Skip to main content

Thank you for visiting nature.com. You are using a browser version with limited support for CSS. To obtain the best experience, we recommend you use a more up to date browser (or turn off compatibility mode in Internet Explorer). In the meantime, to ensure continued support, we are displaying the site without styles and JavaScript.

Surface-engineered sponges for recovery of crude oil microdroplets from wastewater

An Author Correction to this article was published on 13 January 2020

This article has been updated

Abstract

In the United States, the oil industry produces over 15 billion barrels of wastewater contaminated with crude oil microdroplets annually. Current methods are ineffective for the removal of these microdroplets at the variable pH conditions commonly found in wastewater. Here, an innovative surface-engineered sponge (SEnS) that synergistically combines surface chemistry, charge and roughness, provides a solution to this problem. Over broad pH conditions, the SEnS rapidly adsorbed oil microdroplets with 95–99% removal efficiency, predominantly facilitated by Lifshitz–van der Waals forces. At the optimum pH, 92% of the oil was adsorbed within 10 min. The oil was subsequently recovered by solvent extraction under ambient conditions, and the cleaned SEnS was reused for oil microdroplets adsorption ten times. The combined efficacy and reusability can enable large-scale removal and recovery of crude oil microdroplets from wastewater.

This is a preview of subscription content, access via your institution

Access options

Buy article

Get time limited or full article access on ReadCube.

$32.00

All prices are NET prices.

Fig. 1: The rationale behind the design of SEnS for oil microdroplets adsorption.
Fig. 2: SEnS surface physicochemical properties.
Fig. 3: SEnS surface roughness and wetting properties.
Fig. 4: Prediction and validation of crude oil adsorption based on material properties.
Fig. 5: SEnS regeneration, reuse and oil recovery.

Data availability

The data used in the current manuscript are available from C.B.P. upon reasonable request.

Change history

References

  1. Clark, C. E. & Veil, J. A. Produced Water Volumes and Management Practices in the United States Project No. ANL/EVS/R-09-1 (Argonne National Laboratory, US Department of Energy, 2009).

  2. Schindler, D. Tar sands need solid science. Nature 468, 499–501 (2010).

    CAS  Google Scholar 

  3. Pintor, A. M., Vilar, V. J., Botelho, C. M. & Boaventura, R. A. Oil and grease removal from wastewaters: sorption treatment as an alternative to state-of-the-art technologies—a critical review. Chem. Eng. J. 297, 229–255 (2016).

    CAS  Google Scholar 

  4. Ali, I. & Gupta, V. K. Advances in water treatment by adsorption technology. Nat. Protoc. 1, 2661–2667 (2007).

    Google Scholar 

  5. Li, R., Lianbin, Z. & Peng, W. Rational design of nanomaterials for water treatment. Nanoscale 7, 17167–17194 (2015).

    CAS  Google Scholar 

  6. Guilane, S. & Hamdaoui, O. Regeneration of exhausted granular activated carbon by low frequency ultrasound in batch reactor. Desalin. Water Treat. 57, 15826–15834 (2016).

    CAS  Google Scholar 

  7. Qu, W., Hu, Q., Zhu, Y., Peng, J. & Zhang, L. Microwave-assisted regeneration of spent activated carbon containing zinc acetate and its application for removal of congo red. Desalin. Water Treat. 57, 28496–28511 (2016).

    CAS  Google Scholar 

  8. Rizvi, A., Chu, R. K. M., Lee, J. H. & Park, C. B. Superhydrophobic and oleophilic open-cell foams from fibrillar blends of polypropylene and polytetrafluoroethylene. ACS Appl. Mater. Interfaces 6, 21131–21140 (2014).

    CAS  Google Scholar 

  9. Ge, J. et al. Advanced sorbents for oil‐spill cleanup: recent advances and future perspectives. Adv. Mater. 28, 10459–10490 (2016).

    CAS  Google Scholar 

  10. Ge, Jin et al. Joule-heated graphene-wrapped sponge enables fast clean-up of viscous crude-oil spill. Nat. Nanotechnol. 12, 434–440 (2017).

    CAS  Google Scholar 

  11. Mi, H. Y., Jing, X., Huang, H. X. & Turng, L. S. Controlling superwettability by microstructure and surface energy manipulation on three-dimensional substrates for versatile gravity-driven oil/water separation. ACS Appl. Mater. Interfaces 9, 37529–37535 (2017).

    CAS  Google Scholar 

  12. Xu, L. et al. Breathing demulsification: a three-dimensional free-standing superhydrophilic sponge. ACS Appl. Mater. Interfaces 7, 22264–22271 (2015).

    CAS  Google Scholar 

  13. Li, J. et al. Robust superhydrophobic attapulgite coated polyurethane sponge for efficient immiscible oil/water mixture and emulsion separation. J. Mater. Chem. A 4, 15546–15553 (2016).

    CAS  Google Scholar 

  14. Cherukupally, P., Acosta, E. J., Hinestroza, J. P., Bilton, A. M. & Park, C. B. Acid–base polymeric foams for the adsorption of micro-oil droplets from industrial effluents. Environ. Sci. Technol. 51, 8552–8560 (2017).

    CAS  Google Scholar 

  15. Buckley, J. S., Liu, Y. & Monsterleet, S. Mechanisms of wetting alteration by crude oils. SPE J. 3, 54–61 (1998).

    Google Scholar 

  16. Buckley, J. S., Takamura, K. & Morrow, N. R. Influence of electrical surface charges on the wetting properties of crude oils. SPE Res. Eng. 4, 332–340 (1989).

    CAS  Google Scholar 

  17. Zimmermann, R., Freudenberg, U., Schweiß, R., Küttner, D. & Werner, C. Hydroxide and hydronium ion adsorption. Curr. Opin. Colloid Interface Sci. 15, 196–202 (2010).

    CAS  Google Scholar 

  18. Vaćha, R. et al. The orientation and charge of water at the hydrophobic oil droplet−water interface. J. Am. Chem. Soc. 133, 10204–10210 (2011).

    Google Scholar 

  19. McCarty, L. S. & Whitesides, G. M. Electrostatic charging due to separation of ions at interfaces: contact electrification of ionic electrets. Angew. Chem. Int. Ed. 47, 2188–2207 (2008).

    CAS  Google Scholar 

  20. Lee, A. S. et al. Structure of pH-dependent block copolymer micelle: charge and ionic strength dependence. Macromolecules 35, 8540–8551 (2002).

    CAS  Google Scholar 

  21. Yu, X., Wang, Z., Jiang, Y., Shi, F. & Zhang, X. Reversible pH‐responsive surface: from superhydrophobicity to superhydrophilicity. Adv. Mater. 17, 1289–1293 (2005).

    CAS  Google Scholar 

  22. Zisman, W. A. Influence of constitution on adhesion. Ind. Eng. Chem. 55, 18–38 (1963).

    CAS  Google Scholar 

  23. Zhang, D. et al. Smart superwetting surface with responsivity in both surface chemistry and microstructure. Angew. Chem. Int. Ed. 57, 3701–3705 (2018).

    CAS  Google Scholar 

  24. Chaudhury, M. K. & Whitesides, G. M. Correlation between surface energy and surface constitution. Science 255, 1230–1232 (1992).

    CAS  Google Scholar 

  25. Baier, R. E., Shafrin, E. G. & Zisman, W. A. Adhesion: mechanisms that assist or impede it. Science 162, 1360–1368 (1968).

    CAS  Google Scholar 

  26. Baier, R. E. The role of surface energy in thrombogenesis. Bull. NY Acad. Med. 48, 257–272 (1972).

    CAS  Google Scholar 

  27. Absolom, D. R. et al. Surface thermodynamics of bacterial adhesion. Appl. Environ. Microbiol. 46, 90–97 (1983).

    CAS  Google Scholar 

  28. Baier, R. E., Michlovic, J. G., Depalma, V. A. & Pilie, R. J. Universal gelling agent for the control of hazardous liquid spills. J. Hazard. Mater. 1, 21–33 (1975).

    CAS  Google Scholar 

  29. Nosonovsky, M. Multiscale roughness and stability of superhydrophobic biomimetic interfaces. Langmuir 23, 3157–3161 (2007).

    CAS  Google Scholar 

  30. Qu, L. T., Dai, L. M., Stone, M., Xia, Z. H. & Wang, Z. L. Carbon nanotube arrays with strong shear binding-on and easy normal lifting-off. Science 322, 238–242 (2008).

    CAS  Google Scholar 

  31. Croissant, J. G., Fatieiev, Y. & Khashab, N. M. Degradability and clearance of silicon, organosilica, silsesquioxane, silica mixed oxide, and mesoporous silica nanoparticles. Adv. Mater. 29, 1604634 (2017).

    Google Scholar 

  32. Holm, L. W. & Csaszar, A. K. Oil recovery by solvents mutually soluble in oil and water. Soc. Pet. Eng. J. 2, 129–144 (1962).

    Google Scholar 

  33. Tie, L., Zhiguang, G. & Weimin, L. pH-manipulated underwater-oil adhesion wettability behavior on the micro/nanoscale semicircular structure and related thermodynamic analysis. ACS Appl. Mater. Interfaces 7, 10641–10649 (2015).

    CAS  Google Scholar 

  34. Zhou, Y., Ellis, M. W., Nain, A. S. & Behkam, B. Effect of electrode sub-micron surface feature size on current generation of Shewanella oneidensis in microbial fuel cells. J. Power Sources 347, 270–276 (2017).

    Google Scholar 

  35. Briggs, D., Brewis, D. M., Dahm, R. H. & Fletcher, I. W. Analysis of the surface chemistry of oxidized polyethylene: comparison of XPS and ToF‐SIMS. Surf. Interface Anal. 35, 156–167 (2003).

    CAS  Google Scholar 

  36. Andoa, R. A., do Nascimento, G. M., Landers, R. & Santos, P. S. Spectroscopic investigation of conjugated polymers derived from nitroanilines. Spectrochim. Acta A 69, 319 (2008).

    Google Scholar 

  37. Yu, Y. et al. Room temperature hydrosilylation of silicon nanocrystals with bifunctional terminal alkenes. Langmuir 29, 1533–1540 (2013).

    CAS  Google Scholar 

  38. Saint Flour, C. & Papirer, E. Gas–solid chromatography: a quick method of estimating surface free energy variations induced by the treatment of short glass fibers. J. Colloid Interface Sci. 91, 69–75 (1983).

    CAS  Google Scholar 

  39. Fowkes, F. M. Quantitative characterization of the acid–base properties of solvents, polymers, and inorganic surfaces. J. Adhes. Sci. Technol. 4, 669–691 (1990).

    CAS  Google Scholar 

  40. Grundke, K., Jacobasch, H. J., Simon, F. & Schneider, S. T. Physicochemical properties of surface modified polymers. J. Adhes. Sci. Technol. 9, 327–350 (1995).

    CAS  Google Scholar 

  41. Jacobasch, H. J., Grundke, K., Schneider, S. & Simon, F. Surface characterization of polymers by physicochemical measurements. J. Adhes. 48, 57–73 (1995).

    CAS  Google Scholar 

  42. Dukhin, S. S. & Derjaguin, B. V. in Surface and Colloid Science Vol. 7 (ed. Matijevic, E.) 297–300 (John Wiley & Sons, 1974).

  43. Dorris, G. M. & Gray, D. G. Adsorption of n-alkanes at zero surface coverage on cellulose paper and wood fibers. J. Colloid Interface Sci. 77, 353–362 (1980).

    CAS  Google Scholar 

  44. Van Oss, C. J., Good, R. J. & Chaudhury, M. K. Additive and nonadditve surface tension components and the interpretation of contact angles. Langmuir 4, 884–891 (1988).

    Google Scholar 

  45. Ambrosetti, A., Ferri, N., DiStasio, R. A. & Tkatchenko, A. Wavelike charge density fluctuations and van der waals interactions at the nanoscale. Science 351, 1171–1176 (2016).

    CAS  Google Scholar 

  46. Valtiner, M., Donaldson, S. H. Jr, Gebbie, M. A. & Israelachvili, J. N. Hydrophobic forces, electrostatic steering, and acid–base bridging between atomically smooth self-assembled monolayer and end-functionalized PEGolated lipid layers. J. Am. Chem. Soc. 134, 1746–1753 (2012).

    CAS  Google Scholar 

  47. Swain, S. K. et al. Development of a new inorganic–organic hybrid ion-exchanger of zirconium (iv)-propanolamine for efficient removal of fluoride from drinking water. Ind. Eng. Chem. Res. 49, 9846–9856 (2010).

    CAS  Google Scholar 

  48. Cherukupally, P., Chu, R. K. M., Bilton, A. & Park, C. B. Oil diffusion properties of acoustic foams for oil contaminated water treatment. AIP Conf. Proc. 1779, 050011 (2016).

    Google Scholar 

  49. Ho, Y. S. & McKay, G. Pseudo-second order model for sorption processes. Process Biochem. 34, 451–465 (1999).

    CAS  Google Scholar 

  50. Baier, R. E., Meyer, A. E. & Akers, C. K. in Biomedical Engineering (ed. Hall, C. W.) 293–296 (Elsevier, 1983).

  51. Sun, W., Qian, C., Mastronardi, M. L., Wei, M. & Ozin, G. A. Hydrosilylation kinetics of silicon nanocrystals. Chem. Comm. 49, 11361–11363 (2013).

    CAS  Google Scholar 

  52. Sun, W. et al. Switching‐on quantum size effects in silicon nanocrystals. Adv. Mater. 27, 746–749 (2015).

    CAS  Google Scholar 

  53. Mangolini, L., Jurbergs, D., Rogojina, E. & Kortshagen, U. Plasma synthesis and liquid-phase surface passivation of brightly luminescent Si nanocrystals. J. Lumin. 121, 327–334 (2006).

    CAS  Google Scholar 

  54. Pi, X. D., Mangolini, L., Campbell, S. A. & Kortshagen, U. Room-temperature atmospheric oxidation of Si nanocrystals after HF etching. Phys. Rev. B 75, 085423 (2007).

    Google Scholar 

  55. Sun, W. et al. Silicon monoxide—a convenient precursor for large scale synthesis of near infrared emitting monodisperse silicon nanocrystals. Nanoscale 8, 3678–3684 (2016).

    CAS  Google Scholar 

  56. Rizvi, A., Tabatabaei, A., Vahedi, P., Mahmood, S. H. & Park, C. B. Non-crosslinked thermoplastic reticulated polymer foams from crystallization-induced structural heterogeneities. Polymer 135, 185–192 (2018).

    CAS  Google Scholar 

  57. Hamidinejad, S. M., Chu, R. K., Zhao, B., Park, C. B. & Filleter, T. Enhanced thermal conductivity of graphene nanoplatelet-polymer nanocomposites fabricated via supercritical fluid assisted in-situ exfoliation. ACS Appl. Mater. Interfaces 10, 1225–1236 (2018).

    CAS  Google Scholar 

  58. Kwok, D. Y., Vollhardt, D., Miller, R., Li, D. & Neumann, A. W. Axisymmetric drop shape analysis as a film balance. Colloids Surf. A 88, 51–58 (1994).

    CAS  Google Scholar 

Download references

Acknowledgements

We thank S. Shah and R. Pini for providing access to the X-ray microCT instrument and image analysis, and J. P. M. Trusler for the tensiometer at the Chemical Engineering Department, Imperial College London. We also thank L. Fiddes for confocal and AFM imaging, A. Stammitti Scarpone for crude oil interfacial tension measurement, A. Kondor and J. Acs for surface energy measurements and T. Luxbacher of Anton–Paar for zeta potential measurements. We also thank Y. Lu for artistic contribution to Fig. 1a,b. P.C. appreciates a Bert Wasmund Graduate Fellowship in Sustainable Energy Research, Queen Elizabeth II/Herbert A. Staneland Graduate Scholarship in Science and Technology, William Dubar Memorial Scholarship in Mechanical Engineering, and Ontario Graduate Scholarship. The research work was supported by the Natural Sciences and Engineering Research Council of Canada (grant no. NSERC DG 154279-2010), Consortium of Cellular and Microcellular Plastics and Natural Resources Canada Oil Spill Response Program (grant no. OSRS2-011), Department of Fisheries and Oceans (grant no. MECTS-3955465), Natural Sciences and Engineering Research Council of Canada Discovery Grant, Engineering and Physical Sciences Research Council, UK, and National Natural Science Foundation of China (grant no. 51902287).

Author information

Authors and Affiliations

Authors

Contributions

P.C. designed an interdisciplinary research plan and coordinated the project. P.C., W.S., D.R.W., G.A.O. and C.B.P. designed and analysed materials, P.C. and D.R.W. designed and analysed chemical processes, P.C. and A.M.B. designed and analysed water quality studies. P.C., W.S. and A.P.Y.W. performed experiments. P.C. drafted the manuscript. A.M.B. and C.B.P. edited the manuscript. All authors critically reviewed and approved the final manuscript.

Corresponding authors

Correspondence to Geoffrey A. Ozin, Amy M. Bilton or Chul B. Park.

Ethics declarations

Competing interests

Based on the datasets used in the manuscript, a patent application has been filed (British Provisional Patent Application no. GB 1905680.3).

Additional information

Publisher’s note Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Supplementary information

Supplementary Information

Supplementary Figs. 1–8, Discussion, Tables 1 and 2 and refs. 1 and 2.

Supplementary Video

The three-dimensional view of the SEnS, obtained using in-situ micro-CT, shows the adsorbed oil droplets spread on the pore surface and remain trapped inside. The images are not to scale.

Rights and permissions

Reprints and Permissions

About this article

Verify currency and authenticity via CrossMark

Cite this article

Cherukupally, P., Sun, W., Wong, A.P.Y. et al. Surface-engineered sponges for recovery of crude oil microdroplets from wastewater. Nat Sustain 3, 136–143 (2020). https://doi.org/10.1038/s41893-019-0446-4

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1038/s41893-019-0446-4

This article is cited by

Search

Quick links

Nature Briefing

Sign up for the Nature Briefing newsletter — what matters in science, free to your inbox daily.

Get the most important science stories of the day, free in your inbox. Sign up for Nature Briefing