Introduction

Recovery of gait and related functions such as balance and mobility are important priorities for persons with spinal cord injury (SCI) [1, 2]. Recovery of gait function is possible for some persons with an incomplete SCI [3], but less likely if the injury is complete [4, 5]. A central paradigm in rehabilitation is task-specific training aimed at recovery of an identified and desired function [6].

Wearable robotic exoskeletons are motorized orthoses that facilitate untethered standing and walking over ground. These devices can support multiple step repetitions while having full weight bearing on the body thus, being task-specific for rehabilitation of gait function.

Rationales for engaging in exoskeleton training, in cases where rehabilitation of gait function is not the aim, could be a desire to decrease time in sitting position [7], to test effects on secondary complications following SCI, such as pain, spasticity, bowel and bladder function [811] or use of the exoskeleton as a potential future mobility device.

Previous studies of wearable exoskeletons have investigated safety and changes in training characteristics within small study samples with an overall 75% majority of participants with complete SCI [12]. There is a need to assess robotic wearable exoskeleton gait training in the different subgroups of the heterogeneous SCI population, i.e., persons with recent and chronic injury, paraplegia and tetraplegia as well as persons with complete and incomplete SCI. There is also a need for studies representing the different models of wearable exoskeletons on the market. To date, only few studies using the exoskeletons from Ekso Bionics (Ekso Bionics, Richmond, CA) have been published [8, 10, 13, 14].

The primary objective of this study was to assess safety and feasibility during an eight week training programme with the robotic exoskeletons from Ekso Bionics for persons with SCI, while representing a broad range of participants based on severity and level of injury, as well as time since injury. Feasibility testing included documentation of the number of participants who completed the training protocol, changes in training characteristics during the exoskeleton gait training and perceived rate of exertion during training. The secondary objective was to assess changes in gait function outside of the exoskeleton in the subgroup of participants who were able to walk without the exoskeleton.

Methods

Study design

The study was designed as an open-label, prospective quasi-experimental study with a pre- and post-design. The data collection was conducted as a multicentre study across nine European SCI rehabilitation centres located in Denmark, Germany, the Netherlands, Norway, Spain, Sweden and Switzerland.

Participants

The study population was a convenience sample recruited at each of the nine centres. Eligibility criteria are listed in Table 1. Data collection was completed between April 2014 and March 2016. Recruitment was done by verbal communication at in- and outpatient facilities, as well as written advertisement for the study at each centre and in consumer magazines.

Table 1 Eligibility criteria

The study protocol and all tests were systematically reviewed at two kick-off meetings prior to study start. All researchers and therapists involved in the study attended in order to ensure consistency in training and testing procedures.

Training protocol

This study used the two exoskeletons manufactured by Ekso Bionics, the Ekso (n = 8 participants) and the Ekso GT (n = 44 participants). Control of the walk-mode was done by the three settings Max, Fixed or Adapt. Either a front-wheeled walker or crutches were used as assistive devices. At least one Ekso-certified physiotherapist assisted and guided the participant while walking.

The training protocol consisted of gait training three times per week for eight weeks and the training protocol was considered completed if, at least, 16 out of the 24 training sessions (TS) were attended. The training intervention was given as an “add on” to existing training. The study did not control for other types of training the participants participated in.

Assessments

Training characteristics of the gait training were described by the outcome variables total up time (time standing plus time walking), walk time (time in walk motion) and number of steps, recorded by the device during the TS, alongside the walk-mode and the assistive device used. After each TS the participants’ Rate of Perceived Exertion (RPE) on the Borg Scale (6 = very easy to 20 = very exhaustive) [15] was recorded by asking the question: “what was your perceived exertion for the whole TS on a scale from a 6 to 20?” [16].

Skin integrity at contact points with the device was investigated before and after each TS and any adverse events were documented. Skin ulcers were categorized according to The US National Pressure Ulcer Advisory Panel and European Pressure Ulcer Advisory Panel pressure ulcer classification system [17]: Category I, Non-blanchable Erythema; Category II, Partial Thickness Skin Loss; Category III, Full Thickness Skin Loss; Category IV, Full Thickness Tissue Loss; Unstageable, Depth Unknown.

A neurological examination was performed, according to the ISNCSCI [18, 19] at baseline, at end of the training period (TS24) and at a follow-up (FU) session 4 weeks after the last TS. Lower Extremity Motor Score (LEMS) [20] was used as an outcome measure instead of the total upper and lower extremity motor score since LEMS has shown to be a better predictor of gait function than the total score [21]. SCI-subgroups were defined by three dichotomizations: Tetraplegia (neurological level of injury, NLI C1–C8) or paraplegia (NLI T1–L2), recently injured (time since injury, TSI <1 year) or chronically injured (TSI ≥ 1 year), and Motor complete SCI (American Spinal Injury Association Impairment Scale, AIS A and B) or motor incomplete (AIS C and D).

Participants who had or acquired gait function during the training period performed the following tests: 10 Metre Walk Test (10MWT) [20, 2224], Timed Up and Go (TUG) [22, 23], Berg Balance Scale (BBS) [25, 26] and Walking Index for Spinal Cord Injury II (WISCI II) [20, 24]. These tests were recorded at baseline, midway (TS12), at end (TS24) and at FU. The 10MWT was performed at comfortable speed and with flying start. Gait function without the exoskeleton was defined as the ability to complete the 10MWT independently without an assistant, with or without a walker or crutches and/or with a brace. Only participants with LEMS ≥1 were included in the analysis of gait function.

Heart rate (HR) and blood pressure (BP) measurements were recorded in sitting position before walking and after 10 min of walking. Change from sitting to walking HR and BP was used as an outcome measure of physical strain and repeated measures were performed at TS1, TS12 and TS24 to test change over time.

Statistical methods

Repeated measures were analysed with a linear Mixed Model analysis, using compound symmetry for the repeated covariance type, group differences were assessed as a fixed factor and pairwise comparisons were adjusted with Bonferroni correction. Changes in number of persons with gait function was analysed with McNemar’s test for dichotomous variables. Statistical significance was set at α = 0.05. Statistical analyses were performed with IBM SPSS Statistics version 22 (IBM Corp., Released 2013. Armonk, NY, USA).

Statement of ethics

All applicable institutional and governmental regulations concerning the ethical use of human volunteers were followed during the course of this research. All the necessary approvals were obtained in each centre. All participants received oral as well as written information about the study before written consent was obtained. The study followed the Helsinki Declaration guidelines. The study was registered at ClinicalTrials.gov with identifier: NCT02132702.

Results

Population characteristics are shown in Table 2 and details on centres are listed as Supplementary Material 1.

Table 2 Study population characteristics

Feasibility and adherence to the protocol and adverse events

Eligibility criteria were met by 60 participants. Of these, completed 52 participants (87%) the training protocol and 8 dropped out. Reasons for drop out were time constraint (N = 2), surgery not related to the training (N = 1), adverse events with ankle swelling (N = 3), and concurrent medical conditions (N = 2, one participant had a previous minor traumatic brain injury and one had a previous minor stroke). The two concurrent medical conditions were at the screening session evaluated not to affect training or confound the results, but spasticity was too prominent during the first TS and the participants were excluded. There were no serious adverse events and no falls. The reported adverse events and skin issues are listed in Table 3.

Table 3 Adverse events and skin issues

Change in training characteristics over time

The group that adhered to the training protocol (N = 52) had a median number of 21 (88%) completed sessions (IQR 20–23.5, range 17–24). The training characteristics up time, walk time, ratio between the two and number of steps are shown in Fig. 1a–c. All training characteristics increased significantly from TS1 to TS24 in a mixed model analysis (up time: F = 2.168, P < 0.001; walk time: F = 10.988, P < 0.001; steps: F = 15.556, P < 0.001), including all subgroups: recently and chronically injured, paraplegia and tetraplegia and incomplete and complete injury (P < 0.001). There were no differences in up time between groups (no interactions, no main effects). Walk time was longer for chronically injured participants compared to recently injured participants with a mean difference of 5.3 min (95% confidence interval (CI) 0.8–9.8; P = 0.22), but there was no difference in the number of steps in a TS. There were no group differences between participants with paraplegia versus tetraplegia in walk time (F = 2.821, P = 0.100), or number of steps in a session (F = 1.358, P = 0.250). There were no differences in walk time for participants with incomplete, versus complete injuries (F = 1.532, P = 0.222). The participants with incomplete injuries had more steps per session than the group with complete SCI, the mean difference was 335 steps (95% CI 112–558, P = 0.004).

Fig. 1
figure 1

Training characteristics while walking with the exoskeleton at each training session. a Median up time and walk time in minutes, b ratio of walk time and up time; c median number of steps; d Median RPE on the Borg Scale (6–20); e distribution of participants using either walker or crutches as assistive devices at the training session; f walk-modes (Max, Fixed, Adapt). Error bars representing IQR. Abbreviations: RPE, Rate of Perceived Exertion; IQR, Interquartile range

Figure 1e shows the distribution at each TS of participants using the two assistive devices: walker, or crutches. Figure 1f shows the distribution of participants using each of the three walk-modes: Max, Fixed and Adapt.

Physical exertion during walking

The RPE at each TS is shown in Fig. 1d. The median Borg values correspond to “light” to “somewhat hard” exertion. A mixed model analysis showed a significant decrease over time of RPE (F = 2.269, P = 0.001). There were no significant group differences in RPE between participants with recently vs. chronically injuries (F = 0.45, P = 0.833), participants with tetra- vs. paraplegia (F = 0.000, P = 0.983) or complete vs. incomplete SCI (F = 0.004, P = 0.948).

There were no significant differences over time for HR, or BP between time points TS1, TS12 and TS24 (P > 0.05). Within the session, HR increased 15–21% (P < 0.001) from sitting to walking at the three time points but corresponding BP did not change significantly.

Number of persons with gait function outside of the exoskeleton

Figure 2 shows the changes in number of participants with gait function over time, split between recently injured and chronically injured participants. In the recently injured group, five participants (20%) had gait function at baseline which increased to 14 (56%) at TS24, (test statistic = 7.11, P = 0.004) and to 15 participants (60%) at follow up (test statistics = 0, P = 1.00). In the chronically injured group, 11 participants (41%) had gait function at baseline. One chronically injured participant acquired gait function during the training period and retained this at follow up, making a total of 12 (44%). The participant had a 13 years old T12 injury, AIS D and changed LEMS from 36 to 37 from screening to TS24 and at follow up.

Fig. 2
figure 2

Distribution of participants with and without gait function over time among recently injured a and chronically injured b. LEMS Lower Extremity Motor Score,TS training session, TSI time since injury

Figure 3 shows the individual plots for the subgroup of participants who had gait function outside of the exoskeleton. Table 4 illustrate the estimated marginal means and test statistics from a mixed model analysis of the gait tests, at each time point for the same participants. The recently injured participants significantly improved TUG, 10MWT, BBS and LEMS but not WISCI II from baseline to TS24. The chronically injured participants significantly improved TUG and BBS but not 10MWT, WISCI II or LEMS from baseline to TS24. These changes were retained at follow up in both groups. Two chronically injured participants with complete SCI reported a subjective experience of improved sitting balance after the two months of training.

Fig. 3
figure 3

Gait tests, balance tests and lower extremity motor score (LEMS) over time. Group statistics are shown in Table 4. TUG, Timed Up and Go, 10MWT, 10 Metre Walk Test, BBS, Berg Balance Scale, WISCI II, Walking Index for Spinal Cord Injury II, LEMS, Lower Extremity Motor Score

Table 4 Gait and balance tests of participants with gait function

Discussion

This study assessed safety, feasibility, changes in training characteristics, RPE and changes in gait function of an eight week training programme with the exoskeletons from Ekso Bionics for persons with SCI. The study documented no serious adverse events but recorded a number of skin issues. It was feasible for all included SCI subgroups to complete the training protocol and to increase training characteristics up time, walk time and steps and, documented improvements in gait tests without the use of the exoskeleton.

Safety and feasibility

In this study, 88% of TS were completed: equivalent to 2.6 completed sessions per week, which was sufficient to lead to the progression in training characteristics for all subgroups. There was no difference in up time between SCI subgroups and only minor differences between subgroups in the outcomes of training characteristics. Transition from walker to crutches, which could reflect an improved level of control, happened primarily within the first four weeks of training.

Lessons to be learned were the importance of a carefully considered assessment of time consumption, the matching of expectations with the participants and close evaluation of concurrent medical conditions of participants.

The three participants who experienced a swollen joint the day following training had chronic SCI and it was concluded that the injuries were due to overuse. Benson et al. [27] reported a swollen ankle, in a study using ReWalk (Argo Medical Technologies Ltd, Yokneam Ilit, Israel), following the same pattern with joint effusion the day after training. The risk of overuse injuries should be considered when an extensive gait training programme is introduced to individuals with chronic injury who has not walked or stood up regularly for several years. A previous study [10] on the Ekso reported skin issues of category I in contact areas with the skin and similar findings have also been reported with the ReWalk [27].

Overall, we conclude that training with the exoskeletons from Ekso Bionics is safe, in line with the results of previous studies [12]. However, it is important that particular attention is given to prone skin.

Physical strain and RPE

Robotic exoskeletons have been designed for gait training in rehabilitation facilities, but can potentially be used as mobility devices for persons with paralysis. The devices can be seen as a further development of mechanical orthoses, such as the reciprocating gait orthosis. The daily use of these were often limited because of high energy demand and fatigue experienced after walking short distances [28] and have resulted in limited long-term use by individuals [29]. Self-perceived exertion was in the range from “fairly light” to “somewhat hard”, which was supported by the relative low increase in HR measure of 15–21% from sitting to standing. This result is also in line with previous findings of walking with an exoskeleton [8, 12]. Interestingly, we did not find subgroup differences in RPE. The reason could be that different levels of assistance from exoskeleton were allowed. It should also be noted that the subjective Borg RPE may not be accurate in SCI [30]. However, all taken together, the results indicate that walking can be performed for an extended period of time by persons with a variety of SCI.

Changes in gait function without the exoskeleton and LEMS

The recently injured participants who had gait function without the exoskeleton improved in TUG, 10MWT, BBS and LEMS from baseline to TS24 and to follow up. Chronically injured participants improved TUG and BBS in the same periods. The significant changes from baseline to follow up indicate that these changes were sustained over time. Some degree of neurological recovery would be expected in the early phase after injury whereas this is less likely to happen in the chronic phase [4, 5, 31]. The increase seen in LEMS in the recently injured group but not in the chronically injured group could be a reflection of that.

Improvements in 10MWT, TUG and LEMS have been reported after three months of training with the exoskeleton HAL (Hybrid Assistive Limb; Cyberdyne, Inc., Japan) [32] and on 10MWT and TUG using the Lokomat [33]. The latter study [33] also found WISCI II to be less sensitive to changes in gait function in complete SCI compared to the 10MWT and TUG. The same could be suggested to be the case in our study.

The minimal clinically important difference (MCID) for the timed tests was reported by Lam et al. [34] to be 10.8 s (s) for the TUG test and 0.13 m/s for the 10MWT and the minimal detectable difference (MDD) was 3.9 s for the TUG test and 0.05 m/s for 10MWT. These were calculated on distribution scores measured over a three month period. Similar values were reported by Wu et al. [35]. In our study TUG improved by 7.0 and 7.8 s from baseline to TS24 for recently and chronically injured respectively. Gait speed in the 10MWT increased by 0.07 m/s for both groups, based on the marginal means. These values are above MDD but below MCID. However, considering the relatively limited training period of two months and the fact that the tests were performed at comfortable speed, these results could indicate a potential for clinically relevant changes.

The improvements in the gait tests TUG and BBS in the chronically injured group could reflect improvements primarily in balance function, also supported by case reports in this study of improved sitting balance. This seems plausible, since walking with the device relies on correct weight shift from one leg to the other for initiating the next step. Training weight shift should even facilitate the training of balance skills. This could be a direction for future studies to explore.

Strengths and limitations

A strength of this study is that we included both participants with para- and tetraplegia, recent (<1 year) and chronic (>1 year) injuries and motor complete as well as incomplete SCI. This reflects the nature of the SCI population [36] and increases external validity. However, there is a selection bias of the study population, since the study was non-blinded and non-controlled and only participants who could commit to the training protocol were included. This would not reflect the SCI population as a whole. The heterogeneity of the study population resulted in relatively small sample sizes for the subgroups and lowered the statistical power in calculations. The differences between the two versions of devices from Ekso Bionics, the Ekso and the Ekso GT were considered minor and not to confound the results with regards to the objective of the study. Hence, both versions were allowed in the study. Participants from the age of 15 were allowed according to the protocol but none under the age of 18 were included.

To our knowledge, no other studies have tested gait function outside of the device with this or a similar over ground walking exoskeleton. However it should be stressed that the documented changes in the gait tests cannot be assigned to the exoskeleton training intervention with this current study design.

Conclusion

In conclusion, this multicentre study showed that the exoskeletons from Ekso Bionics is safe and feasible for use by persons with SCI, including persons with paraplegia as well as tetraplegia, recent and chronic injury as well as complete and incomplete SCI. Likewise, it was feasible for all the subgroups to increase training characteristics during training. Self-reported RPE, supported by HR measurements, was relatively low and indicates that the device can be used for longer periods of time. For those participants with gait function outside of the exoskeleton, results indicate improvements primarily in balance. This strongly supports continued research in future randomized controlled trials to test wearable exoskeleton gait training in comparison to other types of gait training.

Data archiving

All relevant data are within this manuscript and raw data are archived by the authors.