Abstract
Downhill flows of granular matter colliding in the lowest point of a valley, may induce a self-organized jet. By means of a quasi two-dimensional experiment where fine grained sand flows in a vertically sinusoidally agitated cylinder, we show that the emergent jet, that is, a sheet of ejecta, does not follow the frequency of agitation but reveals subharmonic response. The order of the subharmonics is a complex function of the parameters of driving.
Similar content being viewed by others
Introduction
Granular jets, that is, jets of macroscopic particles, have attracted much attention recently, mainly for their striking phenomenological similarities to fluid jets. The first similarity concerns the Rayleigh-Plateau instability1,2 breaking an narrow flow of liquid into droplets unter the action of gravity due to minimization of surface energy. Initially homogeneous granular jets falling in gravity undergo a similar instability, e.g.3,4,5,6, despite the fact that there is no surface tension. The second similarity concerns the interaction of a granular jet with a solid obstacle, e.g.7,8,9,10,11,12 where granular sheets or cone-like structures emerge. This behavior corresponds to Savart water bells observed for fluid jets13,14. The phenomenon may be described up to good accuracy by means of a vertex free, incompressible fluid flow15,16 which surprises since, in general, granular flows are neither vortex-free nor incompressible. An explanation of this coincidence and the limits of the model are given in ref. 17. Deviations from the perfect fluid description are quantified in18. The third similarity concern splashes which appear when a sphere is dropped into water19. Very similar jet-like splashes can be observed when a sphere is dropped into a loose packing of granular material20,21,22,23,24,25,26. Besides scientifically exciting, granular jets are important also for industrial applications such as abrasive jet micromachining27, jet milling28,29, erosion of granular beds when impinged by a jet30,31,32 and others.
In all experiments mentioned above and in most industrial applications, granular jets are generated by packing the particles into a launching tube and then shooting this plug of particles out of the pipe by means of pressurized gas, see e.g.7,33,34, or by similar procedures. There are, however, effects by which granular jets emerge in a self-organized way. The most prominent of them is the oscillon35 where a spatially isolated granular jet ascends from an vertically vibrated shallow granular bed each second period of the vibration. Granular jets emerge also when an impactor is dropped into a granular bed of low density where the impactor creates a void that when it collapses causes a large but tightly confined splash to shoot upwards, see20,21,22,23,24,25,26 and the discussion above.
Self-organized granular jets are also observed when downhill flows of granular matter collide at the lowest point of a valley. At this point, the incoming rapid convergent flows parallel to the ground come suddenly to rest, such that the energy which cannot be dissipated through particle collisions gives rise to a vertical jet emerging from this point. An convenient experimental system characterized by persistently colliding downhill flows is a vertically vibrated short cylinder, proposed in ref. 36 where the convective flows have the required geometry. In the present paper we adopt this setup to produce sequences of granular jets, similar to the oscillon instability35 with two important differences: First, the novel type of jet appears in each period of the driving vibration unlike the oscillon which is a subharmonic effect of second order. Second, in contrast to the oscillon, the periodic appearance of the jet is superposed by another subharmonic instability whose order is a function of the parameters of driving, amplitude and frequency. The latter type of subharmonic oscillation is the main subject of the present paper. We observed this novel effect to occur as an subharmonic effect of up to order 11.
Results
The experimental setup is sketched in Fig. 1. A cylindrical container of inner diameter 12 cm and length 1 cm is half filled by bright quartz sand of approximately 300 μm particle size (see Fig. 2) vibrated by an electromagnetic shaker. The granular flow is recorded by means of a high-speed camera. The results presented below are obtained from this video footage.
When the system is sinusoidally vibrated in vertical direction, z = A cos(2πf), with sufficiently large amplitude and frequency, Γ ≡ A(2πf)2/g ≳ 1, where g is the gravitational acceleration, one observes pronounced convection flow36. Figure 3 shows a snapshot of the experiment; the convection is schematically shown by superimposed yellow lines. The convective flow entails also the characteristic V-shape of the of the free surface. The corresponding downhill flows implies violent collisions of the particles at the valley where the flows clash. Here, velocity component of the particles in direction along the slopes ceases suddenly and part of the corresponding energy which is not dissipated by inelastic particle collisions, forms a vertical jet close to the center of the system.
From this argument it is plausible, that the size of this jet grows with the intensity of the convection which depends on the amplitude and frequency of the driving. Figure 4(a–c) shows the system at f = 33 s−1 for different values of the amplitude. We find that with increasing amplitude, the convection flow becomes more intense and the jet increases in size (a). Further increasing the amplitude, the central horizontal position of the jet becomes unstable and the jet starts travelling back and forth in horizontal position (b). For yet larger amplitude (c), the convection pattern becomes more complicated and the horizontal oscillation of the jet disappears gradually. The dynamical behavior of the system can be better seen in video sequences corresponding to the snapshots shown in Fig. 4, provided as supplementary material39.
Of particular interest is the intermediate regime when we observe a horizontal, oscillatory motion of the jet which we are going to characterize further. From visual inspection, we find the most salient property of this oscillation which is its stability. The oscillation is a subharmonic effect of higher order as its period, Ts, is an integer multiple, n, of the periode, T, of the driving vibration, n = Ts/T = f Ts = n. In our experiments we found values 6 ≤ n ≤ 11. Figure 5 shows a full period, Ts, of the lateral oscillation of the jet which takes n/f = 7 · 1/34 s ≈ 0.2 s. The amplitude of the vibration is A = 1.97 mm. A corresponding video is provided as supplementary material39.
We quantify the horizontal oscillation by means of the video footage of the high-speed recording (for details of the analysis see Sec. Methods). Figure 6 (left panels) shows the horizontal coordinate of the jet position as a function of time for a fixed frequency, f = 34 s−1 and several values of the amplitude of shaking. From these series we compute the corresponding Fourier spectra (right panels in Fig. 6) to determine the frequency of the oscillation of the horizontal position of the jet. From the spectra we see that for fixed frequency there is a range of amplitude where we find a stable subharmonic oscillation of the oscillation of the jet, where the order of the subharmonics depends in a systematic way on the amplitude. For small and large amplitude of vibration, the oscillation of the jet's horizontal position ceases.
So far, we described the oscillation of the jet's horizontal position for fixed frequency as a function of amplitude. Obviously, the intensity of the convection is not only dependent on amplitude but also on frequency. Therefore, since the convection flow drives the mechanism leading to the jet, one may expect that the oscillation of the jet depends also on the frequency of driving. Figure 7 characterises the jet's horizontal oscillation as a function of both amplitude and frequency, where the color codes the order of the subharmonics, n = Ts/T.
Discussion
We consider a flat cylindrical container partly filled with granular material, with its symmetry axis oriented in horizontal direction. When this system is subjected to vertical sinusoidal vibrations, one observes a convection pattern36 and a characteristic V-shape of the free surface. The corresponding downhill flows which collide in the lowest point of this valley lead to a self-organized granular jet. In dependence on the parameters of the vibration, amplitude and frequency, this jet may reveal a complex temporal behaviour. In particular, for a certain range of parameters, the horizontal location of the jet follows a periodic motion which is a stable subharmonic of order n = 6, …, 11 to the frequency of the driving vibration, that is, the timescale of the jet's periodic oscillation is much larger than the timescale of the driving vertical oscillation. In similar experiments (not reported here) using different materials we observed up to n = 21.
The subharmonic oscillation of the jet's position is a novel effect which was not reported in the literature so far. The effect seems to be robust, that is, in non-systematic experiments we found it for a variety of different experimental conditions, including different container geometry (larger radius, larger height of the cylinder), different filling level, different particle size. Although subharmonic behavior is rather common for different granular systems, such as Faraday waves39 and many other vibro-agitated systems, e.g.35,40,41,42,43,44,45,46,47, we believe that the here reported novel effect is special for two reasons: first, its extraordinary high order of subharmonic response of up to 11. Second, while most subharmonic effects in granular systems are due to a synchrony between the flight time of the granulate or parts of it in the container and period of driving (see48,49 for a detailed discussion) the mechanism leading to the periodic motion of the jet's location is not so clear. In particular, the role of ambient air is still unclear. In the literature on systems rather similar to ours, some references report strong influence of air. e.g.5,23,50, others deny an effect of ambient air, e.g.6.
Methods
Details of the experimental setup
The cylindrical container is manufactured from aluminium with plane front side from glass coated to avoid electrostatic charging. The amplitude of the vibration imposed by the electromagnetic shaker (TIRA S 5220–120) was permanently measured using an Hall effect based position sensor51 with sample rate 10 kHz. This information allows to adjust the amplitude up to high precision with uncertainty ±50 μm. The granular flow was observed by a high speed camera (MotionScope M3), at a frame rate 500 fps and with a spatial resolution 1024 × 1280 pixels. The camera is equipped with a f = 25 mm lens set to an aperture of f/2. For good optical contrast of the displayed images, an image of the black back wall (empty container) was subtracted from the images of the filled box. For illumination we used a LED panel. In addition to the position sensor, we checked the amplitude and frequency of the vibration from the location of a marker at the container wall which was always present in the range of vision of the high-speed camera and could be evaluated à posteriori. The setup is sketched in Fig. 1.
Analysis of the horizontal position of the jet
To quantify the time-dependent horizontal position of the jet, we analyze the frames of the high-speed video recording. First we chose an area which certainly contains the jet for the entire range of amplitude and frequency investigated. This area is marked by a blue line in Fig. 3. For each frame, we consider the field of brightness, , in this area. The horizontal position of the jet is found from
where the summation is performed over all pixels, i, in the marked area and stands for the horizontal component of . The left panels of Fig. 6 show the evolution of xs. The right panels of Fig. 6 are the Fourier transforms of the discrete time series, xs(k), where k stands for the frames of the high-speed video. The order of the subharmonics shown in Fig. 7 is then determined from strongest mode in the amplitude spectrum which is lower than the driving frequency.
Additional Information
How to cite this article: Kollmer, J. E. and Pöschel, T. Subharmonic instability of a self-organized granular jet. Sci. Rep. 6, 22520; doi: 10.1038/srep22520 (2016).
References
Rayleigh, J. W. S. “On the instability of jets”. Proc. London Math. Soc. 10, 4 (1878).
Plateau, J. A. F. Statique expérimentale et théorique des liquides soumis aux seules forces moléculaires (Gauthiers-Villars, Paris, 1873).
Prado, G., Amarouchene, Y. & Kellay, H. “Experimental evidence of a rayleigh-plateau instability in free falling granular jets”. Phys. Rev. Lett. 106, 198001 (2011).
Royer, John, R. et al. “High-speed tracking of rupture and clustering in freely falling granular streams”. Nature 459, 1110–1113 (2009).
Möbius, Matthias, E. “Clustering instability in a freely falling granular jet”. Phys. Rev. E 74, 051304 (2006).
Prado, G., Amarouchene, Y. & Kellay, H. “Incompressible-compressible transition in falling granular jets”. Europhys. Lett. 102, 24006 (2013).
Cheng, Xiang, Varas, G., Citron, D., Jaeger, H. M. & Nagel, S. R. “Collective behavior in a granular jet: Emergence of a liquid with zero surface tension”. Phys. Rev. Lett. 99, 188001 (2007).
Huang, Y. J., Chan, C. K. & Zamankhan, P. “Granular jet impingement on a fixed target”. Phys. Rev. E 82, 031307 (2010).
Buchholtz, V. & Pöschel, T. “Interaction of a granular stream with an obstacle”. Gran. Matter 1, 33–41 (1998).
Cheng, X., Gordillo, L., Zhang, W. W., Jaeger, H. M. & Nagel, S. R. “Impact dynamics of granular jets with noncircular cross sections”. Phys. Rev. E 89, 042201 (2014).
Sano, T. G. & Hayakawa, H. “Jet-induced jammed states of granular jet impacts”. Prog. Theor. Exp. Phys. 2013, 103J02 (2013).
Johnson, C. G. & Gray, J. M. N. T. “Granular jets and hydraulic jumps on an inclined plane”. J. Fluid Mech. 675, 87116 (2011).
Savart, F. “Mémoire sur le choc d’une veine liquide lancée contre un plan circulaire”. Ann. Chim. 54, 55- (1833).
Clanet, C. “Dynamics and stability of water bells”. J. Fluid Mech. 430, 111–147 (2001).
Guttenberg, N. “Microscopic dissipation in a cohesionless granular jet impact”. Phys. Rev. E 85, 051303 (2012).
Ellowitz, J., Turlier, H., Guttenberg, N., Zhang, W. W. & Nagel, S. R. “Still water: Dead zones and collimated ejecta from the impact of granular jets”. Phys. Rev. Lett. 111, 168001 (2013).
Müller, P., Formella, A. & Pöschel, T. “Granular jet impact: probing the ideal uid description”. J. Fluid Mech. 751, 601–626 (2014).
Sano, T. G. & Hayakawa, H. “Simulation of granular jets: Is granular ow really a perfect uid”? Phys. Rev. E 86, 041308 (2012).
Worthington, A. M. A Study of Splashes (Longman and Green, London, 1908).
Thoroddsen, S. T. & Shen, A. Q. “Granular jets”. Phys. Fluids 13, 4–6 (2001).
Lohse, D. et al. “Impact on soft sand: Void collapse and jet formation”. Phys. Rev. Lett. 93 (2004).
Royer, J. R. et al. “Formation of granular jets observed by high-speed x-ray radiography”. Nat. Phys. 1, 164–167 (2005).
Caballero, G., Bergmann, R., van der Meer, D., Prosperetti, A. & Lohse, D. “Role of air in granular jet formation”. Phys. Rev. Lett. 99, 018001 (2007).
Royer, J. R. et al. “Birth and growth of a granular jet”. Phys. Rev. E 78, 011305 (2008).
von Kann, S., Joubaud, S., Caballero-Robledo, G. A., Lohse, D. & van der Meer, D. “Effect of finite container size on granular jet formation”. Phys. Rev. E 81, 041306 (2010).
Marstona, J. O., Lia, E. Q. & Thoroddsen, S. T. “Evolution of uid-like granular ejecta generated by sphere impact”. J. Fluid Mech. 704, 5–36 (2012).
Li, H., Lee, A., Fan, J., Yeoh, G. H. & Wang, J. “On DEMCFD study of the dynamic characteristics of high speed micro-abrasive air jet”. Powder Technology 267, 161–179 (2014).
Levy, A., Ricard, F., Kalman, H., Peyron, I. & Brosh, T. “DEMCFD simulation of particle comminution in jet-mill”. Powder Technology 257, 104–112 (2014).
Levy, A., Kalman, H. & Han, T. “DEM simulation of particle comminution in jet milling”. Particulate Sci. Technol. 20, 325–340 (2002).
Hogg, A. J., Dade, W. B., Huppert, H. E. & Soulsby, R. L. “A model of an impinging jet on a granular bed, with application to turbulent, event-driven bedload transport”. In Coherent ow structures in open channels. edited by Ashworth, P. J., Bennett, S. J., Best, J. L. & McMelland, S. J. (John Wiley & Sons Ltd., 1996) Chap. 5, pp. 101–124.
Arbalaez, D., Zohdi, T. I. & Dornfeld, D. “On impinging near-field granular jets”. Int. J. Numer. Meth. Engng. 80, 815–845 (2009).
Kuang, S. B., LaMarche, C. Q., Curtis, J. S. & Yu, A. B. “Discrete particle simulation of jet-induced cratering of a granular bed”. Powder Technology 239, 319–336 (2013).
Cheng, X., Varas, G., Citron, D., Jaeger, H. M. & Nagel, S. R. “Collective behavior in a granular jet: Emergence of a liquid with zero surface tension”. Phys. Rev. Lett. 99, 188001 (2007).
Cao, W., Liu, H., Li, W. & Xu, J. “The characteristics of the near fild of the granular jet”. Fuel 115, 17-23 (2014).
Umbanhowar, P. B., Melo, F. & Swinney, H. L. “Localized excitations in a vertically vibrated granular layer”. Nature 382, 793–796 (1996).
Jaeger, H. M., Knight, J. B., Liu, C. & Nagel, S. R. “What is shaking in the sandbox”. MRS Bulletin XIX, 24–31 (1994).
Pöschel, T., Schwager, T. & Salueña, C. “Onset of uidization in vertically shaken granular material”. Phys. Rev. E 62, 1361–1367 (2000).
Renard, S., Salueña, C., Schwager, T. & Pöschel, T. “Vertically shaken column of spheres. Onset of uidization”. Eur. Phys. J. E 4, 233–239 (2001).
Faraday, M. “On a peculiar class of acoustical figures”. Philos. Trans. R. Soc. London 52, 299 (1831).
Melo, F., Umbanhowar, P. B. & Swinney, H. L. “Hexagons, kinks and disorder in oscillated granular layers”. Phys. Rev. Lett. 75, 3838–3841 (1995).
Douady, S., Fauve, S. & Laroche, S. “Subharmonic instabilities and defects in a granular layer under vertical vibrations”. Europhys. Lett. 8, 621–227 (1989).
Pak, H. K. & Behringer, R. P. “Surface waves in vertically vibrated granular materials”. Phys. Rev. Lett. 71 (1993).
Melo, F., Umbanhowar, P. B. & Swinney, H. L. “Transition to parametric wave patterns in a vertically oscillated granular layer”. Phys. Rev. Lett. 72 (1994).
Bizon, C., Shattuck, M. D., Swift, J. B., McCormick, W. D. & Swinney, H. L. “Patterns in 3d vertically oscillated granular layers: Simulation and experiment”. Phys. Rev. Lett. 80 (1998).
Carrillo, J. A., Pöschel, T. & Salueña, C. “Granular hydrodynamics and pattern formation in vertically oscillated granular disks layers”. J. Fluid Mech. 597, 119–144 (2008).
Almazáan, L., Carrillo, J. A., Salueña, C., Garzó, V. & Pöschel, T. “A numerical study of the navierstokes transport coefficients for two-dimensional granular hydrodynamics”. New J. Phys. 15, 043044 (2013).
Huang, K. & Rehberg, I. “Period tripling causes rotating spirals in agitated wet granular layers”. Phys. Rev. Lett. 107, 028001 (2011).
Sack, A., Heckel, M., Kollmer, J. E., Zimber, F. & Pöschel, T. “Energy dissipation in driven granular matter in the absence of gravity”. Phys. Rev. Lett. 111, 018001 (2013).
Bannerman, M. N. et al. “Movers and shakers: Granular damping in microgravity”. Phys. Rev. E 84, 011301 (2011).
Lu, H., Liu, H., Li, W. & Xu, J. “Bubble formation in an annular granular jet dispersed by a central air round jet”. AIChE J. 59, 1882–1893 (2013).
Sack, A., Heckel, M., Kollmer, J. E. & Pöschel, T. “Probing the validity of an effective-one- particle description of granular dampers in microgravity”. Gran. Matter 17, 73–82 (2015).
Acknowledgements
We wish to thank Achim Sack for valuable discussion. This work was supported by Deutsche Forschungsgemeinschaft through the Cluster of Excellence “Engineering of Advanced Materials”. We acknowledge support by Deutsche Forschungsgemeinschaft and Friedrich-Alexander-Universität Erlangen-Nürnberg within the funding programme Open Access Publishing.
Author information
Authors and Affiliations
Contributions
J.E.K. performed the experimental work. Both authors designed the research, discussed the results and wrote the manuscript.
Ethics declarations
Competing interests
The authors declare no competing financial interests.
Rights and permissions
This work is licensed under a Creative Commons Attribution 4.0 International License. The images or other third party material in this article are included in the article’s Creative Commons license, unless indicated otherwise in the credit line; if the material is not included under the Creative Commons license, users will need to obtain permission from the license holder to reproduce the material. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/
About this article
Cite this article
Kollmer, J., Pöschel, T. Subharmonic instability of a self-organized granular jet. Sci Rep 6, 22520 (2016). https://doi.org/10.1038/srep22520
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/srep22520
Comments
By submitting a comment you agree to abide by our Terms and Community Guidelines. If you find something abusive or that does not comply with our terms or guidelines please flag it as inappropriate.