Current cartilage regenerative therapies are not fully effective in treating osteoarthritis of the knee (OAK). We have developed chondrocyte sheets for autologous transplantation and tested these in in vitro and in vivo preclinical studies, and have reported that the transplantation of chondrocyte sheets promoted hyaline cartilage repair in rat, rabbit, and minipig models. However, autologous transplantation of chondrocyte sheets has yet to be reported in humans. Here, we report our combination therapy in which conventional surgical treatment for OAK, is followed by autologous chondrocyte sheet transplantation for cartilage repair. Eight patients with OAK and cartilage defects categorized arthroscopically as Outerbridge grade III or IV receive the therapy. Patients are thoroughly assessed by preoperative and postoperative X-rays, magnetic resonance imaging (MRI), arthroscopy, Knee injury and Osteoarthritis Outcome Score (KOOS), Lysholm Knee Score (LKS), and a laser-induced photoacoustic method to assess cartilage viscoelasticity. Arthroscopic biopsies of all patients are performed 12 months after transplantation for histological evaluation. The properties of the chondrocyte sheets are evaluated using gene expression analysis to investigate the ability to predict the clinical and structural outcomes of the therapy. For this small initial longitudinal series, combination therapy is effective, as assessed by MRI, arthroscopy, viscoelasticity, histology, and the clinical outcomes of KOOS and LKS. Gene marker sets identified in autologous chondrocyte sheets may be predictive of the overall KOOS, LKS, and histological scores after therapy. These predictive gene sets may be potential alternative markers for evaluating OAK treatment.
Articular cartilage is a matrix-rich, hypocellular, and vasculature-free structure that functions as a lubricating and load-bearing surface in the joints. Injury to cartilage often progresses spatiotemporally from the articular surface to the subchondral bone and leads to the development of degenerative joint diseases such as osteoarthritis (OA).1 OA is the most common cause of mobility loss that adversely affects quality of life, work productivity, and cost of health care, and is the most prevalent form of musculoskeletal disease worldwide.2,3 No cure or proven interventions are known to stop OA progression. Since 1997, four representative autologous chondrocyte implantation products have been approved in the United States, the European Union, and Japan.4 However, the adaptation of such therapies to cartilaginous defects caused by osteoarthritis of the knee (OAK) might prove difficult because cartilage defects in OAK are variable and changes are associated with female sex, age, and body mass index. Increases of defects are associated with baseline cartilage volume, bone size, and osteophytes, which suggests that these factors play a role in the pathogenesis of cartilage defects.5
OA is a heterogeneous disease characterized by variable clinical features, biochemical and genetic characteristics, and responses to treatments.6 If a control group is used for a comparative study, it always includes individuals with heterogeneous conditions. OAK-related cartilage defects develop over many years and often require multiple therapies to treat coexisting pathological conditions such as malalignment and ligamentous and meniscal disorders. Therefore, complying with regulations that require clear evidence of the add-on effect of each treatment makes the development of new therapies particularly challenging.
Cell-sheet technology has been successfully implemented in clinical research for the regeneration of tissues such as the cornea,7 myocardium,8 and esophagus.9 We were the first to report its applicability in articular cartilage repair with the development of layered chondrocyte sheets.10,11 We have provided evidence from animal studies indicating the potential of layered chondrocyte sheets in the treatment of a partial defect in rabbit cartilage,10 and osteochondral defects in rat,12 rabbit,13,14 and minipig15 cartilage. These are the types of defects that are usually present in OAK. We have also investigated the mode of action of the layered chondrocyte sheets.11,16,17 To confirm the safety of the sheets, we have performed tumorigenicity studies as recommended by the World Health Organization,18,19 monitored genetic mutations and the emergence of abnormal chromosomes,19 and transplanted luciferase-expressing chondrocyte sheets and followed them for over 21 months to track their intra-articular localization.12 On the basis of these data, we received approval from the Ministry of Health, Labor and Welfare of Japan to conduct a clinical study targeting OAK.20
We wanted to challenge the nature of the current regulations by applying cell-sheet technology21,22 combined with conventional surgical treatments and rigorous follow-up procedures in the first human clinical study of regenerative medicine applied to OAK in Japan. We designed a combination therapy (Fig. 1a, b) in which conventional surgical treatment for OAK, covered by National Health Insurance, was followed by the removal of unhealthy tissue, marrow stimulation, and chondrocyte sheet transplantation (the RMSC method) to treat cartilage defects. The study was designed to evaluate the effectiveness of the total treatment but not the add-on effects of each treatment.
Ten patients with OAK were enrolled, and eight patients with accompanying cartilage defects received the therapy. A rigorous evaluation protocol (Fig. 1c) was designed to assess the endpoints of safety and efficacy of the therapy and to evaluate the clinical and structural outcomes. The properties of the transplanted chondrocyte sheets were also evaluated thoroughly using gene expression analysis to investigate their potential use for predicting the clinical and structural outcomes of the therapy. In this small initial longitudinal case series, we wanted to determine whether expression of specific marker gene sets in autologous transplanted chondrocyte sheets derived from each patient could be used to predict the outcomes of this new therapy for OAK.
Clinical outcomes of the combination therapy using RMSC method
The results of clinical examinations and outcomes for the eight patients who received the combination therapy are shown in Table 1. Data from three of eight patients who underwent the therapy are shown in Fig. 2. No serious adverse events related to the combined surgeries were observed during the treatment and follow-up period. There were 26 adverse events reported, including pain (eight patients), leukocytosis (eight patients), increased C-reactive protein level (eight patients), swelling (one patient), and fever (one patient). All adverse events were considered to have been related to the high tibial osteotomy or anterior cruciate ligament reconstruction concomitant with the transplantation of chondrocyte sheets. We believe that these were unlikely to have been related to the transplantation of chondrocyte sheets.
Scores for the individual subscales of the Knee injury and Osteoarthritis Outcome Score (KOOS) continued to improve up to 36 months postoperatively (Fig. 3b). The Lysholm Knee Score (LKS) continued to improve up to 24 months postoperatively and was maintained thereafter (Fig. 3c).
Structural outcomes of the regenerated cartilage
At 36 months postoperatively, MRI confirmed the regeneration of cartilage in areas that lacked cartilage preoperatively (Fig. 2a, b). The results of the magnetic resonance observation of cartilage repair tissue (MOCART) evaluation are shown in Table 2. Knee alignment was maintained 36 months postoperatively (Fig. 2c–e). Cartilage regeneration in the defect areas was confirmed by preoperative, intratransplantation, and postoperative arthroscopy (Fig. 2f–k).
The structural outcomes for the regenerated cartilage were evaluated rigorously. Preoperative arthroscopic images, laser-induced photoacoustic (LIPA) evaluation, and chondrocyte sheet transplantation of a representative patient are shown in Movie 1 in the Supplementary information. Postoperative arthroscopic images, LIPA evaluation, and biopsy of the regenerated cartilage in the same patient are shown in Movie 2 of the Supplementary information. For the LIPA evaluation, the viscoelastic characteristics of regenerated cartilage are represented as the ratios relative to those of normal cartilage in the same joint; these values were calculated to be 0.87–1.06 (Table 1).
Histological evaluations of all patient biopsies revealed strong staining for Safranin O and expression of type II collagen (COL2); samples from three patients showed type I collagen (COL1) expression in the superficial regions. Although the degree to which regeneration occurred varied between patients, these results suggest regeneration of hyaline cartilage (Fig. 3a and Table 1).
Predicting clinical and structural outcomes by analyzing cell sheets
The layered chondrocyte sheets can be handled using a circular white support membrane of polyvinylidene difluoride (PVDF) and appear as thin membranes that exhibit strong adhesive properties (Fig. 4a). The multilayered structure was confirmed by histological staining (Fig. 4b). Immunostaining showed that the sheets strongly expressed fibronectin (FN), COL1, and aggrecan (ACAN), and weakly expressed COL2 (Fig. 4c–f). The chondrocytes in the sheets were dedifferentiated and the properties of chondrocyte sheets were different from those of hyaline cartilage.
Almost all chondrocytes from these sheets were positive for CD81 and CD90. CD49a- and GD2-positive cells were present at a frequency of 20–30% and CD146-positive cells at a frequency of 10%. There were almost no CD31- and CD45-positive cells (Fig. 4g).
Quantitative polymerase chain reaction (qPCR) analysis of the genes expressed by the layered chondrocyte sheets revealed widespread expression of cartilage-related genes of interest, However, the expression levels of ACAN, SOX9, and COL2A1 decreased relative to GAPDH (Fig. 4h).
Predictive gene marker sets for postoperative clinical and structural outcomes were identified based on correlation coefficient analysis. The marker sets were as follows: for overall KOOS (Fig. 3d) ACAN, CSGALNACT1, BMP6, PTGS2, POU5F1, and CXCL6; for the LKS (Fig. 3e) GATA6, LECT1, GDF5, ADAMTS5, SP7, and MATN2; and for the Osteoarthritis Research Society International (OARSI) histological score (Fig. 3f) ACAN, BMP6, POU5F1, CXCL6, VEGFA, and PTGS2. Cronbach’s alpha coefficients of these data sets were 0.73 for KOOS, 0.93 for LKS, and 0.65 for OARSI.
OAK-related cartilage defects develop over many years and often require multiple therapies to treat coexisting pathological conditions such as malalignment and ligamentous and meniscal disorders. Therefore, complying with regulations that require clear evidence of the add-on effect of each treatment makes the development of new therapies particularly challenging. Here, we challenged the nature of these regulations by applying autologous chondrocyte transplantation combined with conventional surgical treatments and rigorous follow-up procedures in the first human clinical study of regenerative medicine applied to OAK in Japan. The properties of transplanted chondrocyte sheets were also evaluated thoroughly using gene expression analysis to investigate the possibility of predicting clinical and structural outcomes.
Our study has four limitations. First, the study included only eight patients, who presented with various preoperative conditions. Three patients with post-traumatic OA underwent anterior cruciate ligament (ACL) reconstruction, and five patients with general OA underwent open-wedge high tibial osteotomy (OWHTO). These associated surgeries may have affected the outcomes of the therapy. Second, we observed promising outcomes for the use of layered chondrocyte sheets over at least 3 years, but longer-term observations are needed to evaluate this new combination therapy fully. Third, we had to adopt a two-stage surgical approach, first to harvest healthy cartilage and synovium, and second to transplant the layered chondrocyte sheets. Although regenerative medicine is commonly performed using autologous cells, this requires the sacrifice of healthy cartilage at a nonloading site of the knee, which comprises a limited area. Therefore, it is difficult to perform this procedure more than twice. Finally, our clinical study was designed as a single-arm, nonrandomized, and uncontrolled study.
For this small initial longitudinal series, the combination therapy was effective as assessed by MRI, arthroscopy, histology, and the clinical outcomes assessed by the KOOS and LKS. The marker gene sets identified from autologous chondrocyte sheets may be effective predictors of the outcomes as measured by the overall KOOS, LKS, and OARSI histological scores, and may be potential alternative markers for evaluating OAK treatment. Determining the true effectiveness of this therapy for OAK will require long-term follow-up and strict comparative studies. A previous prospective clinical study by Wakitani et al.23 on bone marrow mesenchymal cell transplantation with a COL1 gel and periosteum patch combined with high tibial osteotomy for OAK. Although the clinical improvement did not differ significantly between the cell-transplanted and cell-free groups in that study, the arthroscopic and histological grading scores were better in the cell-transplanted group. These results show that it is very difficult to show an add-on effect of cell transplantation in OAK patients.
In this clinical study, we demonstrated evidence of hyaline cartilage repair after chondrocyte sheet transplantation in humans. A previous study by Sekiya et al.24 reporting the clinical outcomes of ten patients with knee cartilage defects treated using transplantation of synovial stem cells showed that most histological sections contained hyaline cartilage in the deep zone and fibrous tissue in the middle and surface zones. By contrast, we have previously reported that pain-alleviating effects and hyaline cartilage repair were achieved after transplantation of layered chondrocyte sheets but not after transplantation with synovial cells.12 These findings suggest that the humoral factors produced by layered chondrocyte sheets may contribute to cartilaginous tissue repair and regeneration.16 In the cases of these animal experiments, we always create the cartilage (osteochondral) defects to be 8 mm in diameter and at 5 mm in depth in minipigs, 5 mm in diameter and at 3 mm in depth in rabbits, and 2 mm in diameter and at 1 mm in depth in rats. We confirmed bleeding from the subchondral bone because of the thin cartilage in these animals. These conditions are considered to be marrow stimulating, as in a clinical procedure. Therefore, we have not needed to create additional holes at the sites of the defects.
This study was also designed as a feasibility study to overcome the conventional requirements of OAK treatment, to show the total effectiveness of the combined treatment, and to identify alternative markers of clinical endpoints, but not to identify the add-on effect of each treatment component. Because OAK is a heterogeneous disease characterized by variable clinical features, biochemical and genetic characteristics, and responses to treatments, control groups for comparative studies always include individuals with heterogeneous conditions. In this small initial longitudinal case series, we demonstrated that the expression of selected marker gene sets in autologous transplanted chondrocyte sheets derived from each patient may be effective predictors of the clinical and structural outcomes of this new therapy for OAK. To our knowledge, this is the first study to identify gene sets that may predict the clinical and structural outcomes of regenerative medicine. The chondrocytes contained in the sheets have dedifferentiated (Fig. 4c–f, h), but our previous data also showed that humeral factors secreted from the sheets may contribute to cartilage repair and regeneration.16,25
From our study results, we propose that our procedure using chondrocyte sheets has three potential advantages. First, for safety, we use only autologous cells without any foreign materials. Second, chondrocyte sheets generated using temperature-responsive culture inserts express FN strongly and have excellent adhesive properties, meaning that the periosteum is not required. Third, several types of animal experiments have demonstrated that hyaline cartilage repair may be possible using chondrocyte sheets,12,13,14,15 and the biopsy samples of all patients in the present study demonstrate that this may also be possible in humans.
We have often experienced difficulties in the precise evaluation of the efficacy of OAK treatment because OAK is a heterogeneous and slowly progressive disease. For this small initial longitudinal series, the combination therapy for OAK was effective, as assessed by MRI, arthroscopy, viscoelasticity, histology, and clinical outcomes such as the KOOS and LKS.
Medial osteophyte progression was observed only in this patient (Fig. 2c–e), and we have not identified any effects or clinical symptoms caused by this osteophyte. However, Felson et al.26 reported that osteophytes are strongly associated with malalignment to the side of the osteophyte and that malalignment is a potential risk factor for progression of OA. We consider it unlikely that this patient’s osteophyte progression reflects malalignment after the OWHTO because the patient is quite active in daily life. We plan careful long-term follow-up of this patient.
In addition, the expression of marker gene sets in autologous chondrocyte sheets appeared to be predictive of the outcomes of the LKS and was weakly predictive of the overall KOOS and OARSI histological scores. A longitudinal prospective study of therapy using autologous cells may be able to determine whether the gene sets identified in the regenerative product can predict the longer-term clinical and structural outcomes of this treatment. The gene sets that would be predict the structural outcomes of histological scores may provide alternative markers for evaluating OAK treatment and predicting the long-term prognosis of the therapy.
Although the method used in our clinical study is challenging for the regulatory authorities, we believe it is essential to continue investigating the outcomes in more patients with OAK. Determining the true effectiveness of this therapy for OAK requires longer-term follow-up and strict comparative studies.
Each author certifies that his institution approved the human protocol for this clinical study that all investigations were conducted in conformity with ethical principles of research, and that informed consent for participation in the study was obtained. Investigations were performed at Tokai University School of Medicine, Isehara, Japan.
Study design and setting
Our clinical study was designed as a single-arm, nonrandomized, uncontrolled study. This study (UMIN Clinical Trials Registry, UMIN000006650) was approved by the Institutional Review Board of the Tokai University School of Medicine and by the Ministry of Health, Labor, and Welfare of Japan. The written informed consent was obtained from all participants.
Eligible patients were aged 20 to 60 years and had a symptomatic cartilage lesion involved in OAK. The inclusion criteria included cartilage defects (of the condyle of the femur and/or the patellofemoral joint) that would traditionally have been indications for marrow stimulation techniques or osteochondral autografts that were equivalent to Outerbridge grade III or IV and sized less than 4.2 cm2/defect. The exclusion criteria included difficulty in obtaining informed consent from the patient; complications hindering surgery under general anesthesia or affecting knee surgery; problematic infectious disease (including being positive for hepatitis B virus, hepatitis C virus, human immunodeficiency virus, human T-cell leukemia virus-1, or the fluorescent treponemal antibody-absorption test); and a history of rheumatoid arthritis or other systemic inflammatory disease. The final decision about entry into the clinical study was made during arthroscopic evaluation 3–4 weeks before the operation.
Ten patients who had cartilage defects categorized arthroscopically as Outerbridge grade III or IV were enrolled, and eight patients received the therapy. Two patients were excluded because we were unable to collect a sufficient volume of cartilage in one and were unable to generate layered chondrocyte sheets from the second.
The first patient was enrolled in November 2011 and the last in August 2013. All patients completed follow-up of at least 3 years. The median age of the patients was 48 years (range, 30–59 years), the median duration of symptoms was 11.8 years (range, 5–20 years), the median size of each cartilage defect was 3.44 cm2 (range, 2.25–4.10 cm2/defect), and the median follow-up was 54 months (range, 36–67 months). For patients meeting the inclusion criteria, a LIPA method was used to assess cartilage viscoelasticity,27,28,29 and cartilage and synovial tissues were collected for the fabrication of chondrocyte sheets. Details of the eight patients who received the combination therapy are shown in Table 1.
Surgery and rehabilitation
We designed a combination therapy in which conventional surgical treatment for OAK, covered by National Health Insurance, was followed by the RMSC method (Fig. 1b). Eight patients with OAK accompanied by cartilage defects of up to 4.2 cm2 received the therapy. This size of the defect was recommended by the Ministry of Health, Labor and Welfare as being within the size of a cell sheet. Three patients with post-traumatic OA underwent arthroscopic ACL reconstruction,30 and five patients with general OA underwent OWHTO.31 After these conventional surgeries, the knee joint was opened using the parapatellar medial approach. The medial femoral condyle, medial tibial plateau, and patellofemoral joint were observed. In all patients, the articular cartilage on these lesions had been lost, and the subchondral bone was often eburnated (Supplementary Movie 1). All cartilage defects were defined as Outerbridge grade III or IV.32 A rigorous evaluation protocol was designed to determine the safety and efficacy of the therapy (Fig. 1c). Pre- and postoperative images of a representative patient who underwent the therapy are shown in Fig. 2.
All patients were immobilized immediately after surgery using a plaster splint that was maintained for 2 weeks at 20-degree flexion of the knee so as not to disturb the transplanted sheets. Patients then started range-of-motion exercise, partial weight bearing at 2 weeks, and full weight bearing at 4 weeks after surgery. In general, low-impact activities started at 6 months, and high-impact activities were allowed at 8 months.
Variables, outcome measures, data sources, and bias
Imaging assessment was performed using X-ray photographs and MRI. X-ray photographs were examined for the knee alignment, the condition of the subchondral bone, and the progression of OAK. Progress was evaluated using the Kellgren–Lawrence grading scale pre- and postoperatively. MRI examinations were performed using an Achieva 3.0-T TX scanner (Philips Healthcare, Best, The Netherlands), within a TX SENSE Knee eight-channel coil (Philips Healthcare). The images were taken with a 10-degree flexion of the knee. Sagittal and coronal MR images were used to evaluate the cartilage defect areas pre- and postoperatively.
For evaluation of the therapy, we used the MOCART method described by Marlovits et al.33 Table 2 shows the variables included in the MOCART. Arthroscopic evaluation of cartilage defects for condition, size, and Outerbridge grade was performed pre- and postoperatively. The LIPA method was used to evaluate the viscoelastic properties of cartilage pre- and postoperatively (Supplementary Movies 1 and 2). The use of LIPA was approved by the Institutional Review Board for Clinical Research at Tokai University, and the method has been applied clinically to evaluate the mechanical properties of cartilage in patients.29
Histological outcomes were evaluated 12-months postoperatively using an arthroscopically performed biopsy taken from near the center of the regenerated cartilage. Samples were embedded in paraffin wax, and 3 μm histological sections were cut, deparaffinized, stained with Safranin O, and immunostained for COL1 and COL2 using previously reported methods.13 The OARSI histological score was assessed independently by three trained orthopedic surgeons. Microscopic scoring of the cartilage was evaluated using the method described by Little et al.36 who provided representative images for each score. There were minimal variations in scoring between the three scorers. The Mankin score37 was obtained similarly. Structural compromise (0–6 points), loss of matrix staining (0–4 points), cellularity anomalies (0–3 points), and violation of tidemark integrity (0 or 1 point) were graded using this scale, with normal cartilage given a score of 0 out of 14 points.
Fabrication of triple-layered chondrocyte sheets
Triple-layered chondrocyte sheets were fabricated using previously described methods.16,17,20 Layered chondrocyte sheets were manufactured for the eight patients at the cell-processing center in our hospital, and their physical and functional characteristics were analyzed to identify predictors of clinical effectiveness. In brief, the collected chondrocytes and synovial cells from each patient were passed through a cell strainer (BD Biosciences, Franklin Lakes, NJ, USA) with a pore size of 100 μm, and the cells were retrieved by centrifugation. The synovial cells were seeded into six-well plates (BD Biosciences) at 1 × 104 cells/cm2, and the chondrocytes were seeded into temperature-responsive culture inserts (4.2 cm2; CellSeed Inc., Tokyo, Japan) at 5 × 104 cells/cm2 (Fig. 1a). The chondrocytes and synovial cells were cocultured for 14–17 days in Dulbecco’s minimal essential medium/F12 supplemented with 20% fetal bovine serum and 1% antibiotic–antimycotic solution at 37 °C in 5% CO2 and 95% air. From day 4, 50 μg/ml ascorbic acid (Wako Pure Chemical Industries, Ltd., Osaka, Japan) was added to the culture medium. After 14–17 days of coculture, the chondrocyte sheets on temperature-responsive culture inserts were removed from the incubator and left at 20 °C for 30 min (Fig. 1a). After removal of the culture medium, a PVDF membrane was used to retrieve each chondrocyte sheet (Fig. 4a) as previously described.38 Briefly, a chondrocyte sheet was covered with a PVDF membrane, and the edges of the sheet were folded onto the membrane. The sheet and membrane were harvested carefully as one unit and placed on top of another chondrocyte sheet. The second and third sheets were harvested similarly and used to fabricate triple-layered chondrocyte sheets. A cell strainer (BD Biosciences) was placed on top of the layered sheet to prevent floating. The triple-layered chondrocyte sheets were cultured for a further 7–8 days in culture dishes.
Flow cytometric characterization of chondrocyte sheets
Flow cytometric analysis of chondrocyte sheets was performed on single-layer sheets before layering and on triple-layered sheets on the day before transplantation. Chondrocyte sheets were digested with TrypLE Express (Thermo Fisher Scientific, Waltham, MA, USA) at 37 °C for 15 min and then incubated with 0.25 mg/ml collagenase-P (Roche, Basel, Switzerland) at 37 °C for 30 min. The dispersed cells were washed with Ca++/Mg++-free phosphate-buffered saline (PBS) containing 0.2% human serum albumin (Sigma-Aldrich, St. Louis, MO, USA) and 1 mM ethylenediaminetetraacetic acid (EDTA; Wako Pure Chemical Industries, Ltd.), and then immunostained with the following antibodies: CD31–fluorescein isothiocyanate (FITC) (clone: 5.6E) and CD45–FITC (clone: J.33) from Beckman Coulter, Inc. (La Brea, CA, USA); CD81–allophycocyanin (APC) (clone: JS-81), CD90–APC (clone: 5E10), CD49a–phycoerythrin (PE) (clone: SR84), and disialoganglioside GD2 (clone: 14.G2a) from BD Biosciences; and CD146–PE (clone: F4-35H7 (S-Endo 1)) from BioCytex (Marseille, France). Fluorochrome-labeled mouse IgG1 antibody (clone: 679.1Mc7, Beckman Coulter) was used as a negative control and FITC-conjugated goat anti-mouse IgG (BD Biosciences) was used as the secondary antibody. Stained cells were analyzed using a FACSVantage flow cytometer (BD Biosciences).
Immunohistochemical characterization of chondrocyte sheets
Cryosections (20-μm thick) of chondrocyte sheets were fixed with 4% paraformaldehyde in phosphate buffer (PB) and washed three times with PBS. For histological analysis, sections were stained with hematoxylin and eosin. For immunohistochemistry, sections were blocked with 5% normal goat serum and 0.3% Triton X-100 in PB for 30 min. The sections were then incubated with primary antibodies to human COL1 (SouthernBiotech, Birmingham, AL, USA; dilution 1:200), COL2 (Kyowa Pharma Chemical Co., Ltd., Toyama, Japan; dilution 1:200), FN (Merck Millipore, Darmstadt, Germany; dilution 1:500), or ACAN (R&D Systems, Minneapolis, MN, USA; dilution 1:10) at 4 °C overnight. The sections were then washed and incubated at room temperature for 1 h with the secondary antibody Alexa Fluor 488-conjugated goat anti-mouse Ig (Thermo Fisher Scientific) for COL2 and FN, or donkey Alexa Fluor 546-conjugated anti-goat Ig (Thermo Fisher Scientific) for COL1 and ACAN. After immunostaining, the slides were stained with 4′,6-diamidino-2-phenylindole (Vector Laboratories, Burlingame, CA, USA) and observed under a BZ-9000 fluorescence microscope (Keyence Corp., Osaka, Japan).
Gene expression analysis of chondrocyte sheets
Chondrocyte sheets from the day before transplantation were disrupted in TRIzol Reagent (Life Technologies, Carlsbad, CA, USA), and total RNA was isolated using an SV Total RNA Isolation System (Promega Corp., Fitchburg, WI, USA). Total RNA was converted to cDNA using oligo(dT)16 primers and MuLV Reverse Transcriptase (both from Applied Biosystems, Waltham, MA, USA) at 48 °C for 30 min. A TaqMan PreAmp Master Mix Kit (Applied Biosystems) was used to preamplify the cDNA. TaqMan gene expression assay kits (Applied Biosystems) including fluorescent probes and forward–reverse primers were diluted with Tris-EDTA buffer (1×) according to the manufacturer’s instructions to obtain a final concentration of 0.2× for the pooled assay mix. TaqMan qPCR was performed using the 7500 qPCR System (Thermo Fisher Scientific). The relative expression values for each gene (–ΔCt values) were calculated using GAPDH as the internal control. qPCR was not performed for one of the eight patients because only a very small amount of total RNA could be isolated after the extraction process.
Predictive gene marker sets were selected from the 45 genes and control genes examined (GAPDH and ACTB) (Table 3 in Supplementary information) as those whose expression correlated with the OARSI histological score or the overall KOOS and LKS 12 months postoperatively. First, 41 of 45 genes with normalized ΔCt values greater than –15 cycles were identified as having detectable gene expression without more than 30% missing values. Then, for each outcome assessment, Pearson correlation coefficients were calculated between the expression level of each of these 41 genes and the individual scores (KOOS, LKS, and OARSI histological score) using the leave-one-out process, and the genes were ranked from highest to lowest for the absolute values of the coefficients. From this, a matrix of seven sets of Pearson correlation coefficients was calculated. Five representative genes were selected independently as predictive markers for each of the outcome assessments by selecting the top five genes in rank order, and listed by their probability of appearance. Finally, six gene sets with the highest probability of appearance were selected as the predictive markers. The gene expression score (GES) was calculated by weighted voting of the appearance probability of each predictive marker gene based on linear functions (GES = ∑ (p × ΔCt)).
Clinical outcomes were assessed using the KOOS and LKS according to the protocol (Fig. 1c). One-way analysis of variance with a post hoc Holm–Bonferroni test was used to identify differences between pre- and postoperative scores for clinical outcomes (n = 8). P-values < 0.05 were considered to be significant.
Further information on experimental design is available in the Nature Research Reporting Summary linked to this article.
The data sets generated and/or analyzed during the current study are available from the corresponding author on reasonable request.
Jiang, Y. & Tuan, R. S. Origin and function of cartilage stem/progenitor cells in osteoarthritis. Nat. Rev. Rheumatol. 11, 206–211 (2015).
Felson, D. T. An update on the pathogenesis and epidemiology of osteoarthritis. Radiol. Clin. North Am. 42, 1–9 (2004).
World Health Organization (WHO). The World Health Report 2002–Reducing Risks, Promoting Healthy Life, Annex Table 3 Burden of disease in DALYs by cause, sex and mortality stratum in WHO Regions, estimates for 2001, 196–197 (2002). https://www.who.int/whr/2002/en/.
Ikawa, T., Yano, K., Watanabe, N., Masamune, K. & Yamato, M. Non-clinical assessment design of autologous chondrocyte implantation products. Regen. Ther. 1, 98–108 (2015).
Ding, C. et al. Natural history of knee cartilage defects and factors affecting change. Arch. Intern Med. 166, 651–658 (2006).
Driban, J. B., Sitler, M. R., Barbe, M. F. & Balasubramanian, E. Is osteoarthritis a heterogeneous disease that can be stratified into subsets? Clin. Rheumatol. 29, 123–131 (2010).
Nishida, K. et al. Corneal reconstruction with tissue-engineered cell sheets composed of autologous oral mucosal epithelium. N. Engl. J. Med. 351, 1187–1196 (2004).
Sawa, Y. et al. Tissue engineered myoblast sheets improved cardiac function sufficiently to discontinue LVAS in a patient with DCM: report of a case. Surg. Today 42, 181–184 (2012).
Ohki, T. et al. Treatment of oesophageal ulcerations using endoscopic transplantation of tissue-engineered autologous oral mucosal epithelial cell sheets in a canine model. Gut 55, 1704–1710 (2006).
Kaneshiro, N. et al. Bioengineered chondrocyte sheets may be potentially useful for the treatment of partial thickness defects of articular cartilage. Biochem. Biophys. Res. Commun. 349, 723–731 (2006).
Mitani, G. et al. The properties of bioengineered chondrocyte sheets for cartilage regeneration. BMC Biotechnol. 9, 17 (2009).
Takaku, Y. et al. In vivo cell tracking by bioluminescence imaging after transplantation of bioengineered cell sheets to the knee joint. Biomaterials 35, 2199–2206 (2014).
Ito, S. et al. Repair of articular cartilage defect with layered chondrocyte sheets and cultured synovial cells. Biomaterials 33, 5278–5286 (2012).
Tani, Y. et al. The effects of using vitrified chondrocyte sheets on pain alleviation and articular cartilage repair. J. Tissue Eng. Regen. Med. 11, 3437–3444 (2017).
Ebihara, G. et al. Cartilage repair in transplanted scaffold-free chondrocyte sheets using a minipig model. Biomaterials 33, 3846–3851 (2012).
Hamahashi, K. et al. Studies of the humoral factors produced by layered chondrocyte sheets. J. Tissue Eng. Regen. Med. 9, 24–30 (2012).
Kokubo, M. et al. Characterization of chondrocyte sheets prepared using a co-culture method with temperature-responsive culture inserts. J. Tissue Eng. Regen. Med. 10, 486–495 (2016).
World Health Organization (WHO). Recommendations for the evaluation of animal cell cultures as substrates for the manufacture of biological medicinal products and for the characterization of cell banks. World Health Organ. Tech. Rep. Ser. 978, Annex 3 (2013).
Yokoyama, M. et al. Assessment of the safety of chondrocyte sheet implantation for cartilage regeneration. Tissue Eng. Part C. Methods 22, 59–68 (2016).
Sato, M., Yamato, M., Hamahashi, K., Okano, T. & Mochida, J. Articular cartilage regeneration using cell sheet technology. Anat. Rec. 297, 36–43 (2014).
Okano, T., Yamada, N., Okuhara, M., Sakai, H. & Sakurai, Y. Mechanism of cell detachment from temperature-modulated, hydrophilic–hydrophobic polymer surfaces. Biomaterials 16, 297–303 (1995).
Okano, T., Yamada, N., Sakai, H. & Sakurai, Y. A novel recovery system for cultured cells using plasma-treated polystyrene dishes grafted with poly(N-isopropylacrylamide). J. Biomed. Mater. Res. 27, 1243–1251 (1993).
Wakitani, S. et al. Human autologous culture expanded bone marrow mesenchymal cell transplantation for repair of cartilage defects in osteoarthritic knees. Osteoarthr. Cartil. 10, 199–206 (2002).
Sekiya, I., Muneta, T., Horie, M. & Koga, H. Arthroscopic transplantation of synovial stem cells improves clinical outcomes in knees with cartilage defects. Clin. Orthop. Relat. Res. 473, 2316–2326 (2015).
Maehara, M. et al. Characterization of polydactyly-derived chondrocyte sheets versus adult chondrocyte sheets for articular cartilage repair. Inflamm. Regen. 37, 22 (2017).
Felson, D. T. et al. Osteophytes and progression of knee osteoarthritis. Rheumatology 44, 100–104 (2005).
Ishihara, M. et al. Development of a diagnostic system for osteoarthritis using a photoacoustic measurement method. Lasers Surg. Med. 38, 249–255 (2006).
Sato, M., Ishihara, M., Kikuchi, M. & Mochida, J. A diagnostic system for articular cartilage using non-destructive pulsed laser irradiation. Lasers Surg. Med. 43, 421–432 (2011).
Ukai, T. et al. Usefulness of using laser-induced photoacoustic measurement and 3.0 Tesla MRI to assess knee cartilage damage: a comparison study. Arthritis Res. Ther. 17, 383 (2015).
Mitani, G. et al. Tibia rotational technique to drill femoral bone tunnel in anatomic double-bundle anterior cruciate ligament reconstruction. Arthrosc. Tech. 3, e495–e499 (2014).
Takeuchi, R. et al. Medial opening wedge high tibial osteotomy with early full weight bearing. Arthroscopy 25, 46–53 (2009).
Outerbridge, R. E. The etiology of chondromalacia patellae. 1961. Clin. Orthop. Relat. Res. 389, 5–8 (2001).
Marlovits, S. et al. Magnetic resonance observation of cartilage repair tissue (MOCART) for the evaluation of autologous chondrocyte transplantation: determination of interobserver variability and correlation to clinical outcome after 2 years. Eur. J. Radiol. 57, 16–23 (2006).
Roos, E. M. & Lohmander, L. S. Knee injury and Osteoarthritis Outcome Score (KOOS): from joint injury to osteoarthritis. Health Qual. Life Outcomes 1, 64 (2003).
Tegner, Y. & Lysholm, J. Rating systems in the evaluation of knee ligament injuries. Clin. Orthop. Relat. Res. 198, 43–49 (1985).
Little, C. et al. The OARSI histopathology initiative–recommendations for histological assessments of osteoarthritis in sheep and goats. Osteoarthr. Cartil. 18, S80–S92 (2010).
Mankin, H. J., Dorfman, H., Lippiello, L. & Zarins, A. Biochemical and metabolic abnormalities in articular cartilage from osteo-arthritic human hips. J. Bone Jt. Surg. Am. 53, 523–537 (1971).
Yamato, M. et al. Thermo-responsive culture dishes allow the intact harvest of multilayered keratinocyte sheets without dispase by reducing temperature. Tissue Eng. 7, 473–480 (2001).
We thank Dr. Kenji Serigano, Dr. Satoshi Itoh, Dr. Taku Ukai, Dr. Miyuki Yokoyama, Dr. Munetaka Yokoyama, Dr. Yoshiki Tani, Dr. Eriko Toyoda, Takumi Takahashi, Miki Maehara, Eri Okada, Ayako Watanabe, and Saori Shirasuna (Tokai University) and our collaborators Dr. Mami Kokubo (Tokyo Women’s Medical University), Dr. Hidenori Akutsu, Dr. Akihiro Umezawa (National Research Institute for Child Health and Development), Dr. Reiko Kato (National Institute of Health Sciences), Dr. Hiroshi Nagashima (Meiji University), Tomoko Kawake, and Dr. Setsuko Hashimoto (CellSeed Inc.) for their various contributions to this project. We also thank the Support Center for Medical Research and Education at Tokai University for technical support in histological analysis. One or more of the authors has received funding from the following sources. This research was supported by a Health Labor Sciences Research Grant (No. 09155416, 12103253 to M.S.) from the Ministry of Health, Labor and Welfare of Japan; by the Research Project for Practical Applications of Regenerative Medicine (No. 12103253 to M.S.); and by the Project Focused on Developing Key Evaluation Technology: Evaluation for Industrialization in the Field of Regenerative Medicine (No. 15667006 to M.S., and R.M.) from the Japan Agency for Medical Research and Development.
Each author certifies that M.S. has been involved in the following relevant financial activities outside of this work and/or other relationships or activities that readers could perceive to have influenced, or that give the appearance of potentially influencing, this manuscript: Funding from CellSeed Inc. M.S. is one of the inventors on the patent (PCT/JP2006/303759) held by the applicants Tokai University and CellSeed Inc. for the manufacturing process of chondrocyte sheets. The other authors declare no competing interests.
Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
About this article
Cite this article
Sato, M., Yamato, M., Mitani, G. et al. Combined surgery and chondrocyte cell-sheet transplantation improves clinical and structural outcomes in knee osteoarthritis. npj Regen Med 4, 4 (2019). https://doi.org/10.1038/s41536-019-0069-4
Cyborg and Bionic Systems (2021)
International Journal of Molecular Sciences (2021)
Trends in Articular Cartilage Tissue Engineering: 3D Mesenchymal Stem Cell Sheets as Candidates for Engineered Hyaline-Like Cartilage
Regenerative Therapy (2021)
npj Regenerative Medicine (2021)