Enormous amounts of keratinaceous waste make a significant and unexploited protein reserve that can be utilized through bioconversion into high-value products using microbial keratinases. This study was intended to assess the keratinase production from a newly isolated B. velezensis NCIM 5802 that can proficiently hydrolyze chicken feathers. Incubation parameters used to produce keratinase enzyme were optimized through the Response Surface Methodology (RSM) with chicken feathers as substrate. Optimization elevated the keratinase production and feather degradation by 4.92-folds (109.7 U/mL) and 2.5 folds (95.8%), respectively. Time-course profile revealed a direct correlation among bacterial growth, feather degradation, keratinase production and amino acid generation. Biochemical properties of the keratinase were evaluated, where it showed optimal activity at 60 °C and pH 10.0. The keratinase was inhibited by EDTA and PMSF, indicating it to be a serine–metalloprotease. Zymography revealed the presence of four distinct keratinases (Mr ~ 100, 62.5, 36.5 and 25 kDa) indicating its multiple forms. NMR and mass spectroscopic studies confirmed the presence of 18 free amino acids in the feather hydrolysates. Changes in feather keratin brought about by the keratinase action were studied by X-ray diffraction (XRD) and spectroscopic (FTIR, Raman) analyses, which showed a decrease in the total crystallinity index (TCI) (1.00–0.63) and confirmed the degradation of its crystalline domain. Scanning electron microscopy (SEM) revealed the sequential structural changes occurring in the feather keratin during degradation. Present study explored the use of keratinolytic potential of the newly isolated B. velezensis NCIM 5802 in chicken feather degradation and also, unraveled the underlying keratin hydrolysis mechanism through various analyses.
Keratin waste like feathers, hairs, nails, hooves, horns, wool, etc. can serve as an excellent source of protein. Keratins are insoluble, recalcitrant, highly cross-linked, fibrous structural proteins resistant to proteolysis1. The ordered structural arrangement of α-helical and β-sheet configurations provides the stability and robustness, whereas disulfide bonds are equally responsible for conferring a high degree of rigidity, strength, and resistance to chemical as well as biological degradation to the protein. In the poultry processing industry, the increased production of meat over the years has caused concomitant increase in unwanted solid poultry waste, mainly keratin2,3,4. Literature suggests that more than 85% of keratin content is produced in the form of feathers and roughly around 10 million tons per year of feather waste is generated worldwide, representing a massive sustainable protein reserve5. However, the high degree of disulfide bonds and hydrophobic nature of keratin makes its utilization and management extremely difficult and bears hazardous consequences upon the environment6.
This recalcitrant reserve presents a formidable challenge for its processing into value-added by-products7. Conventionally, the keratin biomass is hydrolyzed further by physical and chemical processes such as hydrothermal extraction, or treatment with reducing agents leading to production of stimulants, animal feedstock, fertilizers, amino acids, and soil conditioner8,9. Feather meals are commonly obtained by subjecting the keratin biomass to the hydrothermal process where the feathers are cooked at high pressure and temperature. Hydrothermal treatment provides efficient and complete conversion of feathers into feather meal; however, the resulting feather meal loses its nutritional value and digestibility during the process. As the decomposition of feather biomass through a hydrothermal or chemical process, ensues the decomposition of essential amino acids, such as methionine, lysine, tryptophan, cysteine, and tyrosine. Apart from being detrimental to the environment, physico-chemical treatments also need high energy and reagent inputs incurring high costs8,10.
Biodegradation of the keratinous waste through microbial keratinases is an effective and inexpensive valorization approach for the efficient treatment of keratin-rich wastes that entails waste management, human and environmental safety, and resource generation (amino acids, peptides, and nonprotein nitrogenous compounds)11,12. Also, the conversion of low-priced readily accessible chicken feathers into dietary protein for animal feedstock strengthens a bio-economical approach. Keratinases (EC 3.4./24/99.11) are a set of proteases with a unique keratinolytic ability to depolymerize fibrous, recalcitrant structural keratins into soluble proteins13. A number of bacteria, fungi, and actinomycetes are known to produce keratinases14,15. Ker A was the first purified keratinase characterized from Bacillus licheniformis strain which belonged to subtilisin-like serine protease family (S8)16. Some other bacterial keratinases of the S8 family include those from B. subtilis, B. halodurans, and Streptomyces sp.17. Furthermore, keratinases belonging to the metalloprotease families have also been identified from various groups of bacteria and fungi18,19.
Keratinases have many prospective applications that are linked to the efficient conversion and production of feather meal, animal feedstock, biofertilizers, cosmetics, thermo-bioplastics, personal care items including anti-dandruff shampoo, and pharmaceutical products such as prion decontaminants20,21,22. The sturdiness of bacterial keratinases and the differences in their catalytic proficiency have highlighted the necessity for investigating other hyperactive and versatile keratinase-producing strains.
Therefore, the present study explores a cost-effective and eco-friendly approach to keratin waste recycling and optimization protocol for the enzymatic degradation of feather wastes along with its conversion into value-added products such as amino acids, soluble proteins, and oligopeptides using B. velezensis NCIM 5802 keratinase. Multi-scale characterization of the biocatalyst and the substrate was carried out to delineate the mechanism of the efficient keratin degradation.
Materials and methods
Chemicals and materials
All the chemicals used in this study were of analytical grade and utmost available purity. Keratin azure was purchased from Sigma-Aldrich, India while casein and gelatin were purchased from HiMedia, India. Chicken feathers were obtained from a local chicken slaughterhouse, extensively washed with warm water and mild detergents to remove blood, dirt, and other impurities followed by sun-drying for 4–5 days; and then were stored at room temperature, for further use.
Sample collection and isolation
Soil samples were collected from the university campus situated on the Patharia hills, Sagar, MP, India. Using the principle of enrichment culture, the collected samples were inoculated in distilled water containing 1% (w/v) autoclaved, clean intact feathers, and incubated at 37 °C, 120 rpm for two weeks. In cases where complete solubilization of feathers was observed, the suspension was serially diluted and inoculated on feather meal minimal salt agar (FMMSA)23. Plates were then incubated at 37 °C for 48 h and single colonies were transferred on FMMSA plates to get pure culture. Pure bacterial cultures, thus isolated, were assayed for extracellular caseinase and gelatinase production on casein or gelatin agar plates24. Promising bacterial cultures representing a prominent zone of hydrolysis on casein agar plate were tested for their feather degrading capability using the feather as a sole source of carbon and nitrogen, under submerged conditions at 37 °C and 200 rpm for 48 h. Among these, isolates showing higher feather degradation were further evaluated for feather solubilization (% w/w), soluble protein content, amino acid release, and extracellular keratinase activity. Promising bacterial isolates were sub-cultured and maintained on keratin agar slants (40% w/v) and were stored at 4 °C/− 80 °C for further use.
Morphological and molecular identification of the strain
Molecular validation of the isolate identity was achieved by 16S rDNA sequence assessment which involved extraction of genomic DNA and amplification and sequencing of 16S rRNA gene. Extraction of genomic DNA was carried out from 18 to 20 h old bacterial culture using Genomic DNA extraction kit (Thermo Fisher Scientific). Amplification of the 16S rDNA was carried out using Applied Biosystems Veriti Thermal Cycler, using two 16S rDNA universal primers with the subsequent sequences: 5′-AGAGTTTGATCCTGGCTCAG-3′ (27F) and 5′-GGTTACCTTGTTACGACTT-3′ (1492R) as forward and reverse primers, respectively. Amplification of the 16S genes was carried out as follows: initial denaturation 98 °C for 5 min, denaturation 95 °C for 30 s, annealing 55 °C for 30 s, extension 72 °C for 90 s, and final extension 72 °C for 8 min and the PCR was run for 30 cycles5,25. The amplified PCR products were sequenced, the resulting sequence was compared with the available sequences in the GenBank using BLAST tool and deposited in the GenBank. The culture was deposited in National Centre for Industrial Microorganism (NCIM), Pune. The isolate was identified by phylogenetic clustering and tree was constructed using ClustalW. Morphological features of NCIM 5802 were also studied by scanning electron microscopy (SEM).
Inoculum broth (50 mL) containing (g/L): 10.0 glucose, 10.0 peptone, 3.0 yeast extract, 2.0 calcium chloride (pH 7.0) was inoculated with a loopful of bacterial suspension and was incubated overnight at 37 °C, 150 rpm.
Keratinase production by NCIM 5802
Keratinase production was carried out in the feather meal minimal salt broth (FMMSA devoid of agar) supplemented with 0.5% (w/v) chicken feathers at 200 rpm at 40 °C for 96 h. After fermentation, the remaining chicken feathers were removed from the cultivation fluid by filtration through a glass filter. The culture filtrate thus obtained was centrifuged at 10,000g for 10 min at 4 °C. The protein was precipitated using acetone as described earlier23. The protein precipitate was resuspended in 0.05 M Citrate buffer (pH 5.0), dialyzed using 10 kDa cut-off membrane and was used as the source of keratinase.
Keratinase activity was performed according to the method described by Navone and Speight26 using keratin azure as the substrate with some modifications. Concisely, 0.01 g of keratin azure was suspended in 0.05 M Tris–HCl buffer (pH 10.0) to which appropriately diluted enzyme was added. Contents were mixed thoroughly by vortexing and the tubes were incubated at 40 °C for 1 h in water bath. After incubation, the tubes were centrifuged at 10,000g for 5 min and the absorbance of the clear supernatant was taken at 595 nm against the appropriate blank. One unit (U) of keratinolytic activity was defined as the increase in absorbance by 0.01 at 595 nm under the standard assay conditions27,28.
Optimization of keratinase production and feather degradation using response surface methodology (RSM)
The optimized process parameters for keratinase production (U/mL) and feather degradation (%) by OVAT were taken and four independent variables (A) Temperature (℃), (B) pH, (C) Substrate concentration (%) and (D) Inoculum size (%) were further optimized by Central Composite Design (CCD) using Design-Expert v13-Stat-Ease software. A plot of total 30 experiments based on the randomized factorial design consisted of five levels (− α, − 1, 0, + 1, + α) with four variables, and 6 replicate trials of central points. These experiments were performed to see the response pattern and to ascertain the optimum combination of factors. The response of the design was measured in terms of keratinase activity (U/mL) and feather degradation (%). The experimental data were fitted to a second-order polynomial equation through multiple regression analysis, and analysis of variance (ANOVA) indicated the competence of the model so obtained. Mutual interactions between the independent variables were characterized by three-dimensional response surface plots29.
Time course profile of keratin degradation
Time-dependent study of feather keratin degradtion by B. velezensis NCIM 5802 was carried out for 96 h in 500 mL Erlenmeyer flasks under the optimized process conditions (3.5% inoculum, 0.625% substrate concentration at 40 °C and 200 rpm). Aliquots were withdrawn from the flasks at regular time intervals (12 h) and were tested for various parameters, such as, bacterial growth, keratinase activity (U/mL), residual substrate (%), protein concentration (µg/mL), amino acid content (µg/mL), pH, and soluble oligopeptides (µg/mL).
Growth pattern of NCIM 5802
During fermentation, the growth pattern of the bacterium was studied by measuring the increase in absorbance at 600 nm up to 96 h. All the experiments were performed in triplicates and the data represents average ± SD.
The soluble protein content in the fermentation medium, was measured by Bradford method with bovine serum albumin (BSA) as standard 30.
Amino acid content
Total amino acid content present in the feather hydrolysate was estimated using the ninhydrin method. In a nutshell, 30 μL of the hydrolysate and 150 μL of phosphate citrate buffer (pH 5.0) were mixed thoroughly, to which 3% ninhydrin solution was added (1:1) and the mixture was vortexed for 1 min and subjected to boiling for 15 min. Upon the development of color, the reaction was stopped by cooling the tubes on ice. Following this, solution of isopropanol and water (7:3) was added to the mixture and after vortexing the absorbance was measured at 570 nm with serine as standard31.
Soluble oligopeptides in the hydrolysate
To study the soluble oligopeptide content in the aliquots, the samples were centrifuged at 5000g for 10 min and the hydrolysates were passed through 10 kDa cut-off Amicon Ultra membrane (Merck Millipore, India). Later, the absorbance of the filtrate was measured at 230 nm29.
Feather weight loss
Biodegradation of substrate by NCIM 5802 during the course of fermentation was evaluated in terms of substrate weight loss (%). After fermentation, the feather residues were separated and collected from the culture supernatant by filtration. The collected residual feathers were then washed thoroughly and dried in a hot air oven at 100 °C for 48 h. Biodegradation of feathers was expressed as percentage weight loss with respect to the initial dry weight of the substrate (before and after incubation). The uninoculated flask with feathers was used as control for the assessment.
The keratinase enzyme produced by NCIM 5802 was analyzed by studying the effect of temperature and pH on the enzyme activity and stability. In addition, the effect of some metal ions, surfactants, inhibitors, and activators was also investigated.
Effect of pH and temperature on keratinase
To study the effect of pH, keratinase activity was performed by incubating the reaction mixture at different pH (4.0–11.0) for 1 h. Keratin azure (1% w/v) was dissolved in different buffers (0.05M) viz. citrate buffer (pH 4.0–5.5), phosphate buffer (pH 6.0–8.5), glycine–NaOH buffer (pH 9.0–10.0), and NaOH-potassium dihydrogen phosphate buffer (pH 11.0). The enzyme activity at different pH values was expressed in terms of relative activity (%). The effect of temperature on keratinase activity was studied by incubating the reaction mixture at different temperatures ranging from 30 to 90 °C in 0.05 M glycine–NaOH buffer (pH 10.0) with 1% (w/v) keratin azure as substrate32. The residual keratinase activity was expressed as the relative enzyme activity with respect to control.
Effect of pH and temperature on keratinase stability
To examine the pH stability, keratinase preparation was pre-incubated with an equal amount of different buffers viz. phosphate buffer (pH 6.0–8.5), glycine–NaOH buffer (pH 9.0–10.0), and NaOH-potassium dihydrogen buffer (pH 11.0), respectively, for 80 min at 60 °C. Aliquots were withdrawn at regular time intervals and the residual keratinase activity was estimated using keratin azure as substrate as described above. The thermostability of the enzyme was assessed by incubating the keratinase at different temperatures (60–90 °C) for 80 min at pH 10.0 (Glycine–NaOH buffer). Aliquots were withdrawn at regular intervals and the residual keratinase activity was determined. The relative enzyme activity was defined as the percentage of the ratio between the keratinase activity of the treated sample and the activity present in the untreated control against a suitable blank.
Effect of metal ions, detergents, solvents, activators, and inhibitors
To study the effect of metal ions on NCIM 5802 keratinase, the keratinase activity was investigated in the presence of monovalent (Na+ and K+) and divalent metal ions (Cu2+, Ca2+, Mg2+, Hg2+, Zn2+, Fe2+, Ag+, NH4+, Mn2+). The effect of some activators and inhibitors such as urea, EDTA (ethylenediaminetetraacetic acid), β-ME (β-mercaptoethanol) and PMSF (phenylmethanesulfonyl fluoride) was also tested. The influence of certain surfactants and solvents on keratinase was tested using Triton X-100, Tween 80, SDS (sodium dodecyl sulfate), ethanol, methanol, and glycerol (0.1, 0.5, 1, 2 and 5%). The enzyme was preincubated with metal ion, detergent, solvent, activator or inhibitor for 30 min at 28 °C and the residual relative activity (%) was calculated against the appropriate control.
Multi-scale sequential analysis of feather degradation
Surface topology of degraded feather
To study the structural changes occurring during feather hydrolysis, feather samples (collected at 12 h interval up to 96 h) from the culture were visualized using scanning electron microscope (SEM) as described earlier23. Samples were air-dried and sliced into small fragments before fixing on the sample holder. The sample holder stubs were exposed for 60 s to the Denton vacuum sputter coater for gold coating and were examined with FEI Nova NanoSEM 450 (FEI, USA) at 15 kV.
Fourier-transform infrared (FTIR) spectroscopic analysis
The presence of characteristic functional groups in the untreated and hydrolyzed feathers was ascertained by FTIR analysis33. The changes occurring in the functional groups of the keratin were observed in the feather samples. The FTIR spectra was obtained using an ALPHA II spectrometer, (Bruker) in the spectrum range 4000–500 cm−1 with 40 scans at a resolution of 4 cm−1.
Raman spectroscopic studies of keratinase treated feathers
To study keratinase mediated feather solubilization process, Raman spectra of the residual feather mass obtained after the fermentation process was studied. Samples of hydrolyzed feathers were taken at regular time intervals and were air-dried. The inVia confocal Raman spectroscope (Renishaw) was used to record the spectra of the samples placed on a glass slide and focused using a video camera through the Raman option at 785 nm with a maximum output of 250 mW and 100 µm size of the laser spot. To get the optimal Raman spectra, the scan was repeated 4 times in the spectrum ranging from 3000 to 500 cm−1 with 40 scans34. For comparison, the spectrum of the feathers collected from the uninoculated flask were used as control.
X-ray diffraction (XRD) analysis
The X-ray diffraction (XRD) pattern of both degraded chicken feathers and intact feathers was conducted using X-ray diffractometer (Bruker D8 ADVANCE, Germany). The crystallinity was observed by adjusting the monochromator diffraction beam coupled with a copper X-ray tube at 40 kV and 30 mA, while the diffraction spectra were signified by the 2θ angle35. The scattering angle (2θ) was from 6 to 26° at a scanning rate of 2° min−1. The crystallinity index (CrI) was calculated using the intensities of amorphous (Iam) as well as crystalline regions as given below:
where, the highest diffraction intensity at the highest peak was I002 (~ 21.2) and the lowest diffraction intensity between the major and secondary peaks was Iam (~ 14.0).
The average crystallite size of the native and degraded feather was determined using the Scherrer’s equation:
where DSE = crystallite size (Å), κ = Scherrer’s constant (0.9), λ = 1.5406 Å (wavelength of X-ray radiation), β = full width at half maximum (FWHM) of X-ray diffraction peaks and θ = Bragg’s angle (angle of diffraction) relating to the planes.
Amino acid profile of feather hydrolysates
The amino acids in the feather hydrolysate samples (collected periodically after 12 h of incubation over 96 h) were analyzed through Electrospray Ionization-Mass Spectrometry (ESI–MS). Mass spectra of the samples were recorded in using Xevo G2-S QTOF mass spectrometer in positive ion mode paired with a 2424 Evaporative Light Scattering (ELS) detector. Collision induced dissociation (CID) was caused by Helium and the generated data was assessed using MassLynx data analysis software (Version 4.1). Uninoculated sample was taken as control and standard amino acids were taken as a reference to assign the peaks of the experimental samples30.
NMR spectroscopic studies
NMR analysis of the feather hydrolysate was carried out to reveal the sequential changes brought about by the keratinase action on feathers. For this, samples were prepared in HPLC grade water and small amounts of deuterium oxide (D2O) and tetramethylsilane (TMS) were added for spin locking and internal reference, respectively. The 1H was decoupled with the SPINAL-64 1H decoupling sequence. 1H liquid state NMR experiment of feather hydrolysates was carried out using a liquid state NMR probe. The water suppression was done by pre-saturation method and the uninoculated medium was taken as a control for all the 1H NMR experiments in the liquid state36.
Semi-native SDS-PAGE was carried out using 12% (w/v) polyacrylamide gel as described earlier33 with slight modification. For keratinase zymography, 20 µL of appropriately diluted enzyme sample was loaded on the semi-denaturating gel containing soluble keratin (0.1% w/v). Electrophoresis of the gel was conducted for ~ 3 h at 90 V at 4 °C. Afterwards, the gel was removed and incubated at 40 °C for 24 h and the presence of keratinase was visualized by staining with Coomassie brilliant blue G-250. The active bands on the gel appeared as the zone of keratin hydrolysis.
Quality assurance and quality control
All the experimental methods and procedures mentioned were conducted as per the standard operating protocols and good laboratory practices. All the chemicals used were of analytical grade with the highest available purity and the machines used for analysis were calibrated. The experimental setup was carried out in triplicates and the results were expressed as mean ± SD.
Morphological and molecular identification of the isolate
Based on the distinct zone of hydrolysis on casein and keratin agar plates, a potent keratinolytic bacterium NCIM 5802 was selected for this study. The isolate degraded keratin (40.2%) and produced high titers of extracellular keratinase (22.3 U/mL) accompanied with the release of amino acids (203.05 μg/mL) and soluble protein content (62.2 μg/mL). The 16S rDNA (ON203026) of NCIM 5802 revealed that this isolate belonged to the genus Bacillus having the highest homology with B. velezensis (97.38% homology; accession number: OM074020) and B. tequilensis (97.34% homology; accession number: OM061696.1) (Supplementary Fig. S1). Staining followed by the microscopic observation confirmed it to be a gram-positive bacillus. The DNA G + C content (https://en.vectorbuilder.com/tool/gc-content-calculator.html) of the strain NCIM 5802 was found to be 55.14 mol%. The strain was deposited in the National Collection of Industrial Microorganisms (NCIM), Pune, India and has been assigned accession number NCIM 5802.
Production optimization of the process parameters for waste feather degradation
To attain the optimal response for maximizing keratinase production for feather degradation, four significant independent variables [X1: Temperature (℃), X2: pH, X3: Substrate conc. (%) and X4: Inoculum size (%)] were selected and two responses, R1: Keratinase activity (U/mL) and R2: Feather degradation (%) were generated. All the experiments were conducted in triplicate, and the obtained results represent average ± SD.
Response surface optimization of feather degradation and keratinase production
The four variables were analyzed using the central composite design (CCD) approach, and the corresponding percentage of substrate degradation and enzyme production (U/mL), along with the interactional relationship among the selected variables was observed in terms of coded values. The optimal values of the four independent variables obtained from the maximum polynomial model point were found to be 40 °C, 8.0, 0.625%, and 3.5% for temperature, pH, substrate concentration and inoculum size, respectively, with the predicted keratinase production and feather degradation values being 102.9 U/mL and 90.7%, respectively, while actual experimental values were different. In addition, 104.5, 100.9, 128.3, 110.5, 101.7 and 112.5 keratinase activity (U/mL) and 93.4, 100, 97.2, 94.3, 94.6 and 95.2% feather degradation data was observed in the run numbers 12, 13, 20, 23, 28 and 30, respectively (Supplementary Table S1). The obtained result at p = 0.0005 indicated that there is a statistically significant relationship between the studied variables and the measured response, namely enzyme production (U/mL) and substrate degradation (%). Additionally, the obtained value of the determination coefficient (R2 = 0.964), which is a measure of the fitting degree for the applied model, indicated that about 3.6% of the total variations in the measured response are not explained by the model. Figure 1 presents the interactive effects of independent variables for acquiring the maximum and optimal level of the studied responses, namely keratinase yield and substrate degradation as presented by three-dimensional (3D) surface and contour plots. The F-value of the model was 7.07 and 27.16 for keratinase production and residual keratin substrate, respectively with p-values less than 0.0500, indicating that the present model is significant and noteworthy. In this context, the current study revealed the high efficiency of NCIM 5802 keratinase in feather keratin degradation. Parametric optimization of feather degradation and keratinase production was successfully applied leading to 2.5 and 4.92-fold enhancement, respectively.
Time course profile of keratin degradation
Time course profile was studied for 96 h of cultivation to understand the relationship among growth curve of NCIM 5802 and keratinase production (U/mL), pH alteration, residual substrate concentration (%), protein concentration (μg/mL), amino acid (μg/mL), and oligopeptide production (μg/mL) under RSM optimized conditions (Fig. 2A). Keratinase production by NCIM 5802 reached highest (292.6 U/mL) after 96 h of fermentation in the late stationary phase of its growth. The residual feather was found to be 1.81% (w/v) accompanied with the increase in soluble protein (8398.5 μg/mL), oligopeptides (930.77 μg/mL), amino acids (1151.8 μg/mL) and a pH shift from 7.0 to 9.5.
Characterization of the NCIM 5802 keratinase
Effect of pH and temperature
The activity profile of the keratinase indicated that it exhibits a broad pH range with an optimal activity at 10.0 (Fig. 2B). The data presented in Fig. 2C shows the optimal temperature of the keratinase to be 60 °C; hence, the enzyme can be categorized as an alkali and thermo-stable keratinase. The results presented in Fig. 2B suggested that the enzyme was stable at pH 10. It retained more than 60% activity up till 60 min indicating its tolerance for alkaline pH. However, it lost about half of its activity at pH 11.0 in 30 min (49.43%). The data revealed that the keratinase had optimal activity at 60 °C and remained stable at 60 °C for up to 40 min (90.13%), while the half-life of keratinase at 80 °C was 60 min (Fig. 2C).
Effect of metal ions, detergents, solvents, surfactants, activators, and inhibitors
Among various metal ions, keratinase activity was positively influenced in the presence of Ca2+ (153.8%) and Mg2+ (211.8%) (Table 1). Metal ions such as Cu2+, K+, Na+, Hg2+, Zn2+, Fe2+, Ag+, NH4+ and Mn2+ were found to be inhibitory.
Also, decrease in the activity of NCIM 5802 keratinase was noticed upon treatment with EDTA (metallo-protease inhibitor), urea, β-mercaptoethanol (reducing agent), and PMSF (serine protease inhibitor). The keratinolytic protein was severely inhibited in the presence of PMSF (residual activity: 5.28%). EDTA, Urea and β-ME had inhibitory effects on NCIM 5802 keratinase, causing the loss of the enzyme activity by 47.3–71.1%. Treatment of the keratinase with surfactants (Triton X 100, Tween 80, SDS) and organic solvents also revealed their inhibitory effect (Table 1).
Multi-scale characterization of degraded feathers and feather hydrolysate
Structural changes: profiling the feather degradation
Microstructural and topological changes in the feather keratin before and after bacterial degradation were investigated by scanning electron microscopy (SEM). Distinct stages of disintegration and biodegradation of chicken feather due to keratinase action were noticed (Fig. 3). Uninoculated feathers retained the highly ordered form and crystalline structure with tiered branched assemblies of barbules, barbs, rachis and shaft whereas, the bacterial colonization on feather barbs and disintegration was clearly noticed in case of feathers inoculated with bacterial culture. Considerable fracturing, complete degradation of barbules, and invasion of bacterial cells towards the keratin fibrils was observed during 36–48 h (Fig. 3). Complete degradation of barbs and barbules was recorded after 84 h-96 h of incubation.
FTIR analysis of treated feathers
The FTIR spectra of the unhydrolyzed and hydrolyzed feather keratin revealed the presence of characteristic absorption peak assigned to CONH, i.e., peptide bonds. The enzyme treated feather exhibited a broad absorption band for Amide A which is related to the secondary structure of feather (3250–3400 cm−1) linked to O–H and N–H stretching, Amide I (1600–1700 cm−1) showed an intense band for the α-helical structure corresponding to C=O stretching vibration, Amide II (1480–1580 cm−1) marked the presence of C−N and N−H stretching (Fig. 4A). Presence of α-helical and β-sheet conformation in feather keratin (1570–1720 cm−1) and the broad transmission band in the range of 1220–1300 cm−1 were accredited to C=O, N–H bending, and C–N stretching in-phase combination, respectively, which are identified as Amide III. Furthermore, the presence of an intense, sharp band at 600–1000 cm−1 indicated the integrity of the disulfide bonds. Additionally, the presence of a weak intensity peak at 1024 cm−1 in the hydrolyzed feather indicated the symmetric S=O stretching of the Bunte salt residues which were not observed in the unhydrolyzed feather sample.
Raman spectroscopic studies of the keratinase treated feathers
Chemical fingerprinting of native and treated chicken feathers was obtained using Raman spectroscopy. The graph presented in Fig. 4B, portrays these changes as a function of incubation time, where the spectral intensity of Amide I was observed at 1768 cm−1, Amide II at 1600–1700 cm−1, Amide III at 1400–1200 cm−1 corresponded to C–H stretching and S–S stretching vibration at 600 cm−1 is linked with cystine residues. The vibration of the thiol inorganic anion associated with S–H stretching vibration is related to cysteine (–S–SH or –S–S–SH) at 2600–2700 cm−1. The spectral peak of Amide I suggested that the degraded keratin remained largely in the β-sheet conformation whereas, the Amide III component suggested the presence of random coil and β-sheet conformation of the protein.
X-ray diffraction (XRD) analysis of hydrolyzed feather keratin
XRD analysis was performed to examine the crystal structures at various stages of chicken feather degradation during the course of fermentation. Figure 5 shows the XRD pattern of the native and treated chicken feathers at different time intervals. The diffraction peak at 2θ of about 9.0° corresponding to the α-helical conformation, and the peaks at 16.0° and 21.0°, indexed as the crystalline structure of antiparallel-pleated sheet, were observed for the raw feather (at 0 h). In comparison to raw keratin, the intensity of the broader peaks decreased remarkably in the hydrolyzed feathers, and several peaks emerged in the subsequent duration of fermentation that could be attributed to the amorphous structure of feather keratin. The CrI of treated feathers after successive incubation (37.4% and 48.24%) was higher than the CrI of untreated feathers (30.19%) (Fig. 5). Hence, the CrI of treated feathers after 96 h of incubation was 18.05% higher than the raw unhydrolyzed feather. Relative CrI (CrI/keratin) of keratin polymer after 96 h incubation was found to decrease in the treated feathers (0.63) as compared to raw keratin (1.0). Consistent with these results, the crystallite sizes (DSE) of the native and treated chicken feathers were calculated. The major diffraction peaks at 2θ = ~ 16, 21, and 22° were employed in samples of hydrolyzed and unhydrolyzed feathers for the evaluation of crystallite sizes. Raw unhydrolyzed keratin showed the DSE of about 11.7 nm and hydrolyzed feather after 96 h of incubation showed the highest DSE about 30.4 nm.
Amino acid profile of the feather hydrolysate
Amino acid content in the feather hydrolysate i.e., the cell-free culture supernatant withdrawn at regular time intervals up to 96 h of incubation, is given in Table 2. It shows the types of amino acid profiles noticed at different time periods. Moreover, the presence of particular amino acids at different time intervals was also monitored e.g., after 12 h of incubation, arginine, serine, and threonine were observed. Along with these proline, valine, leucine, isoleucine, and asparagine were detected after 24 h of incubation. Afterwards, at the completion of 36 h incubation time histidine, phenylalanine, methionine, lysine, cysteine and tyrosine were observed, whereas after 48 h aspartate, glutamine, glutamate and tryptophan were noticed. Additionally, at 72 h alanine was released in the feather digest. After the completion of incubation period i.e., at 96 h about 18 free amino acids were detected in the feather hydrolysate.
NMR spectroscopic studies: generation of amino acids from polymeric substrate
The 1H NMR spectra of the feather hydrolysates showing presence of various amino acids is presented in Fig. 6. The absorption spectral peak at 1.3 ppm indicated the presence of threonine (Thr), while those at 3.2 ppm and 3.5 ppm were attributed to cystine (CH2–S–S), arginine (Arg) and cysteine (CH2–S–H, Cys). Peaks at 1.5 ppm, 4.0 ppm, 4.8 ppm and 7.0 ppm were assigned to alanine (Ala), serine (Ser), lysine (Lys) and tyrosine (Tyr), respectively. Also, the broad peak at 4.6 ppm was assigned to phenylalanine (Phe). Thus, the 1H NMR of liquid hydrolysate confirmed the release of amino acids indicating the depolymerization of feather keratin by B. velezensis NCIM 5802.
Zymographic profile of the feather hydrolysate
The bacterium was observed to produce the active keratinases after 24 h of fermentation time (Fig. 7) as no keratinase activity was detected after the 12 h of incubation whereas, the presence of four distinct keratinases (Mr ~ 100, 62.5, 36.5, and 25 kDa) was noticed indicating secretion of multiple keratin hydrolyzing enzymes by B. velezensis.
Recent advancements in biomass valorization research suggest that apart from lignocellulose and chitin, keratin will also play a major role in bioeconomy20,37. Feather keratin, in particular, consists mainly of β-pleated sheets and due to its recalcitrant nature, robust enzymes of fungal or bacterial origin are needed for its degradation37. Fungal keratin degradation process appears to be relatively slow while some bacterial species including B. licheniformis RG138, Fervidobacterium pennavorans39, Fervidobacterium islandicum AW-140, Meiothermus taiwanensis WR-223041 and Bacillus cereus IIPK3529 are known to produce high titers of keratinases in about 30–120 h. In the present study, B. velezensis NCIM 5802 was found to produce keratinase and degrade feather keratin completely in 84–96 h of fermentation. B. velezensis NCIM 5802 efficiently degraded chicken feathers and the keratinase activity reached to highest level in 96 h of fermentation.
Hossain et al.42 reported that in the absence of any redox reaction, about 10–20% of feathers are degraded solely by bacterial keratinases. Keratinases derived from B. licheniformis ER-15, Bacillus paralicheniformis MKU3 and B. cereus IIPK35 degraded around 90% of the feather keratin29,43,44. In the present study, newly isolated B. velezensis NCIM 5802 degraded feathers completely (~ 99.1%) into amino acids and soluble proteins. In order to achieve dual targets of effective feather degradation and maximum keratinase production, the parametric optimization of both the processes was achieved through statistical optimization using CCD. The optimal conditions (40 °C, pH 8.0, substrate load 0.625% and inoculum size 3.5%) were validated resulting in the enhancement of both, feather degradation and keratinase production by 2.5 and 4.92-folds, respectively. These results are in agreement with those obtained by Kshetri et al.10, obtaining 84% of feather degradation along with the increased production of soluble peptides after statistical optimization. After optimization of process parameters Jana et al.29 achieved five fold enhanced titers of keratinase.
A follow-up of the time course of bacterial growth on feathers showed a pH shift from neutral to alkaline (7.0–9.5). Peng et al.45 have suggested that alkaline environment or a reducing agent is required for the breaking of the disulfide bonds, and as keratin degradation is a complex process, it requires a combination of enzymes mainly, disulfide reductase, cysteine dioxygenase (EC 188.8.131.52), glutathione reductase (EC 184.108.40.206), thioredoxin reductase (EC 220.127.116.11) for efficient degradation of feathers26,45,46. Simultaneous to the enzymatic degradation of the feathers, corresponding increase in the soluble protein (8398.5 μg/mL), amino acid (1151.8 μg/mL), and oligopeptide (930.77 μg/mL) content was noticed after 84–96 h of fermentation.
The keratinase activity profile signifies a broad pH working range (7.0–11.0) with an optimum at 10.0. The keratinase was active in the temperature range of 30 to 90 °C with optimal activity at 60 °C. These cardinal values are in agreement with earlier reports showing that the optimal pH value of alkaline keratinase is close to 10.047,48,49,50 (Table 3). Similarly, several researchers have reported the optimal functioning of the Bacillus keratinases (Table 3) in the range of 60–65°C25,51.
The keratinase retained more than 60% activity at pH 10.0 after 1 h, indicating its alkali stable nature. In this context, Bacillus subtilis keratinase has been shown to be stable in the pH range of 10–1248,52. Being able to retain 80% activity at 60 °C, the keratinase was considered thermostable. Elevated temperatures are known to increase the rate of keratinolysis47. Our findings are in agreement with those reported for B. licheniformis ALW1 thermo and alkali stable keratinase25.
The NCIM 5802 keratinase activity was strongly inhibited by PMSF and EDTA indicating it being a metalo-serine protease. EDTA removes the metal ion through chelation, suggesting the requirement of metal ion(s) for the proficient enzyme catalysis28,53,54. Presence of Ca2+ and Mg2+ boosted the enzyme activity by 53.8% and 111.8%, respectively. This upsurge in the enzymatic activity in the presence of divalent metal ion(s) suggested that the active conformity of the enzyme is maintained by these cations, which in turn, contributes to the increased keratinolytic activity. As this enzyme belonged to the class of serine-proteases, Ca2+ may play an important role in the stabilization of the enzyme structure and function23,55,56. Our findings suggest that these metal ion(s) possess a functional role in the structural stabilization of the enzyme, meaning that studied metal ions ensure the proper binding of the enzyme–substrate complex at the active site. All other metal ions (K+, Na+, Zn2+, Fe2+, Cu2+, Mn2+) moderately inhibited the keratinase activity57. Likewise, Ag+, Hg2+ and NaN3 drastically decreased the keratinase activity, which implies that a cysteine residue in the free form is present at the active site of the enzyme57. Our findings are in agreement with several authors, who reported the inhibitory effect of such metal ions on the keratinase24,57,58.
On the other hand, reducing agents, non-ionic surfactants, and solvents were found to inhibit keratinase, which is in accordance with the findings reported earlier58,59,60. Literature suggests that non-ionic surfactants or solvents disintegrate the keratinase structure by partly solubilizing it61.
The sequential changes occurring during feather keratin hydrolysis were investigated through multiscale analyses. Scanning electron microscopy revealed bacterial adherence and colonization of the feathers and damage in the barbs, that marked the first step of degradation followed by the extensive fracturing and disintegration of barbs and barbules. Subsequently, the bacterial invasion, decomposition, and weakening of the most recalcitrant part of the feather i.e., rachis was observed. Afterwards, the final stage of keratinolysis resulted in the complete disintegration of the amorphous porous keratinous material. Among several studies employing bacteria for feather keratin degradation, the time course for the complete degradation of keratin varied from 1 to 6 days29,40,56,62. Shorter span of time is favorable for industrial applications and few reports, including the present study, demonstrate the efficient keratin hydrolysis within 24–96 h23,26. We have reported a process of keratin degradation with an efficiency exceeding 95% in 84 h.
To understand the dynamics of keratin biodegradation and structural changes in the keratin at molecular level, FTIR and Raman spectroscopic analyses were conducted where, the changes in the intensity and position of the bands are attributed to the conformational changes in the keratin structure. The spectral peak of Amide I and Amide II at 1600–1700 cm−1 and 1480–1580 cm−1 respectively, corresponds to the α-helical and β-sheet structure in feather keratin. In the hydrolyzed feather keratin, the peak intensity of β-sheet structure present in the initial phases was reduced with the time of incubation along with the shift in –NH stretching region signifying the potential degradation of the keratin fibers63. The degradation of sulfide-containing cysteine was more evident by the weak S=O bond at 1024 cm−1. The increase in the intensity of stretching vibrations at 560–600 cm−1 suggested that a significant amount of the -S–S- bonds in the protein have been cleaved indicating the weakening of the keratin structure. The microbial degradation of the keratin was more evident as the peak of the S–H (thiol) bond at 2400 cm−1 was intensified with the increase in the fermentation time. Changes in the secondary structure and reduction in disulfide bonds with thiol (S–H) formation with respect to cultivation time indicated the proteolytic and sulfitolytic prospects of the isolate, which is an indicator of efficient keratin hydrolysis34,36. The results of FTIR and Raman analysis complemented each other where, distinct changes in the vibrations of the hydrolyzed and unhydrolyzed feather keratin were noticed63,64.
The relative crystallinity index (CrI) is considered as one of the major attributes that affects the hydrolysis kinetics of keratin. Relative CrI of keratin (0.63) was found to decrease in the hydrolyzed feather keratin as compared to raw keratin (1.0) after 96 h incubation. High crystallinity index represents the tight packaging of β-pleated sheets in feather keratin whereas, the reduction in relative crystallinity index of hydrolyzed feather keratin along with the increase in the crystallite size with the incubation time indicates the breakdown of disulfide bonds thus, successful keratin hydrolysis35,65. Crystallinity of the macromolecule plays an important role in maintaining the integrity, stability, providing strength to the keratin and resistance to proteolysis66,67.
Furthermore, the present report of biodegradation and enzymatic conversion of feathers into value-added by-products is purely an enzymatic process that is not only simple and streamlined but also inexpensive, in which no additional chemicals are supplemented to aid the feather degradation. The amino acids present in feather hydrolysate were studied through ESI–MS and, about 18 free amino acids were detected (Table 2) in consort with the rare amino acids, including serine and proline, and sulfur-containing amino acids including methionine47,68. Likewise, the presence of amino acids in the hydrolysates was also investigated through 1H NMR spectroscopy, where a number of amino acids was detected with respect to the cultivation time. The result is in accordance with the findings reported by Barone and Schmidt36.
Additionally, to investigate the nature of the enzyme responsible for the keratin hydrolysis the keratinase activity was detected on the gel and four distinct bands (Mr ~ 100, 62.5, 36.5 and 25 kDa) of keratin hydrolysis were observed. Multiplicity of keratinases (six bands ranging from 17 to 122 kDa) has been reported from Bacillus sp.69 and our findings are in agreement with the earlier reports47,70. Bacterial keratinases are known to occur in wide range of molecular mass, e.g., 18 kDa in Streptomyces albidoflavus, while 240 kDa in Kocuria rosea. Keratin being a complex, recalcitrant molecule may require endoprotease, exoprotease, and oligopeptidase activities to work synergistically71. The present work suggested that the feather keratin can be transformed into usable products including, feather meal, amino acids, or protein concentrates by employing the keratinases derived from newly isolated B. velezensis.
The keratinolytic potential of the newly isolated B. velezensis NCIM 5802 producing thermo-alkali-stable keratinase consortia was evaluated. It effectively degraded the feather keratin with an efficiency of 99.1% along with the production of soluble protein (8398.5 μg/mL), amino acids (1151.8 μg/mL) and oligopeptides (930.77 μg/mL) in 96 h. The extracellular keratinase preparation was found to be a serine-metallo protease showing optimal activity at 60 °C and pH 10.0. The biodegradation of feather keratin was mediated by multiple keratinases as revealed by the zymography. Multi-scale spectroscopic analysis of treated feathers using FTIR, Raman, XRD and NMR revealed the sequential degradation of β-sheets and α-helices along with disulfide bonds. The results presented in this paper provide new insights into the feather keratin degradation and potential of B. velezensis NCIM 5802 in poultry waste valorization for animal feed production and effective management of keratin waste.
The 16S rRNA sequences of Bacillus sp. NCIM 5802 were submitted to the NCBI accession number ON203026 (https://submit.ncbi.nlm.nih.gov/subs/?search=SUB11319989) and the bacterial culture is submitted to NCIM accession number NCIM-5802 (https://www.ncl-india.org/files/ncim/CatalogueDetails.aspx?NCIMNo=5802). The authors declare that all data supporting the findings of this study are available within the article.
Feather meal minimal salt agar
Response surface methodology
Central composite design
Analysis of variance
Bovine serum albumin
Sodium dodecyl sulfate
Electrospray ionization–mass spectrometry
Collision induced dissociation
Evaporative dissociation light scattering
Scanning electron microscope
Fourier transform infrared spectroscopy
Nuclear magnetic resonance
X-ray powder diffraction
Wang, B., Yang, W., McKittrick, J. & Meyers, M. A. Keratin: Structure, mechanical properties, occurrence in biological organisms, and efforts at bioinspiration. Prog. Mater. Sci. 76, 229–318 (2016).
Thankaswamy, S. R., Sundaramoorthy, S., Palanivel, S. & Ramudu, K. N. Improved microbial degradation of animal hair waste from leather industry using Brevibacterium luteolum (MTCC 5982). J. Clean. Prod. 189, 701–708 (2018).
Akhter, M., Wal Marzan, L., Akter, Y. & Shimizu, K. Microbial bioremediation of feather waste for keratinase production: an outstanding solution for leather dehairing in tanneries. Microbiol. Insights. 13, 1178636120913280 (2020).
Jagadeesan, Y., Meenakshisundaram, S., Saravanan, V. & Balaiah, A. Sustainable production, biochemical and molecular characterization of thermo-and-solvent stable alkaline serine keratinase from novel Bacillus pumilus AR57 for promising poultry solid waste management. Int. J. Biol. Macromol. 163, 135–146 (2020).
Peng, Z. et al. Engineered pro-peptide enhances the catalytic activity of keratinase to improve the conversion ability of feather waste. Biotechnol. Bioeng. 118, 2559–2571 (2021).
Emran, M. A., Ismail, S. A. & Abdel-Fattah, A. M. Valorization of feather via the microbial production of multi-applicable keratinolytic enzyme. Biocatal. Agric. Biotechnol. 27, 101674 (2020).
Mousa, A., Moubayed, N., Jaloud, A., Khattaf, F. & Dahmasha, N. Chicken feathers waste management by microbial as a sustainable and tool environmental friendly. J. Environ. Prot. Sci. 12, 639–653 (2021).
Papadopoulos, M. C., El Boushy, A. R., Roodbeen, A. E. & Ketelaars, E. H. Effects of processing time and moisture content on amino acid composition and nitrogen characteristics of feather meal. Anim. Feed Sci. Technol. 14(3), 279–290 (1986).9.
Tiwary, E. & Gupta, R. Rapid conversion of chicken feather to feather meal using dimeric keratinase from Bacillus licheniformis ER-15. J. Bioprocess Biotech. 2(4), 1–5 (2012).
Kshetri, P., Roy, S. S., Sharma, S. K, Singh, T. S., Ansari, M.A., Prakash, N. & Ngachan, S. V. Transforming chicken feather waste into feather protein hydrolysate using a newly isolated multifaceted keratinolytic bacterium Chryseobacterium sediminis RCM-SSR-7. Waste Biomass Valori. 10, 1–11 (2019).
Tallentire, C. W., Mackenzie, S. G. & Kyriazakis, I. Can novel ingredients replace soybeans and reduce the environmental burdens of European livestock systems in the future. J. Clean. Prod. 187, 338–347 (2018).
Venkatachalam, M., Rathinam, A., Rao, J. R. & Krishnan, C. Bioconversion of animal hair waste using salt-and sulphide-tolerant Bacillus sp. KLP1 and depilation using keratinase. Int. J. Environ. Sci. Technol. (2021).
Kshetri, P., Roy, S. S., Chanu, S. B., Singh, T. S., Tamreihao, K., Sharma, S. K., Ansari, M. A. & Prakash, N. Valorization of chicken feather waste into bioactive keratin hydrolysate by a newly purified keratinase from Bacillus sp. RCM-SSR-102. J. Environ. Manage. 273, 111195 (2020).
Gupta, R. & Ramnani, P. Microbial keratinases, and their prospective applications: An overview. Appl. Microbiol. Biotechnol. 70(1), 21–33 (2006).
Nnolim, N. E., Udenigwe, C. C., Okoh, A. I. & Nwodo, U. U. Microbial keratinase: Next generation green catalyst and prospective applications. Front. Microbiol. 11, 3280 (2020).
Lin, X., Kelemen, D. W., Miller, E. S. & Shih, J. C. Nucleotide sequence and expression of kerA, the gene encoding a keratinolytic protease of Bacillus licheniformis PWD-1. Appl. Environ. Microbiol. 61(4), 1469–1474 (1995).
Brandelli, A., Daroit, D. J. & Riffel, A. Biochemical features of microbial keratinases and their production and applications. Appl. Microbiol. Biotechnol. 85(6), 1735–1750 (2010).
Gegeckas, A., Gudiukaitė, R., Debski, J. & Citavicius, D. Keratinous waste decomposition and peptide production by keratinase from Geobacillus stearothermophilus AD-11. Int. J. Biol. Macromol. 75, 158–165 (2015).
Huang, Y., Busk, P. K., Herbst, F. A. & Lange, L. Genome and secretome analyses provide insights into keratin decomposition by novel proteases from the non-pathogenic fungus Onygena corvina. Appl. Microbiol. Biotechnol. 99(22), 9635–9649 (2015).
Srivastava, B., Khatri, M., Singh, G. & Arya, S. K. Microbial keratinases: an overview of biochemical characterization and its eco-friendly approach for industrial applications. J. Clean. Prod. 252, 119847 (2020).
Nnolim, N. E. & Nwodo, U. U. Microbial keratinase and 550 the bioeconomy: A three-decade meta-analysis of research exploit. AMB Express 11, 12 (2021).
Matikeviciene, V., Masiliuniene, D. & Grigiskis, S. Degradation of keratin containing wastes by bacteria with keratinolytic activity. In Proceedings of the 7th International Scientific and Practical Conference, vol. 1, 284–289 (2009).
Sharma, I. & Kango, N. Production and characterization of keratinase by Ochrobactrum intermedium for feather keratin utilization. Int. J. Biol. Macromol. 166, 1046–1056 (2021).
Ramakrishna Reddy, M., Sathi Reddy, K., Y., Chouhan, R., Bee, H. & Reddy, G. Effective feather degradation and keratinase production by Bacillus pumilus GRK for its application as bio-detergent additive. Bioresour. Technol. 243, 254–263 (2017).
Abdel-Fattah, A. M., El-Gamal, M. S., Ismail, S. A., Emran, M. A. & Hashem, A. M. Biodegradation of feather waste by keratinase produced from newly isolated Bacillus licheniformis ALW1. J. Genet. Eng. Biotechnol. 16, 311–318 (2018).
Navone, L. & Speight, R. Understanding the dynamics of keratin weakening and hydrolysis by proteases. PLoS ONE. 13 (2018).
Bouacem, K., Bouanane-Darenfed, A., Jaouadi, N. Z., Joseph, Hacene, M. H., Ollivier, B., Fardeau, Bejar, M. L., & Jaouadi, S. B. Novel serine keratinase from Caldicoprobacter algeriensis exhibiting outstanding hide dehairing abilities. Int. J. Biol. Macromol. 86, 321–328 (2016).
Verma, A., Singh, H., Anwar, S. A., Chattopadhyay, K. K., Tiwari, S. & Kaur Dhilon, G. S. Microbial keratinases: industrial enzymes with waste management potential. Crit. Rev. Biotechnol. 37, 476–491 (2017).
Jana, A. et al. Keratinase biosynthesis from waste poultry feathers for proteinaceous stain removal. ACS Sustain. Chem. Eng. 8, 17651–17663 (2020).
Jaouadi, N. Z. et al. A novel keratinase from Bacillus tequilensis strain Q7 with promising potential for the leather bating process. Int. J. Biol. Macromol. 79, 952–964 (2015).
Jin, H. S. et al. Development of a keratinase activity assay using recombinant chicken feather keratin substrates. PLoS ONE 2, e0172712 (2017).
Barman, N. C., Zohora, F.T., Das, K.C., Mowla, M. G., Banu, N. A., Salimullah, M. & Hashem, A. Production, partial optimization, and characterization of keratinase enzyme by Arthrobacter sp. NFH5 isolated from soil samples. AMB Express. 7, 181 (2017).
Gurunathan, R., Huang, B., Ponnusamy, V. K., Hwang, J. S. & Dahms, H. U. Novel recombinant keratin degrading subtilisin like serine alkaline protease from Bacillus cereus isolated from marine hydrothermal vent crabs. Sci. Rep. 11, 12007 (2021).
Poole, A. J., Lyons, R. E. & Church, J. S. Dissolving feather keratin using sodium sulfide for bio-polymer applications. J. Polym. Environ. 19, 995–1004 (2011).
Tesfaye, T., Sithole, B., Ramjugernath, D. & Chunilall, V. Valorisation of chicken feathers: Characterisation of chemical properties. Waste Manage. 66, 626–635 (2017).
Barone, J. R. & Schmidt, W. F. Effect of formic acid exposure on keratin fiber derived from poultry feather biomass. Bioresour. Technol. 97, 233–242 (2006).
Li, Q. Structure, application, and biochemistry of microbial keratinases. Front. Microbiol. 12, 674345 (2021).
Priya, R., Rajni, S. & Rani, G. Keratinolytic potential of Bacillus licheniformis RG1: structural and biochemical mechanism of feather degradation. Can. J. Microbiol. 51, 191–196 (2005).
Friedrich, A. B. & Antranikian, G. Keratin degradation by Fervidobacterium pennavorans, a novel thermophilic anaerobic species of the order Thermotogales. Appl. Environ. Microb. 62, 2875–2882 (1996).
Nam, G. W. et al. Native-feather degradation Native-feather degradation by Fervidobacterium islandicum AW-1, a newly isolated keratinase-producing thermophilic anaerobe. Arch. Microbiol. 178, 538–547 (2002).
Wu, W. L. et al. The discovery of novel heat-stable keratinases from Meiothermus taiwanensis WR-220 and other extremophiles. Sci. Rep. 7, 4658–4658 (2017).
Hossain, M. S., Azad, A. K., Abu Sayem, S. M., Mostafa, G. & Hoq, M. M. Production, and partial characterization of feather degrading keratinolytic serine protease from Bacillus licheniformis MZK-3. J. Biol. Sci. 7, 599–606 (2007).
Tiwary, E. & Gupta, R. Medium optimization for a novel 58kDa dimeric keratinase from Bacillus licheniformis ER-15: Biochemical characterization and application in feather degradation and dehairing of hides. Bioresour. Technol. 101, 6103–6110 (2010).
Kalaikumari, S. S., Vennila, T., Monika, V., Chandra Raj, K., Gunasekaran, P. & Rajendhran, J. Bioutilization of poultry feather for keratinase production and its application in leather industry. J. Clean. Prod. 208, 44–53 (2019).
Peng, Z., Zhang, J., Du, G. & Chen, J. Keratin waste recycling based on microbial degradation: Mechanisms and prospects. ACS Sustain. Chem. Eng. 7, 9727–9736 (2019).
Qiu, J., Wilkens, C., Barrett, K. & Meyer, A. S. Microbial enzymes catalyzing keratin degradation: Classification, structure, function. Biotechnol. Adv. 44, 107607 (2020).
Goda, D. A., Bassiouny, A. R., Abdel Monem, N. M., Soliman, N. A. & Abdel-Fattah, Y. R. Feather protein lysate optimization and feather meal formation using YNDH protease with keratinolytic activity afterward enzyme partial purification and characterization. Sci. Rep. 11, 14543 (2021).
Genckal, H. & Tari, C. Alkaline protease production from alkalophilic Bacillus sp. isolated from natural habitats. Enzym. Microb. Technol. 39, 703–710 (2006).
Patel, R. K., Dodia, M. S., Joshi, R. H. & Singh, S. P. Purification, and characterization of alkaline protease from a newly isolated haloalkaliphilic Bacillus sp. Process Biochem. 41, 2002–2009 (2006).
Doddapaneni, K. K. et al. Purification and characterization of a solvent and detergent-stable novel protease from Bacillus cereus. Microbiol. Res. 164, 383–390 (2009).
Mazotto, A. M. et al. Biodegradation of feather waste by extracellular keratinases and gelatinases from Bacillus spp. World J. Microbiol. Biotechnol. 27, 1355–1365 (2011).
Joo, H. S., Kumar, C. G., Park, G. C., Paik, S. R. & Chang, C. S. Oxidant and SDS-stable alkaline protease from Bacillus clausii I-52: Production and some properties. J. Appl. Microbiol. 95, 267–272 (2003).
Riessen, S. & Antranikian, G. Isolation of Thermoanaerobacter keratinophilus sp. nov., a novel thermophilic, anaerobic bacterium with keratinolytic activity. Extremophile. 5, 399–408 (2001).
Rai, S. K., Konwarh, R. & Mukherjee, A. K. Purification, characterization, and biotechnological application of an alkaline β-keratinase produced by Bacillus subtilis RM-01 in solid-state fermentation using chicken-feather as substrate. Biochem. Eng. J. 45, 218–225 (2009).
Anitha, T. S. & Palanivelu, P. Purification and characterization of an extracellular keratinolytic protease from a new isolate of Aspergillus parasiticus. Protein Expr. Purif. 88, 214–220 (2013).
Sana, B., Ghosh, D., Saha, M. & Mukherjee, J. Purification and characterization of a salt, solvent, detergent, and bleach tolerant protease from a new gamma-Proteobacterium isolated from the marine environment of the Sundarbans. Process Biochem. 41, 208–215 (2006).
Gupta, R. & Ramnani, P. Microbial keratinases and their prospective applications: A overview. Appl. Microbiol. Biotechnol. 70, 21–33 (2006).
Sanghvi, G. et al. A novel alkaline keratinase from Bacillus subtilis DP1 with potential utility in cosmetic formulation. Int. J. Biol. Macromol. 87, 256–262 (2016).
Zhang, R. X., Gong, J. S., Zhang, D. D., Su, C., Hou, Y. S., Li, H., Shi, J. S. & Xu, Z. H. A metallokeratinase from a newly isolated Acinetobacter sp. R-1 with low collagenase activity and its biotechnological application potential in leather industry. Bioprocess Biosyst. Eng. 39, 193–204 (2016).
Paul, T. et al. Biochemical and structural characterization of a detergent stable alkaline serine keratinase from Paenibacillus woosongensis TKB2: a potential additive for laundry detergent. Waste Biomass Valori. 5, 563–574 (2013).
De Oliveira Martinez, J. P. et al. Challenges, and opportunities in identifying and characterising keratinases for value-added peptide production. Catalysts 10, 184 (2020).
Laba, W., Choinska, A., Rodziewicz, A. & Piegza, M. Keratinolytic abilities of Micrococcus luteus from poultry waste. Braz. J. Microbiol. 46, 691–700 (2015).
Eslahi, N., Dadashian, F. & Nejad, N. H. An investigation on keratin extraction from wool and feather waste by enzymatic hydrolysis. Prep. Biochem. Biotechnol. 43, 624–648 (2013).
Paul, T. et al. Valorization of chicken feather waste for concomitant production of Keratinase, Oligopeptides and essential amino acids under submerged fermentation by Paenibacillus woosongensis TKB2. Waste Biomass Valori. 5, 575–584 (2014).
Idris, A., Vijayaraghavan, R., Patti, A. & MacFarlane, D. Distillable protic ionic liquids for keratin dissolution and recovery. ACS Sustain. Chem. Eng. 2, 1888–1894 (2014).
Xu, W., Ke, G., Wu, J. & Wang, X. Modification of wool fibre using steam explosion. Eur. Polymer J. 42, 2168–2173 (2006).
Zhao, W., Yang, R., Zhang, Y. & Wu, L. Sustainable and practical utilisation of feather keratin by an innovative physicochemical pre-treatment: high-density steam flash-explosion. Green Chem. 14, 3352–3360 (2012).
Huang, Y., Liu, X., Ran, Y., Cao, Q., Zhang, A. & Li, D. Production of feather oligopeptides by a newly isolated bacterium Pseudomonas otitis H11. Poult. Sci. (2019).
Rahayu, S., Syah, D. & Suhartono, M. T. Degradation of keratin by keratinase and disulfide reductase from Bacillus sp MTS of Indonesian origin. Biocatal. Biotransfor. 1(2), 152–158 (2012).
Rai, S. K. & Mukherjee, A. K. Statistical optimization of production, purification and industrial application of a laundry detergent and organic solvent-stable subtilisin-like serine protease (Alzwiprase) from Bacillus subtilis DM-04. Biochem. Eng. J. 48(2), 173–180 (2010).
Lange, L., Huang, Y. & Busk, P. K. Microbial decomposition of keratin in nature—a new hypothesis of industrial relevance. Appl. Microbiol. Biotechnol. 100, 2083–2096 (2016).
Author IS is thankful to Department of Science and Technology (DST-INSPIRE), New Delhi, Govt. of India, for providing financial assistance as Junior Research Fellow. Authors are grateful to Sophisticated Instrumentation Centre (SIC), Dr. Harisingh Gour Vishwavidyalaya, Sagar and DST PURSE (II) program for instrumentation facilities.
The authors declare no competing interests.
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Sharma, I., Pranaw, K., Soni, H. et al. Parametrically optimized feather degradation by Bacillus velezensis NCIM 5802 and delineation of keratin hydrolysis by multi-scale analysis for poultry waste management. Sci Rep 12, 17118 (2022). https://doi.org/10.1038/s41598-022-21351-9
This article is cited by
Synthesis and characterization of keratinase laden green synthesized silver nanoparticles for valorization of feather keratin
Scientific Reports (2023)
Bioconversion of chicken feather waste into feather hydrolysate by multifaceted keratinolytic Bacillus tropicus LS27 and new insights into its antioxidant and plant growth-promoting properties
Biomass Conversion and Biorefinery (2023)