., Karawacki, E. & Khan, M. Transient hot-strip method for simultaneously measuring thermal conductivity and thermal diffusivity of solids and fluids. J. Phys. D 12, 1411–1421 (1979).

    Article  Google Scholar 

Download references


Work at the University of Texas at Dallas (UTD) was supported by the US National Science Foundation under contract no. ECCS-1707581. The fabrication and design of TEG devices was supported by Texas Instruments (TI). The authors thank J. DeBord (TI) for help with copper metal system questions, K. Maggio (TI) for circuit design help, A. Asaadzade (UTD) for assistance with the measurements and M. Kim (UTD) and Q. Wang (UTD) for their aid in taking cross-section SEM images.

Author information

Authors and Affiliations



G.H. made measurements, developed and wrote modelling code, and analysed data. H.E. designed the devices, supervised fabrication of the devices and analysed data. M.L. set up measurements, validated data and modelling, and analysed data.

Corresponding author

Correspondence to Mark Lee.

Ethics declarations

Competing interests

The fabrication and design of all TEG devices used in this work was supported by Texas Instruments. H.E. is an employee of Texas Instruments.

Additional information

Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Hu, G., Edwards, H. & Lee, M. Silicon integrated circuit thermoelectric generators with a high specific power generation capacity. Nat Electron 2, 300–306 (2019).

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI:

This article is cited by


Quick links

Nature Briefing

Sign up for the Nature Briefing newsletter — what matters in science, free to your inbox daily.

Get the most important science stories of the day, free in your inbox. Sign up for Nature Briefing